Toyota Tacoma power steering loss problems

Filed May 6, 2026 · Transmission · OH

In October of 2025 I was notified of a safety based recall for my 2025 Tacoma related to the front axle shafts possibly breaking which could cause loss of steering control should an incident occur. The recall is listed as 25TA11, (Interim notice 25TB11) and is attached to the federal safety agency ID 25V656. As of May 6th, Toyota lists this situation as still preparing the remedy. If the situation is truly a safety concern, I believe the length of time Toyota is taking to provide the remedy is unacceptable. I would like to politely suggest that Toyota have pressure put on them to provide the proper remedy in an actual timely manner for something that can cause loss of control or a rolling vehicle in the 'Limited' trim models.

Filed Jan 12, 2026 · Fuel system · 120,000 miles · CA

The contact owns a 2020 Toyota Tacoma. The contact stated that while driving approximately 35 MPH, the vehicle stalled. The vehicle lost power steering assist and brakes, but was able to coast to the side of the road. The contact stated that the low oil and brake warning lights were illuminated, and a message to “Contact Dealer” was displayed. The vehicle was hauled by a friend's truck to a parking lot. The contact used a hand scanner and retrieved fault codes for the fuel pump, brake override, drive start control malfunction, and low oil pressure. The vehicle was towed back to the residence. The contact had not taken the vehicle to a local dealer or independent mechanic to be diagnosed or repaired. The contact researched online and related the failure to the federal safety agency Campaign Number: 20V682000 (Fuel System, Gasoline). The manufacturer was informed of the failure, and the contact was informed that the VIN was not included in the recall. The failure mileage was approximately 120,000.

Filed Oct 20, 2025 · Driver assistance · MT · crash

While driving on a dry, clearly marked two-lane highway in Montana, I had Lane Tracing Assist and Active Lane Keep/Track Assist turned on. My hands were on the steering wheel, speed was within the limit, and visibility was clear. The truck unexpectedly steered itself out of the lane toward the right-side guard rail. There were no audible or visual lane-departure alerts, no “steering assist canceled” message, and the Pre-Collision System did not apply braking before impact. The vehicle struck the guard rail. The system failed on multiple safety layers — no lane warning, no steering correction, and no automatic braking — under normal conditions (dry pavement, well-painted lane lines, daylight). I believe this represents a malfunction or defect in the driver-assist software or sensor calibration for Toyota Safety Sense 3.0. I request the federal safety agency investigate similar incidents for 2024–2025 Toyota Tacoma models equipped with LTA/LDA and Pre-Collision System to determine whether a systemic defect exists.

Filed Aug 9, 2025 · Engine, Steering · NY

I purchased a brand-new 2025 Toyota Tacoma TRD Off-Road. From the first day, the steering wheel was off-center and the vehicle vibrated while driving. At around 500 miles, I noticed severe instability and abnormal tire wear. A wheel alignment report showed: Thrust angle: +0.15° (spec: 0° ± 0.05°) Rear toe: Left 0.23°, Right -0.10° (difference: 0.33°, spec ≤ 0.15°) Front caster: Both sides out of specification (shown in red on report) Driving symptoms include: Cannot maintain straight-line driving; requires constant steering correction. Excessive body roll during lane changes or turns. Continuous vibration of the vehicle and steering wheel on smooth roads. Vehicle bounces and momentarily loses control on uneven surfaces. Steering wheel rotation does not match front wheel steering angle. When stationary, turning the steering to full lock causes the body to rise; releasing it causes it to drop. Attempts to repair at Toyota of Manhattan (June 2025 – August 2025) were unsuccessful. The dealership repeatedly refused to perform proper inspections, provide reports, or acknowledge the defect, despite multiple appointments and a case opened with Toyota corporate. The defect presents a serious safety risk: reduced vehicle stability, increased stopping distance, loss of steering control during maneuvers, excessive and uneven tire wear, and abnormal fuel consumption (13.5 MPG with no load). The problem exists from new and has not been corrected.

Filed Jul 3, 2024 · Steering · 47,000 miles · CA

The contact owns a 2021 Toyota Tacoma. The contact stated while driving at an undisclosed speed, the vehicle lost power steering functionality. The vehicle was driven to the destination. The contact checked the power steering fluid reservoir and discovered that the power steering fluid reservoir was empty. In addition, the contact became aware that the rubber boots on each side of the power steering rack were soaked with power steering fluid. The vehicle was taken to the dealer where it was diagnosed with steering rack failure. The contact was informed that the steering rack needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 47,000.

Filed Aug 8, 2023 · Steering · MA

Sudden and total loss of power steering while backing up to park. There were/are no warning lights or messages displayed on the dashboard. With great difficulty, I was able to drive the car to my local mechanic. Steering was extremely difficult. The power steering unit has been ordered by my mechanic.

Filed Nov 5, 2021 · Steering · NY

my lower [ntermediate steering shaft has to be replaced repair is pending the u joint was so rusted steering was very difficult i noticed that the vehicle steering wheel would not return to normal straight it was a gradual process at least 3 months of minor to very hard steering while having some routine work done it was pointed out to me that it might need to be replaced vehicle is a 2013 tacoma 2wd base

Filed Oct 3, 2021 · Steering · MD

During routine maintenance at a independent shop, the driver side power steering rack boot was found to be leaking. I was informed by a former Lexus master technician that this was a problem with some of the similar Lexus models previously. The vehicle currently had 47,xxx miles which seems very low for a power steering failure. I can provide images of the leak as needed and the vehicle has not been repaired as of this filing.

Filed May 20, 2021 · Steering · OH

This issue has been ongoing. Taken into local Toyota dealer and was told they needed to replace entire rack and pinion at a cost of nearly $1500. Three days after picking up it is doing same thing. While steering around corner it will temporarily lock and suddenly it feels like it has no power steering. I am getting nothing but the run around from Wooster Toyota. My wife very nearly was in an accident because of this. This truck only has 80000 miles. [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Filed May 12, 2020 · Fuel system · NY

Tl* the contact owns a 2018 toyota tacoma. The contact received notification of the federal safety agency campaign number: 20v012000 (fuel system, gasoline) however, the part needed for the repair was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. Js huntington motors (370 oakwood rd, huntington station, ny 11746, (631) 271-6212) was contacted and confirmed that the part was not available. The manufacturer was contacted and made aware of the issue. The contact had not experienced a failure. Vin tool confirms parts not available. *ln consumer stated vehicle was continuously stalling without warning causing a loss of power steering.*jb*dt