I noticed the vehicle frame has 4 holes on the frame. The holes are on the passenger side and driver side near the exhaust manifolds. The holes are approximately 2 to 3 inches in length.
2004 Toyota Tundra body complaints
Page 3 of 8: complaints 41 to 70 of 200, newest first, as owners wrote them.
The frame of this truck is rusted so bad that it seems like it could be unsafe to drive. A couple months ago, the spare tire dropped on the ground due to the hook that keeps it pinned to the vehicle rusted out. Luckily this happened after I returned to my residence and off of the highway where there could have been a dangerous situation to other vehicles and the citizens driving them.
I just purchased this vehicle on 11/16/2019 after doing research into the frame recall/limited safety campaign through toyota. I did not find any results into the vehicles frame corroding or breaking therefore I purchased the vehicle. I then spoke with toyota about the airbag recall on 11/18/2019 and 11/19/2019 and asked if there is/was a recall with the frame. They stated yes and there is nothing I can do because it has expired except for paying out of pocket for the replacement. Now, I noticed the frame has a large hole in it due to rust corrosion located behind the front left wheel. I called toyota corporation twice (11/18/2019 and 11/19/2019) and they told me I have to pay out of pocket for the fix. I then asked why, after searching their website with the VIN , I was unable to locate the recall/limited service campaign. The representative stated " I can't answer that question". If I were able to see that the vehicle had that issue I would not have purchased it. Now the vehicle will not pass inspection and I cannot legally/safely drive the vehicle on the road. Toyota will not replace or fix the frame as they stated that it was a limited service campaign to have the frame sprayed with the anti-corrosion chemical and that the vehicle was not sprayed. Again I did not know this prior to purchase but now I am stuck with a vehicle that I just purchased and cannot drive it. Toyota has not offered a remedy for the situation I am in.
My 2004 toyota tundra sr5 4wd crewcab is showing significant sign of frame rust that's compromising the structural integrity of the frame and thus operational safety of the vehicle. Despite being barely used over the years and at just 144k miles, in certain sections of the frame there are holes where the frame has rusted through. The ride quality feels a bit wobbly, even after examination and rectification of other mechanical issues (suspension, joints, etc.) upon further research, this issue seems to be pervasive issue among first generation toyota tundras made in the us of this period. The result is very premature rust and complete disintegration of the truck frame. The primary cause was poorly made truck frames from a toyota vendor that ended in a class-action lawsuit. Toyota has offered extended recall to inspect and replace all affected truck frames as appropriate. I seek to be included in this program and proper assessment by an authorized toyota dealer. As this issue affects both the resale value of my vehicle and more importantly the operational safety of this vehicle, I request that the issue be expedited by the right authorities. Thank you!
I had recently purchased a 2004 tundra with knowing about the recall for frame rust. I believed toyota had completed the recall and fixed the problem. Not long after owning the vehicle, I noticed a spot of rust bubbling through the anti corrosion coating. After further inspection, the frame is completely corroded through and cracked. This vehicle was meant to use for travel with my family in it and now it's not safe to drive at all.
Tl* the contact owns a 2004 toyota tundra. While the contact was inspecting the rear suspension of the vehicle, he noticed that the subframe, suspension support, and spare tire enclosure were extremely corroded. The contact also stated that the spare tire had separated from the vehicle. The contact was unaware as to when the spare tire detached. The contact stated that the vehicle was inspected in 2015 at mccarthy toyota of sedalia (3110 w broadway blvd, sedalia, mo 65301, (660) 826-5400) per a manufacturer communications regarding frame rust. At that time, the vehicle did not have excessive corrosion. The vehicle was not repaired. The manufacturer was informed of the failure. The dealer was not notified. The approximate failure mileage was 150,000.
Tl* the contact owns a 2004 toyota tundra. The contact detected that the passenger side engine compartment contained a hole and hairline crack. Also, the fuel tank was falling apart and the crossmember was rusted. There were no warning indicators illuminated. The vehicle was taken to carbone toyota of bennington (751 n bennington rd, bennington, vt 05201, (802) 440-1854) where it was determined that the frame needed to be replaced. The vehicle was not diagnosed or repaired. The manufacturer was contacted and did not assist. The failure mileage was 222,877.
Purchased vehicle from private party. Previous owner informed us of frame recall preformed on vehicle 3/2014 stating toyota sprayed frame with rust inhibitor, he complained that he wasn't satisfied with the results. Frame is now unsafe. Reinspected by toyota 8/2019, frame is unsafe but the recall has ended. Vehicle has 133,000 miles and is useless. Toyota put a bandaid on the issue and called it fixed.
I have a 2004 toyota tundra limited 4wd in immaculate condition with 100,000 miles. The frame was sprayed with corrosion at a toyota dealer in 2014. The trucks frame is now completely rusted and not safe to drive. I have called toyota about the issue and they do not seem to care. They should have fixed the issue back in 2014 and this wouldn't have happened.
Tundra frame rot and rust. In 2014, we purchased a 2004 toyota tundra with 90k miles on it for our 16 year old son to drive. Near the time of purchase in 2014, the truck frame was sprayed by toyota under their limited service campaign by the person selling us the vehicle. To our surprise,the truck recently failed inspection for a rusted/rotted frame. The current mileage is 122,892. I contacted toyota and they claim that they addressed the issue with the spraying back in 2014 and are not able to assist further. The federal safety agency, please help us. Toyota will not stand behind the defective frames. Please step up and address this issue with toyota.
Frame has rust holes, per toyota mechanics, my frame continue to rust out cannot pull a trailer with bad frame. Toyota will not honor their work. I am a loyal toyota customer and has a lot of work done by toyota dealer. I need my frame repaired to continue using my truck.
Purchased 2004 tundra new . Never received a recall notice on frame. Have a popping noise underneath the truck. Toyota dealer just called to tell me that my truck would have to be condemned.now I have no trade in , no vehicle. Thank you ,toyota.
Still having major rust issues on frame following 2015 toyota recall to coat the frame.this is a major safety issue and I don't know why toyota stopped at the year 2003 on frame replacements when obviously 2004 year just as bad. Everytime I back out of my garage I see rust debris. Come on the federal safety agency do your job and recall these safety concerns !!!
My frame is rusting almost into, I don't think it was inspected well, and now the rear axle housing is rusted so bad it's leaking fluid
Popping and snapping when turning or going over bumps in road LED to a mechanical inspection. Discovered the frame right behind both front wheels is rusted/rotted such that half or more of it is literally gone. The popping/snapping apparently is caused by the frame kinking and moving at the weakened point and front and back sections contacting each other. I fear that the front part of the truck frame with the wheels, engine, and suspension attached could break and cause loss of vehicle control on the highway.
2004 tundra frame rusted and will not pass inspection. Inspector noted rust holes larger than a quarter.
After I purchased my tumdra used I noticed the frame on this truck has a severe rust issue which I believe could be a safety issue. Large chunks of rust are coming off of the frame I spite of having been 'treated' by toyota in 2015 during a recall campaign . I poked the frame with a screw driver in one location and was able to poke a hole in frame since it was so weak from rusting. I fear the truck breaks in 1/2 or doesn't provide protection in collision. This truck only has 75k miles and is in really good condition with the exception of the frame which is way worse than normal surface rust I've seen. I have read that many other owners are having the same experience. We need help getting toyota to provide a remedy to make our vehicles safe again. Pictures attached
Our 2004 tundra with 65,000 miles was recently identified to have a rusty frame. We put it into the dealership to see what could be done. The dealership deemed it rusty to the point that it could not be coated and was a loss. We contacted toyota and they said the frame programe was for 2000-03 and is now expired and our 2004 wasn't covered. This is a major safety issue. There are hundreds of thousands of trucks on the road that are still affected by the faulty frames and toyota is not doing anything. This leaves consumers with a vehicle that is worthless and dangerous. A recall is needed to protect our families and the roads we travel on. We are going to start seeing vehicles come apart on the roads and killing people.
2004 toyota tundra fame rust prevents vehicle from passing state safety inspection. Never received the "limited service campaign" notifications but toyota will not stand behind their vehicle. "sorry, campaign has expired. We're not responsible for the us mail."
I have a 2004 toyota trundra with only 93,000 miles on it , that has never hardly ever set outside, with frame rust behind front wheels that I can stick my finger though it....it is unsafe to drive on the highway,, and I have not had a recall on frame rust repair.. But have had a air bag and over spare tire support recall ..I only notice this when getting a tire repaired,in april of 2019, it was pointed out to me by repairman, , don't know how long it's been this way
Vehicle frame is rotting. This is a common problem with the toyota tundra. For whatever reason, prior recalls did not apply to the 2004 model year even though the same problem exists when the vehicle is used in areas that are treated with salt during the winter. Frame corrosion has rendered this vehicle unsafe to drive.
Tl* the contact owns a 2004 toyota tundra. While the vehicle was undergoing routine maintenance, the contact was able to see that the frame was rusted. There were no warning indicators illuminated. The dealer and manufacturer were made aware of the failure. The vehicle was not diagnosed or repaired. The failure mileage was 224,300.
Excessive rust on sub-frame of vehicle; frontal sub-frame completely rusted out on vehicle with no apparent body rust; garaged throughout its history; and with less than 100k miles; rear frame rusted
2004 toyota tundra. Consumer writes in regards to severe rotting on frame. *ld
Tl* the contact owns a 2004 toyota tundra. The contact stated that the frame was rusted, rotted, and the bottom portion developed bubbles. The vehicle was taken to lakewood toyota (1118 ocean avenue rt88, lakewood, nj 08710, 732‑364‑9000), but was not diagnosed or repaired. The manufacturer was made aware of the failure and no assistance was provided. The failure mileage was 190,000. .*bf
04 tundra had recall done 5/15, toyota chapmanville wv said undercoating was all needed done. Tundra in another shop at independent shop, they inform me to make appointment with a toyota dealer to have frame inspected asap, and do not tow anything whatsoever. Ball toyota charleston wva refuse to look at, and said nothing they can do, recall has expired, sorry we can't help you.
Frame rusting and rear differential rusting out. Frame is corroding from rust. Rear differential has several pin holes causing fluid to leak. These are both known problems with the gen 1 tundra's. Contacted toyota customer care and basically told me there isn't anything they can do since the frame recall campaign ended in 2015. I never received notification of the frame recall. I was told that there wasn't any recall fro the differential but that is a very common problem for tundra's used in ne USA whereby road salt is used in winter. The salt causes frame and differential rust because material used by toyota is of poor corrosion resistance quality. The consumer iis on their own. Toyota won't do anything even though it's their failure to build the vehicle fit for it's intended use.
Rusted frame' I received a letter for recall from toyota on the rusted frame . So I went to my longtime mechanic and he informed me it was bad, he then began to hit parts of the frame with a small hammer and punched a hole through it and than stoped any more hammering. When I checked my recall VIN# it does not show up, even though I received letters for it.
I received a recall notice and had my vehicle frame inspected in 2014. I was told it was ok and an undercoating was spayed on the frame. On 11-23-2018 I was looking in the engine compartment and noticed a sizable hole in the frame of the vehicle on the passenger side behind the front wheel. I had took it to the dealership and they confirmed the rusted holes on the frame. I was advised it wasn't covered under any current recalls or campaigns and advised to call toyota corporate to ask for assistance. I spoke to a representative and a supervisor and was given a flat no. My vehicle is not covered under any current campaigns or recalls and the repair would be an out of pocket expense. I was informed it is not safe to drive in the cure condition.
Had recall for rust, dealer inspected, said ok and undercoating was done, no now rust holes in frame.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2004 Toyota Tundra?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history