2023 Toyota Tundra: engine knocking or ticking

Filed Aug 27, 2026 · Engine, Lights · GA

2023 Toyota Tundra CrewMax SR5 4x4, VIN [XXX], approximately 79000 miles. This vehicle has two open safety recalls. Both show "Recall Incomplete, remedy not yet available" on the federal safety agency's VIN lookup as of XXX the federal safety agency 25V322 (Toyota 25TB06) was filed XXX for moisture intrusion causing both reverse lamps to fail. Toyota's remedy notice estimated that the remedy would begin to be available in the fourth quarter of 2025. That estimate is now approximately nine months past and no remedy is available for this VIN. the federal safety agency 25V767 (Toyota 25TB14) was filed XXX for machining debris causing number one main bearing failure, with symptoms including engine knocking, rough running, no-start, and loss of motive power. Interim notices were mailed XXX. The remedy has been postponed and remains unreleased for this VIN, with rollout phased by vehicle age. I am filing because the manufacturer has been unable to provide a remedy for either recall within a reasonable time. I have owned this vehicle since XXX and have been unable to obtain repair for a known safety defect for more than fifteen months on the first campaign. I am requesting that the federal safety agency record this delay and address the manufacture's remedy timeline. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 21, 2026 · Engine · OH

Recall # 25V767 has been open since November 6, 2025 and the remedy is not yet available. There is a possibility that certain machining debris may not have been cleared from the engine when it was produced which can lead to potential engine knocking, engine rough running, engine no start, and/or a loss of motive power. I am concerned about this being a major safety issue and also concerned about the fact that the recall has been open since November 2025 and there is still no remedy.

Filed Jul 20, 2026 · Engine, Lights · AZ

2 RECALLS ISSUES: Since I bought that Toyota Tundra from 2023 to now, I was reporting several times issues with knocking engine and losing of engine power (rough running), but service department said nothing happens with. Then, now I have a recall, waiting to get a new engine, that I saw it over the dealer Toyota computer, as the adviser told me "I am in waiting line", but time is running, and no one is contacting me to done it. I am very worry to get issues when I am driving, Then I have to get a long trip no Mexico with the truck, but can not do it like this. Then my reverse lamp lights have a recall too. I'D CONTACT TOYOTA CAMELBACK OF PHOENIX AZ. TWO TIMES, BUT I RECEIVED NO ANSWERS. Thank you so much

Filed May 6, 2026 · Engine · TX

I am submitting this complaint regarding Toyota Motor Sales, U.S.A. and my 2023 Toyota Tundra, which is currently subject to Safety Recall 25V767 involving catastrophic engine failure risk due to crankshaft bearing contamination within the V35A engine. Toyota has acknowledged that my vehicle is included in the recall and has further acknowledged that the engine will require replacement. However, despite confirming the seriousness of the defect, Toyota has refused to repurchase the vehicle and has failed to provide any timeline whatsoever regarding when the engine replacement remedy will become available. Toyota’s position has simply been that the engine will be repaired “once a remedy is available,” without any estimated repair date or meaningful resolution for affected consumers. The recall itself states that the defect may result in engine knocking, rough running, engine no-start, and/or sudden engine stall. Toyota further acknowledges in its recall documentation that engine stall while driving can lead to loss of motive power and increase the risk of a crash. This is a major safety issue, not a minor inconvenience. I live and drive in [XXX] , where highway driving and high-speed traffic are unavoidable. Due to the risk of sudden engine failure or loss of power, my family and I no longer feel safe operating the vehicle under normal driving conditions. As a result, we have drastically limited use of the truck despite continuing to make monthly loan payments, insurance payments, and registration expenses. Additionally, the truck has experienced multiple other recall and repair-related issues since purchase. Several recalls have already required service visits, and additional unresolved recalls remain pending. The ongoing pattern of defects and unresolved safety concerns has substantially diminished my confidence in the reliability, safety, and value of the vehicle. Toyota acknowledges the engine requires replacement, Toyota provides no repair timeline INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION AC

Filed Jan 26, 2026 · Engine, Transmission · TN

On my 2023 Toyota Tundra TRD Pro Hybrid at 72,241 miles, the vehicle started making a knocking noise. Engine turned off and wont start at all. Had the truck hauled to toyota dealership for service. After them having it a week, they called to let me know that the engine is completely locked up. Metal Shavings in the oil and motor wont turn over at all, even with a rachet on the crank bolt. Luckily I bought a extended warranty when i purchased the truck used as toyota is claiming only the non hybrid engines are under the toyota recall for the engines. After reading and researching they have the same engine just one doesnt have the hybrid assist on it. Toyota told me that the extended warranty company was coming today to check it out and would let me know where to go from here. They said its a very very uncommon issue on the hybrids but after researching that, that was a lie.

Filed Jan 26, 2026 · Engine, Transmission · AZ

Engine started knocking, complete loss of power and had to pull over immediately to avoid any further issues such as an accident

Filed Dec 26, 2025 · Engine · KY

On December 23, 2025, while driving at highway speeds, I began to hear a loud knocking sound. The sounds increased and a "low oil pressure" warning appeared on the dash. I began to loose power and the knocking sounds increased. I was able to carefully get the truck off the highway and parked to be towed to a local dealership. The loss of power while on the highway put myself and my family at risk due to not being able to keep at speed with traffic, and the possibility of being stuck on the side of a highway if I was unable to make it to the next exit. The vehicle experienced the same symptoms prior to the engine seizing in July of 2025. At that time the vehicle was not included in a recall campaign, and a short block replacement, rather than a complete engine replacement, was completed by Toyota.

Filed Dec 24, 2025 · Electrical, Engine · TX

While driving today the engine check light turned on, and the engine turned off (stalled) while in the middle of the road with a good amount of traffic around me. I pulled off to the side of the road and gave the engine a minute. I turned the truck back on again, the engine sounded very rough turning on and rough while driving. After a minute or two of driving, the engine light turned on again, and the engine stopped (stalled) again while in the middle of the road. I stopped this time for two minutes or so and turned the engine on again. I then proceeded to try to make it home, which I accomplished, but the truck's engine sounded rough and with a chattering sound (engine knocking) even when idling. I have received a recall notice letter concerning " Certain 2022-2024 Model Year Tundra Vehicles Engine May Stall During Driving." I possess the letter with the federal safety agency Recall Number and the Toyota Recall Number. In the letter, it mentions the condition for which it is being recalled. The conditions are as stated in the letter. "Machining debris may not have been cleared from the engine when it was produced. In the involved vehicles, this can lead to engine knocking, engine rough running, engine no start, and/or a loss of drive power. A loss of drive power while driving can increase the risk of a crash." My truck has experienced all of the disfunctions that are stated in the recall letter. I would like for Toyota to look into this and remedy this problem before it ends in a major fatal crash or any other unfortunate circumstance. Thank you!

Filed Dec 18, 2025 · Engine · SC

My Toyota Tundra (2023) has a recall notice due to possible debris in the engine that is over a year and a half old. This still has not been repaired by the manufacturer. I can hear sounds like knocking coming from the engine and I am concerned that the vehicle could stall or stop while driving on the highway with my children and cause a severe crash. How do I get the vehicle engine replaced expeditiously? The Recall is 24V381.

Filed Dec 17, 2025 · Engine · TX

The vehicle is affected by a manufacturer safety recall related to the engine. According to the recall, machining debris may not have been properly removed during engine production. This can lead to engine knocking, rough running, failure to start, loss of power, or the engine stalling while driving. The manufacturer has stated that the fix will require replacement of the engine assembly, but the remedy is not yet available. Because of this, the vehicle continues to be driven with a known engine defect and no repair timeline. The main safety concern is the risk of sudden loss of power or engine stall while driving, which could be dangerous, especially at highway speeds or in traffic. The vehicle has been inspected by a dealer, who confirmed that the recall applies but could not perform a repair, provide a timeline, or confirm that the vehicle is safe to drive while waiting for the remedy. No crash or injury has occurred so far. There have been no warning lights or specific failure events yet, but the concern is based on the acknowledged manufacturing defect and the possibility that the issue could occur without warning. The vehicle is still being driven because there is no available repair, no clear safety guidance from the manufacturer, and no alternative transportation or loaner vehicle provided. The concern remains that the vehicle could unexpectedly lose power or stall, putting the driver and others at risk.

Filed Dec 5, 2025 · Engine · TX

I was driving on the highway at 55 mph when my engine suddenly began making a loud knocking noise and lost power. I immediately pulled over, but as I was doing so, the vehicle lost all power and the engine light came on. This was a dangerous situation because I was in the middle of traffic and almost got rear-ended as I couldn’t keep up with the traffic speed. Let alone the warning light didn’t come on until I lost all power to the engine. This is a 2023 Hybrid Limited with under 15,000 miles! I could not believe it as I just got rid of my 2022 Tundra Limited with engine issues and purposely got a hybrid to avoid engine problems. Toyota, what on earth are you doing?!

Filed Nov 10, 2025 · Engine · CO

October 6th 2025, I was leaving my place of work and started to here a slight banging/knocking sound, the vehicle lost instant power and I the engine quit running, I have taken the vehicle to the Toyota dealer and they have confirmed a internal bearing failure in the engine. The vehicle is not part of the engine recall but appears to be the same issue. The Toyota dealership has agreed that it is still with in the warranty period after review of there regional representative and agreed to replace the engine short block and rebuild the remaining engine components. I towed it to the dealer October 6th and have been given a rough timeline for repairs to be performed roughly around December based on the availability of parts.