2024 Toyota Tundra: won't start

Filed Sep 15, 2026 · Engine, Transmission · TX

On XXX6, while driving on the highway at approximately 89 mph and 36,714 miles, the engine misfired and the vehicle began shaking. The check engine light started flashing and a "reduced power, visit dealer" message appeared, along with a loss of motive power. The vehicle was taken to an authorized dealer on XXX at 37,032 miles. The dealer's repair order documents stored diagnostic trouble codes for random misfires, and states that freeze frame data confirmed misfires on cylinders 3, 4 and 5 at 89 mph and 2700 rpm in direct injection mode. Despite this, the repair order was closed as "no issue found." No repair and no further diagnosis was performed. The dealer stated the condition could not be duplicated after driving the vehicle and idling it for about an hour. The vehicle is subject to an open safety recall for machining debris in the engine (the federal safety agency 25V767, manufacturer 25TB14), for which no remedy is available. The recall summary lists engine knocking, rough running, no-start and loss of motive power as symptoms, and instructs owners experiencing symptoms to contact their dealer. When contacted, the dealer stated the manufacturer is still developing a remedy and that the vehicle can either wait indefinitely or be picked up as is. The defect remains undiagnosed and unrepaired. The vehicle is available for inspection. The safety concern is a sudden loss of motive power at highway speed, which is the same risk identified in the manufacturer's own recall filing. No remedy has been made available more than ten months after the recall was filed. Video of the failure as it occurred, showing the check engine light flashing and the loss of power: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 4, 2026 · Engine · IL

Engine shutdown while driving (was towing a travel trailer at the time) and after coasting to a stop the engine would not start. After 10 minutes the engine would start, but had loud knocking. My 2024 Tundra only had 31,726 miles and had to be towed to the dealership. Seems to be the known engine issues with the redesigned v6 engine. Tundra has been in the dealership for 4 weeks and was told it will require engine replacement, but do not know when the new engine will be shipped. While Toyota will perform the replacement free of charge, based on the hundreds of thousands of Tundra's being recalled for this very issue, I no longer trust this engine design (replaced or not).

Filed Jun 16, 2026 · Electrical, Engine · TX

Vehicle has two open Toyota safety recalls that have remained unresolved for over a year. the federal safety agency campaign 25V322 (manufacturer no. 25TB06) covers reverse lamp assembly corrosion. the federal safety agency campaign 25V767 (manufacturer no. 25TB14) covers a V35A engine manufacturing defect where leftover machining debris can damage the main bearing, leading to engine knocking, rough running, no-start, or loss of drive power while driving. No engine symptoms have occurred to date. However, the vehicle is used for rideshare and delivery work, meaning passengers and cargo are regularly on board while this known defect remains unremedied. The dealership stated it could not address the engine recall and directed me to Toyota corporate. Toyota corporate opened a case and confirmed no remedy is currently available for this recall. The vehicle has not been inspected by the dealer or manufacturer, as no repair or inspection procedure has yet been provided to perform one. No warning lamps or dashboard messages have been observed. Vehicle is available for inspection upon request. Concern: a known crash-risk engine defect (loss of drive power) has been acknowledged by the manufacturer for over a year with still no completed remedy, while the vehicle continues to be operated commercially with passengers.

Filed Jun 1, 2026 · Engine · FL

Vehicle Information: 2024 Toyota Tundra 4x4, VIN: [XXX] livery: [XXX] Current Mileage: 24,147 Complaint Synopsis: My 2024 Toyota Tundra is subject to two active open safety recalls with no remedy available ("NO FIX YET" status per Toyota owner portal). 1. What component(s) or system failed or malfunctioned, and is it available for inspection upon request? Primary: Engine assembly (Recall 25TB14 / 25TA14) – machining debris left in the engine during manufacturing. This can cause engine knocking, rough running, no-start, and sudden loss of motive power. Secondary: Reverse lamp system (Recall 25TB06 / 25TA06) – moisture intrusion causing both reverse lamps to become inoperable. The vehicle remains available for immediate inspection at Clearwater Toyota or by Toyota representatives. 2. How was your safety or the safety of others put at risk? The engine defect creates a severe risk of sudden loss of motive power while driving at highway speeds, which can cause loss of vehicle control and increase the likelihood of a crash. The reverse lamp defect eliminates rear visibility and brake indication when backing up in low-light conditions, significantly increasing the risk of collisions with other vehicles or pedestrians. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? The defects are formally admitted by Toyota through active the federal safety agency safety recalls. Clearwater Toyota has refused multiple requests for inspection and service documentation. No independent inspection has been performed due to Toyota’s refusal to schedule one. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No. Toyota has not conducted a physical inspection of my vehicle despite repeated requests. Clearwater Toyota provided a temporary loaner vehicle but has refused to inspect or document the recalled conditions. No police or insurance inspections have occur INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 19, 2026 · Engine · MI

While driving highway speeds. The vehicle lost power. A warning light came on saying no power to the vehicle. The sudden lost of power to vehicle locked my power steering. Vehicle would not drive. When attempted to restart vehicle. The vehicle would not turn over and burning smell came from vehicle. Toyota stated it was the engine that failed due to recall 25TB14. It’s now 05/19/2026 and no repairs have been completed and no expected repair date.

Filed Dec 1, 2025 · Electrical, Engine · WI

I am the second owner of a 2024 Toyota Tundra that is branded as a manufacturer buyback/lemon. The first owner had the engine short block replaced at around 31,000 miles due to bearing failure. I later bought this truck at around 36,000 miles specifically because Toyota stated that the engine problem had been fixed with the short-block replacement. I relied on that representation and believed I was buying a vehicle whose defect had been properly remedied. Toyota has now issued safety recall 25V767 / 25TA14 (“engine may stall during driving”) for this same V35A engine, including service short blocks. I am concerned that the earlier short-block repair either did not fully fix the underlying defect or may have introduced additional problems. At around 41–42k miles, the truck developed starting issues and then completely failed to start, leaving me stranded in the middle of an intersection in town. The vehicle would not crank or start and had to be towed out of traffic, which I consider a serious safety risk. The dealer ultimately replaced a 50-amp fusible link, the 12V battery, and the starter. The total repair bill was about $2,100 before my third-party extended warranty paid a portion of it. Even with that coverage, this is an extremely expensive repair for a relatively new truck that has already had major engine work. Now I have engine history, electrical/starter problems, and I do not know what other issues may appear. I trusted Toyota’s assurance that the engine problem was fixed, and that is why I felt comfortable buying a branded lemon; this now feels like I was misled or cheated. I am also aware of ongoing engine and reliability complaints on newer 2024–2025 Tundras, which suggests there may be a broader design or quality issue. My concern is that my truck remains defective despite the prior engine short-block replacement and that other owners could experience similar no-start or stall situations in traffic.

Filed Oct 22, 2025 · Engine · AZ

Was driving at approx 35mph when engine started making clanking noise and truck shut off. Stalled on main road and barely made it into parking lot. Tried to started it again and did not start. Had truck towed to dealership where dealership assumed engine has ceased at 32k miles. No warning, messages, or symptoms.

Filed Sep 11, 2024 · Transmission · MD

I purchased the vehicle from a Toyota dealer 10 days ago. since then I have driven about 500 miles. I started the engine this morning (09/11/2024); but it will not start. This is a hybrid vehicle. I read the user's manual, which says a green "READY" indicator on the instrument panel should be on if hybrid system is normal. The green indicator was not on; it blinked briefly when I pushed the POWER button, then it disappeared. The vehicle is unable to move either forward or backward. I just called Toyota Roadside Assistance. It sent a two truck to it to a nearby Toyota dealer for inspection & repair.