Volkswagen Jetta fire or smoke problems

Filed Jul 29, 2026 · Engine, Transmission · CA

Note: (never has any issues before ever as vehicle always maintained and taken directly to vw for maintenance.) /-/———————————————— I was driving: came to a stop: light turned Green proceeded to go through intersection YET VEHICLE. KT NOT MOVE! Put lever into park: turned off car and turned back on : put thr stick BACK INTO DRIVE - NOTHING HAPPENED I GUNNED it BY pushing my foot on the gas VW Jetta ALMOST REDLINED but didnt: was able to get across the interaction as I turned Left . Car sputtered: Car died: CAR CAUGHT FIRE! put fire out with towel: transmission fluid expelled: Car SEIZED ALL MOVEMENT Car would turned on with push start: could put in ALL GEARS BUT WOULD NOT MOVE

Filed Mar 18, 2026 · Brakes, Driver assistance · 177,000 miles · MA

The contact owns a 2009 Volkswagen Jetta. The contact received notification of the federal safety agency Campaign Number: 16V913000 (Service Brakes, Hydraulic, Electronic Stability Control (ESC). The contact stated that while driving on several occasions at various speeds, there was a burning odor coming from outside the vehicle, and the odometer was inoperable. The ABS, Brake, DRL, and EPC warning lights were illuminated. During the failure, the vehicle drove like the parking brake was engaged. The contact stated that on two separate occasions, while driving and experiencing the failures, the vehicle was pulled over to the side of the road, and the contact exited the vehicle, and observed smoke coming from all four wheels. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the cylinder to the ABS module had failed to communicate with the computer and needed to be replaced. The vehicle was not repaired, but the contact was made aware of an associated recall. The vehicle was taken to a dealer where it was diagnosed, and determined that the ABS module was inoperable and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, and a complaint was filed. The failure mileage was 177,000.

Filed Dec 3, 2025 · Engine, Fuel system · VA · fire

The fuel rail bolts on the car loosened, one sheered off. Fuel poured from the front end of the car. When the car was started, to be placed on a flatbed the car caught on fire. The car is currently at a mechanics, but has not been repaired. The car could have easily caught on fire while being driven or started any time before or after it actually caught on fire, it was only taken care of quickly as the tow truck driver had a fire extiguisher, we do not carry one in the car. The car had the recall work done in 2021 in Tyson's Corner VA. The dealer refuses speak to us and states that the recall was done and therefore not their issue. The issue was confirmed with the new mechanic. There was one EFC light on the night it started leaking fuel.

Filed Aug 26, 2025 · Engine, Fuel system · LA

The turbocharger is out. I've had problems with coolant leaking. Mechanic pressurized tank, its fine. While parked coolant disappears, evaporates, idk..Nothing leaking on ground. Now smoke coming out of exhaust. Car has 56,000 miles.

Filed Aug 8, 2025 · Engine · 18,078 miles · NY

The contact owns a 2024 Volkswagen Jetta. The contact stated that at start-up, there was an abnormal amount of white smoke coming from the exhaust pipes. There was no warning light illuminated. The vehicle was taken to a local dealer where it was diagnosed, and the contact was informed that a cause for the failure was not found. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 18,078.

Filed Jul 21, 2025 · Electrical, Steering · 131,260 miles · CA

The contact owns a 2012 Volkswagen Jetta. The contact stated that for the past eight months, the contact was unable to remove the key from the ignition. Several warning lights were illuminated. The contact stated that to start the vehicle, the contact had to plug in the two fuse boxes and connect the battery cable. The contact feared the vehicle might catch on fire. The contact received notification of the federal safety agency Campaign Number: 19V615000 (Electrical System, Steering). The vehicle was taken to the dealer; however, the contact was informed that pre-existing repairs needed to be performed before the recall repair could be performed. The contact stated that the dealer had not provided an official repair estimate, however the total repair cost was provided. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure but provided no assistance. The manufacturer confirmed that the pre-existing repairs needed to be performed prior to the recall repair. The failure mileage was approximately 131,260. Parts distribution disconnect.

Filed Jul 15, 2025 · Brakes · CA · fire

driving on freeway (speed around 70mph) out of nowhere i start smelling strange burning smell then about 1 minute later the car brakes lock up in the front and I loose control of car but luckily it was in light traffic and I regained control enough to get it off to the shoulder. I got out to address the issue and notice the front tires smoking alot and it was at night and the inside (rotor, brake caliper, and rim were glowing bright red and the heat was melting the tire". Then I notice a flame and grabbed a bottle water and applied the tire and extinguish it. I sat there for a good 30 minutes to let everything cool down and the car would not move. "THIS IS A SERIOUS SAFTEY RECALL" AND IF IT'S NOT IT SHOULD BE ADDRESSED A.S.A.P PLEASE ADDRESS THIS ISSUE WITH VOLKSWAGON! AND HAVE THIS SERIOUS SAFTEY ISSUE CORRECTED thank you.

Filed Jun 17, 2025 · Electrical, Engine · PA

My Volkswagen Jetta shut off driving down interstate 99 due to major fuel leak (fuel rail bolt broke) I saw Volkswagen had a recall for fuel rail bolt coming loose after time. I called Volkswagen states recall was completed in May 2021 I bought the car May 2025. I asked Volkswagen rep if they would repair it as this is the same issue as the recall obviously it isn’t corrected. This could have been very bad with fuel leaking along a major highway one thing ignited and car would have went in flames. My son could have been seriously injured or even killed! EPC light came on as this was happening. The car is at my local mechanic who advised me to call Volkswagen due to an open recall for this issue. Volkswagen rep states I could take it to Volkswagen dealer to have it looked at but advised it would be at my expense. The only way anything would be done or reviewed if the car caught on fire or someone died. I would like this looked into as I believe vw should pay for my car to be fixed. Since the known problem was not fixed. I don’t have any documentation as my car is still in the process of getting fixed.

Filed Feb 12, 2025 · CA · fire

At around 5am on februaury 7, 2025 I was awoke by my roommate screaming my car was on fire. When I went outside I seen my neighbor and roommate attempting to put out a fire in the engine of my car. My car had been parked for at least 5 hours and was not running. My neighbor stated that he looked out his window and saw flames and ran across the street where he started to extinguish the fire with my water hose until fire and police assistance arrived. There was no one in the car, or around the car, the fire spontaneously started. I had no prior warnings that would be cause for concern of an engine fire. The car burnt to total destruction. It is located at my address. It is available for inspection on request. I am financing the car from shaws auto since 08/23/2024. Shaws auto has been notified of the incident. The firemen stated that it was caused by a manufacturer defect. I am uploading pictures of my car. I am still acquiring official incident reports. Attempted to upload photos of vehicle post fire but to no avail. This incident has taken a significant amount of mental, physical, and spiritual energy in order for me to stay intact. This is my first opportunity at buying a newer car that I was under the expectation that I wouldnt be under constant worry that something was going to go wrong with my car costing me money I dont have. I newer car shouldve brought me at least a few years use before concern for any kind of wear and tear issues arise. This engine fire was not my fault or cause therefore I should be compensated with a car of which ican rely on. I was never notified of any recalls on my car and was not aware of any until after the fire. Had I known there was an urgent recall I would have corrected it.

Filed Dec 2, 2024 · Electrical · MN

PTC Heater - Driver side footwell short / overheating Burning smell Climatronic temp set to warm Fan speed on or off Outside air temperature below 35deg fahrenheit Burning plastic and vapor starts filling the cabin within 10 seconds Fear of vehicular fire or related health effects from exposure. No warning codes or lights to indicate an issue.