The contact owns a 2010 Volvo XC90. The contact stated while driving 70 MPH, the vehicle stalled with the check engine warning light illuminated. The contact attempted to restart the vehicle, but the failure persisted. Due to failure, the vehicle was towed to the residence. An independent mechanic arrived at the residence and discovered a leak in the fuel line. Upon investigation, the contact linked the failure to the federal safety agency Campaign Number: 10V147000 (Fuel System, Gasoline). The vehicle was not repaired. The failure mileage was approximately 125,000.
The worst 2010 Volvo XC90 problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Fuel system4
- Body2
- Steering2
- Tires2
- Airbags1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Fuel system4
- Body2
- Steering2
- Tires2
- Airbags1
- Brakes1
- Engine1
- Visibility1
- Wheels1
Recalls 3
Steering
- What is wrong
- Volvo is recalling certain model year 2010-2011 xc90 vehicles manufactured from january 29, 2010, through august 16, 2010. The power steering fluid may leak from the oil pipe connection at the steering gear valve housing.
- Risk
- This condition could lead to a sudden loss of power steering, increasing the risk of a crash.
- Remedy
- Dealers will replace the oil pipes on the power steering rack free of charge. The recall is scheduled to begin during june 2011. Owners may contact volvo at 1‑800‑458‑1552.
Recall number 11V286000 · Recall details
Equipment: electrical: navigational system(global positioning system)
- What is wrong
- Volvo is recalling certain vehicles equipped with garmin 760 portable global positioning system (GPS) units because the batteries on those units may overheat.
- Risk
- An overheated battery could lead to a fire.
- Remedy
- Volvo advises owners to please stop using the garmin portable GPS device immediately, and visit the garmin website to determine if their unit is affected. The unit's battery will be replaced with a new battery and a spacer will be inserted on top of the battery next to the pcb. This service will be performed free of charge. The safety recall began on november 18, 2010. Owners may contact garmin at 866‑957‑1981 or visit garmin's website at www.garmin.com/nuvibatterypcbrecall.
Recall number 10V566000 · Recall details
Fuel system, gasoline: delivery
- What is wrong
- Volvo is recalling certain model year 2010 xc90 vehicles. A leak may develop in the fuel line between the line and a connector.
- Risk
- Fuel odor may be detected. A fuel leak in the presence of an ignition source can lead to a fire at the right front wheel.
- Remedy
- Dealers will inspect the date code printed on the fuel line and replace the fuel pressure line if it falls within the recalled range free of charge. The recall began on april 23, 2010. Owners may contact volvo at 1‑800‑458‑1552.
Recall number 10V147000 · Recall details
Technical service bulletins for the 2010 Volvo XC90 217
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- This is a Technical Journal: Text plus 2 PDFs and 1 .PNG Oil Consumption test
- This is a TJ text only
- This is a Technical Journal
- This is a Technical Journal: Remote connection, BOMGAR application
- Unknown or other
- This is a Technical Journal: Vehicle/Connectivity report checklist
- Information about valid Software partnumbers to order and download Software for "PDS" Pre-Delivery Service
- This is a Technical Journal: 12V Battery Testing Method
- Complimentary upgrade C00009 description.
- Rubber cushion
2010 Volvo XC90 fuel economy
Official EPA estimates in miles per gallon (MPGe for electric). Ranges cover trims that share the same engine.
| Engine | Drive | City | Highway | Combined |
|---|---|---|---|---|
| 3.2L 6‑cyl | FWD | 15 | 22 | 18 |
| 3.2L 6‑cyl | AWD | 15 | 21 | 17 |
| 4.4L 8‑cyl | AWD | 13 | 19 | 15 |
What 2010 Volvo XC90 owners say
Most recent owner complaints, unedited.
I was driving my wheel locked I cannot turn my wheel
Engine stalled and shut down at highway speed of approximately 70 MPH. Two consecutive tankfuls at about 1/4 tank or 135 miles to empty. Check engine light came on. Restarted engine and limped to nearest gas station. After fillup engine light cleared and it drove fine until down to approx a quarter tank again when it reoccurred.
The vehicle gets a strong gas smell inside the driving area when gas tank filled. No fuel found to be leaking. Smell comes from under floor by backseats
Steering often shakes and is hard to control going over 50 miles per hour. Steering column sticks at times and then is very wobbly.
Drove volvo one day ago and while driving on rural highway road early morning in the dark, vehicle without warning totally shut down in middle of road and stalled out. Had to veer off road and coast on incline with not much momentum due to cars behind me. Was dangerous situation, but luckily got vehicle into small ditch off road . Had to be towed to garage as would not restart. Was advised by volvo dealer after diagnostic that fuel pump was bad and part burned out inside it and needs replaced. About a little less then a year ago vehicle began to shake upon start and wanted to stall, was checked out and thought maybe bad gas as no further symptoms. Nothing happened after and car ran normally until incident 1 day ago.
Tl* the contact owns a 2010 volvo xc90. The contact stated that the dashboard had deteriorated to the point where it was structurally unsound and buckling in the area of the front passenger side air bag component. The dealer (volvo escondido, 1938 auto park way, escondido, ca 92029) was notified and stated that the failure could have been caused by extreme heat. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was not available.
The drivers side view mirror has loosened without evidence of trauma. It is difficult to maintain visibility without opening the window and manually pushing the mirror casing outward. It moves when the car is in motion and when stationery.
The spare tire cable assembly broke, causing spare tire to drop from under vehicle while parked in garage. The cable assembly dismounted from the carrier nut. Spare tire has never been used my owner. If vehicle was traveling on road at time of cable malfunction, would have caused an accident or possible death. Please advise!
Startlingly loud pop when driving at 70mph on interstate. Pulled off to check tires in thick morning rush hour traffic and did not notice sunroof had shattered until some miles later when I continued to hear gravel rolling around on top of my car. A large chunk of window had flown off the back, apparently. Fortunately, screen was closed. And,the cars behind me were not effected. I do not recall anything hitting the sunroof nor was I behind any trucks that may have had loose rocks. Cost to repair is $935!!, all out of pocket since my deductible is $1000. This should not have happened! Volvo service tells me this happened to another car recently!!
Compare the 2010 Volvo XC90
XC90 vs Acura MDXXC90 vs BMW X5XC90 vs Audi Q7XC90 vs Lexus RXXC90 vs Mercedes-Benz GLE 350XC90 vs Cadillac XT5
Other model years
2003200420052006200720082009201020112012201320142016201720182019202020212022202320242025
Questions about the 2010 Volvo XC90
Is the 2010 Volvo XC90 reliable?
Owners have filed 12 complaints about the 2010 Volvo XC90, fewer than a typical XC90 model year.
What is the 2010 Volvo XC90 year score?
The 2010 Volvo XC90 scores 90 out of 100 (good). The score compares it with the other model years of the Volvo XC90: 75 is a typical year, 50 means twice the usual complaints, and serious complaints and recalls lower it.
What is the most common problem with the 2010 Volvo XC90?
Fuel and propulsion system, with 4 complaints. Next is body (2).
How many recalls does the 2010 Volvo XC90 have?
3 recalls, covering steering, equipment and fuel system, gasoline.
Was there a recall on the 2010 Volvo XC90 fuel system?
Yes, 1 recall: 10V147000. Check your VIN to see if your car still needs the free repair.
What year does the Volvo XC90 have the most fuel system problems?
The Volvo XC90 model years with the most fuel system complaints are 2004 (77 complaints), 2005 (33 complaints) and 2016 (13 complaints).
Is there a class action lawsuit over the Volvo XC90?
Yes. New class action says Volvo's Google-based infotainment screens freeze and take climate and rearview camera with them (November 9, 2026).
What gas mileage does the 2010 Volvo XC90 get?
Official estimates for the 2010 Volvo XC90 range from 15 to 18 mpg combined. The most efficient version (3.2L 6-cyl, FWD) gets 15 city and 22 highway.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2010 Volvo XC90?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history