2021 Volvo XC90 problems

Filed Nov 4, 2026 · Electrical, Engine · VA

Electrical system shutdown during use rendering car unable to shift out of park. According to dealer, the extensive electrical and wiring damage resulted from a clogged sunroof drain. This issue is well documented for a decade or longer and is clearly a safety problem (vs "maintenance" or "wear & tear") as vehicles are rendered useless on the roadway. I do not understand why the federal safety agency has not issued a recall. Is this the federal safety agency Mission Statement no longer relevant? "the federal safety agency's MISSION Save lives, prevent injuries and reduce economic costs due to road traffic crashes, through education, research, safety standards and enforcement activity."

Filed Oct 29, 2026 · Body, Electrical · MN

The rear passenger-side door latch on my 2021 Volvo XC90 failed, and the door will not open from inside or outside. This prevents an occupant from exiting through that door, including in an emergency or after a crash. The failure occurred on XXX at approximately 45,000 miles while the vehicle was in normal use. I have small children and they are now not able to get out of the car so this is a major safety issue. There was no crash or injury. Borton Volvo ([XXX]) diagnosed a failed door latch assembly and quoted $1,106 to replace it. Volvo declined goodwill coverage. Owner reports indicate door latch failures are common on 2016+ XC90 models INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 16, 2026 · Electrical · PA

The check engine light on our Volvo XC90 Plug-in Hybrid came on stating "Hybrid System Failure Service Required". The vehicle would no longer accept a charge. A service appointment was made and the technician found that there was a fault with cell module A. A case was started but we were told the part was on backorder.

Filed Oct 11, 2026 · MA · 1 injury

The chrome trim on the center console, immediately to the right of the gear selector, deteriorates and peels away, leaving razor-sharp edges capable of cutting skin. This appears to be a widespread issue, with numerous owner reports and photographs online dating back to the 2016 Volvo XC90. The same defect is present on my 2021 model, suggesting Volvo has continued using a component prone to this failure for multiple model years. The location is particularly concerning because drivers frequently place their hands near this trim when operating the gear selector and using the center console. Owners have reported cuts and bleeding from the sharp edges, creating a potential risk of sudden driver distraction. This is a recurring safety concern involving a factory-installed component, not simply a cosmetic defect, and warrants investigation by the federal safety agency.

Filed Oct 5, 2026 · Seat belts · MA

This is 2021 volvo xc90 purchased new in 2021. A few weeks ago, my wife asked me to look at the middle row seatbelt as it wouldnt buckle. I could see that it was broken. I checked the seatbelt next to it and same thing. Plastic buckle broken in same place. I took it to the dealer where we get serviced and they told me it would cost $900. I told them this should not be my expense as this is a manufacture defect. Car was bought new 5 years ago. I brought the car home and then checked all seatbelts. 4 out 6 (have a third row) all have the same issue! I created a case with Volvo corporate. I was offered a 20% discount on parts only. I told them this was unacceptable and they then closed the case as they said i declined their assistance. Dealer told me it would cost about $1500 to repair all 4.

Filed Sep 25, 2026 · Electrical · CA

My 2021 Volvo XC90 Recharge (plug-in hybrid) has been at Volvo Cars Dublin, Dublin CA since June 15, 2026 for a failed high-voltage battery cell module requiring replacement. The replacement part is on national backorder with no estimated availability. The vehicle has been out of service for over 100 days and remains undrivable. A failed high-voltage battery cell module in a plug-in hybrid is a safety concern, and the indefinite nationwide backorder suggests this defect and parts shortage may affect other owners. Volvo corporate (case 07207782) has provided no repair date.

Filed Sep 25, 2026 · Electrical · CA

My 2021 Volvo XC90 Recharge (plug-in hybrid) has been at Volvo Cars Dublin, Dublin CA since June 15, 2026 for a failed high-voltage battery cell module requiring replacement. The replacement part is on national backorder with no estimated availability. The vehicle has been out of service for over 100 days and remains undrivable. A failed high-voltage battery cell module in a plug-in hybrid is a safety concern, and the indefinite nationwide backorder suggests this defect and parts shortage may affect other owners. Volvo corporate (case 07207782) has provided no repair date.

Filed Sep 21, 2026 · Electrical · 60,000 miles · WA

The contact owns a 2021 Volvo XC90. The contact stated that while driving at various speeds and depressing the accelerator or the brake pedal, the vehicle hesitated with the check engine warning light illuminated. The dealer was contacted. The vehicle was taken to the dealer to be diagnosed, and it was determined that the electric rear axle drive system had failed and needed to be replaced. The contact stated that the failure occurred each time the vehicle was driven. The manufacturer was notified of the failure and informed the contact to continue driving the vehicle because the vehicle was safe to drive. The failure mileage was approximately 60,000.

Filed Sep 10, 2026 · CA

I am reporting a serious safety defect involving a Nuna RAVA child safety seat. The harness straps loosened on their own without the harness release button being pressed or otherwise intentionally operated. This occurred while the child was secured in the car seat. This malfunction presents a serious risk to child safety. If the harness loosens during vehicle travel, particularly in a sudden stop or crash, the child may not be properly restrained. In a crash, the child could potentially move out of the appropriate restraint position, be partially or completely ejected from the car seat, or suffer serious injury. The component involved is the harness restraint system, specifically the mechanism or component that is supposed to maintain the harness straps at the properly tightened position. The car seat is still in my possession and is available for inspection. I also have video footage of my child in the carseat while it was malfunctioning. I reported this safety concern to Nuna, the manufacturer, but Nuna has not responded to my safety complaint or inspected the car seat. I am requesting that the federal safety agency investigate this issue because an unintended loosening of the harness can compromise the effectiveness of the child restraint and potentially place a child at serious risk of injury or death in a crash.

Filed Aug 22, 2026 · Electrical, Engine · WA

In February 2026, my 2021 Volvo XC90 Recharge T8 (VIN: [XXX]) experienced a hybrid battery cell failure. The failure was diagnosed and confirmed by an authorized Volvo dealership (Volvo of Tacoma) and is covered under the vehicle's manufacturer warranty. However, I have been informed that a replacement part may not be available until December 2026 or later — a delay of ten months or more from the original failure date. Volvo has advised me that attempting to charge the vehicle in its current state carries a risk of fire. As a result, I am unable to charge the hybrid system and have had to operate the vehicle on gasoline alone, with fuel costs increasing approximately 3.5x per month. Separately, an independent mechanic has advised me that continued operation of the vehicle without a functioning hybrid battery cell is causing ongoing, worsening mechanical damage over time, separate from the original defect. I have made extensive good-faith efforts to resolve this directly with Volvo Cars USA customer care, including phone calls, an online request form, and direct correspondence, with prolonged periods of no response despite written acknowledgment of the issue on XXX. Given that Volvo itself has identified a fire risk associated with charging this vehicle, combined with an indefinite repair timeline of ten months or more and mechanic-confirmed risk of continued mechanical degradation, I am filing this report to document a potential safety defect in the hybrid battery system of this vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)