Suspension subframe crossmember (Upper)(part number 8K0505235AQ) has severe rust Corrosion perforation, and is available for inspection. Fear of unsafe vehicle operation due to the Structural integrity being severely compromised rendering the vehicle unsafe to operate. The rusted subframe as been confirmed by an Audi dealer and an independent service center. The vehicle has been inspected by the Audi dealer and the independent service center. There were no warning lamps, messages or other symptoms of the problem prior to the discovery of the subframe failure. The rusted subframe was first discovered on May 12, 2026 by the independent service center and later confirmed by the Audi dealer on May 15, 2026.
The worst 2016 Audi A4 Allroad problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Engine3
- Body2
- Electrical2
- Fuel system2
- Lights2
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Engine3
- Body2
- Electrical2
- Fuel system2
- Lights2
- Acceleration1
- Airbags1
- Driver assistance1
- Steering1
- Suspension1
- Visibility1
Recalls 3
Engine and engine cooling: cooling system
- What is wrong
- Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2013-2017 Audi A5 Cabriolet, A5 Sedan and Audi Q5 vehicles, 2012-2015 Audi A6 vehicles and 2013-2016 Audi A4 Sedan and A4 allroad vehicles. These vehicles, equipped with 2.0l Turbo FSI engines, have an electric coolant pump that can either become blocked with debris from the cooling system causing it to overheat or can short-circuit from moisture within the pump.
- Risk
- A blocked pump or a short-circuited pump can increase the risk of a fire.
- Remedy
- Audi will notify owners, and dealers will replace the pumps, free of charge. The recall began September 14, 2018. Owners may contact Audi customer service at 1‑800‑253‑2834. Audi's number's for this recall is 19N3/19N4. Note: This recall is in additional to the coolant pump software update applied as a remedy under recall 17V002.
Recall number 18V229000 · Recall details
Electrical system: wiring
- What is wrong
- Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2013-2016 Audi A5 Coupe, A5 Cabriolet, A4 Sedan, A4 Allroad and Q5 vehicles. Contact corrosion within the electrical connector for the auxiliary heater may cause the heater wires to overheat or melt.
- Risk
- The melted wires can increase the risk of a fire.
- Remedy
- Audi will notify owners, and dealers will replace the auxiliary heater and, as necessary, update the software, free of charge. The Recall began November 27, 2017. Owners may contact Audi customer service at 1‑800‑893‑5298. Volkswagen's numbers for this recall are 80C5 and 80C6.
Recall number 17V622000 · Recall details
Engine and engine cooling: cooling system
- What is wrong
- Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2013-2017 Audi A5, A5 Cabriolet and Q5 vehicles, 2013-2016 Audi Allroad and Audi A4 vehicles and 2012-2015 Audi A6 vehicles. These vehicles, equipped with 2.0l Turbo FSI engines, have an electric coolant pump that can be blocked with debris from the cooling system, resulting in the pump overheating.
- Risk
- If the coolant pump overheats, it can increase the risk of a fire.
- Remedy
- Audi will notify owners, and dealers will update the software so that the power supply to the coolant pump is deactivated if the pump becomes blocked with debris, free of charge. The recall is expected to begin February 20, 2017. Owners may contact Audi customer service at 1‑800‑253‑2834. Volkswagen's number for this recall is 19M1.
Recall number 17V002000 · Recall details
Technical service bulletins for the 2016 Audi A4 Allroad 478
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- This special notice is to inform dealers to return the parts listed and only order the successor parts...
- This bulletin provides information about professional noise analysis with the VAS 611 015 PICO-NVH tool
- This bulletin provides information when the anti-theft alarm activates for no reason, or when the...
- This TSB is a label placement guide as required by CARB for remanufactured parts.
- This service information TSB describes a cosmetic issue after using a car wash.
- This TSB provides damage assessment guidelines for textile seat covers.
- This bulletin provides information when the exterior lights have moisture accumulation.
- Removed expiration date, Updated part numbers in parts and claiming sections, General circular updates
- This bulletin serves as an assessment aid for shock absorber leaks.
- This bulletin provides informatin when the engine does not run smoothly at idling speeds.
What 2016 Audi A4 Allroad owners say
Most recent owner complaints, unedited.
Rear Suspension cross- member. Extensive corrosion hidden behind stone guard trapping dirt and moisture. I would not have known the rust was there if the stone guard had not come apart from the cross member I cannot trust the safety of this vehicle until it is repaired Audi requires a dealer inspection at the cost of the consumer. Audi Suspension cross member components are the same for many models. The Allroad should be included in the class action lawsuit.
The contact owns a 2016 Audi A4. The contact stated while driving approximately 65 MPH, the vehicle started shaking. The EPC warning light was illuminated. The vehicle was taken to the local dealer and diagnosed with cylinder #4 failure. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 88,000.
Initially my fuel pump began leaking fuel. Two weeks after replacement, the new audi factory fuel pump began leaking again and had to be replaced. After the fuel pump was replaced the second time, a large amount of fuel began leaking around the fuel injectors. This was an extreme safety hazard because of the large amount of fuel leaking and falling onto the alternator and other parts.
Fuel pump began leaking at 55,000 mile mark
Air system is putting out excessive debris and particles . Computer mmi does not work. Can not log into to audi portal propertly and sync. My software. Never received my recall on the electrical system wiring. Had it at the dealer for services multiple times and problem not resolved. Keeps reoccurring
Tl* the contact owns a 2016 audi a4. The contact received notification of the federal safety agency campaign number: 18v229000 (engine and engine cooling); however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The contact did not call a dealer to see if the parts were available; however, the contact mentioned that the recall letter stated that the part was not available. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Vin tool confirms parts not available.
Tl* the contact owns a 2016 audi a4. Upon activating the air conditioner, an abnormal burning odor emerged from the vents. There were no warning indicators illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The failure mileage was 36,000. The VIN was not available.
When stepping on the gas on my audi it takes a while to go it feels like it has no power it also has been shaking really bad especially when going up hill. It has a noise coming from the engine that sounds like when your riding a bike all these problems are while it's in motion in both city streets and highways. The faster I go in the vehicle the more it shakes and the more I hear the noise as well. There is no light indicating that my car has a problem but there definitely is something wrong with my audi and I don't know what?
Tl* the contact owns a 2016 audi a4. The contact received notification of the federal safety agency campaign number: 18v229000 (engine and engine cooling); however, the parts to do the repair were unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The dealer (audi chantilly, 14839 stonecroft center ct, chantilly, va 20151, (703) 956-2100) was contacted and confirmed that the parts were not available for the recall remedy. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Vin tool confirms parts not available.
Compare the 2016 Audi A4 Allroad
Other model years
Questions about the 2016 Audi A4 Allroad
Is the 2016 Audi A4 Allroad reliable?
Owners have filed 15 complaints about the 2016 Audi A4 Allroad, close to a typical A4 Allroad model year.
What is the 2016 Audi A4 Allroad year score?
The 2016 Audi A4 Allroad scores 74 out of 100 (average). The score compares it with the other model years of the Audi A4 Allroad: 75 is a typical year, 50 means twice the usual complaints, and serious complaints and recalls lower it.
What is the most common problem with the 2016 Audi A4 Allroad?
Engine and cooling, with 3 complaints. Next is body (2).
How many recalls does the 2016 Audi A4 Allroad have?
3 recalls, covering engine and engine cooling and electrical system.
Was there a recall on the 2016 Audi A4 Allroad engine?
Yes, 2 recalls: 18V229000, 17V002000. Check your VIN to see if your car still needs the free repair.
What year does the Audi A4 Allroad have bad engine?
The Audi A4 Allroad model years with the most engine complaints are 2013 (15 complaints) and 2014 (15 complaints).
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Audi A4 Allroad?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history