Audi Q5 fuel pump problems

Filed Sep 22, 2026 · Fuel system · CA

There is fuel leaking by the rear passenger tire under where the gas tank is. There was a recall for a cracked flange on the fuel pump.

Filed May 1, 2026 · Fuel system · CA

I am reporting a safety issue involving my 2016 Audi Q5. The vehicle previously underwent recall 20Z8/20W9, which addresses fuel pump flange cracking that can cause fuel leaks and fuel vapor odors. Despite this recall repair being marked as completed, I am now experiencing a strong gasoline smell inside the cabin. This appears to be the same condition the recall was intended to fix. When I called the authorized Audi dealership (Audi San Jose), I was told I would be responsible for diagnostic and repair costs because the recall had already been completed and is no longer covered. I believe this indicates that: The recall remedy may have been ineffective, or The defect has reoccurred This presents a potential fire hazard and safety risk. I am requesting that this issue be reviewed, as it appears the recall did not adequately resolve the safety defect. Date issue first noticed: [04/27/2026] Mileage at time of issue: [101k] Thank you.

Filed Mar 26, 2026 · Fuel system · 108,000 miles · AZ

The contact owns a 2014 Audi Q5. The contact stated that while driving at an undisclosed speed, there was an abnormal fuel odor inside the vehicle. The contact stated that while exiting the vehicle, the fuel odor was also outside the vehicle. No warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with a leaking fuel pump. The contact was informed of the federal safety agency Campaign Number: 17V298000 (Fuel System, Gasoline). The dealer was made aware of the failure, and the contact was informed that the recall repair was performed in 2017. The contact was informed that a protective film was applied during the recall repair. The manufacturer was made aware of the failure but provided no assistance. The contact was informed that the recall repair had a one-year warranty. The failure mileage was approximately 108,000.

Filed May 13, 2025 · Engine, Fuel system · FL

Fuel pump has been recalled on other models but not mine. I have a 2018 audi q5. It had a warranty extension but the previous owner never claimed but if it would have been a recall then I wouldnt be having this problem . Now I have to replace the water pump and pay almost $2k for something that wasn't a recall.

Filed Apr 1, 2025 · Driver assistance, Fuel system · GA

Paid for fuel pump when should b covered on recall

Filed Feb 27, 2025 · Fuel system, Steering · FL

Back in 2017 there was a recall on my 2016 Audi Q5 regarding the fuel pump. Audi's solution to this recall was to replace the fuel pump if it had any cracks, but if there weren't any cracks their protocal was to just put a protective shield on the fuel pump. Since my car was only a year old, all that Audi did was the protective shield. A few weeks ago, my car started smelling like leaking fuel. After a couple days I took it to Audi since there had been a recall. My car has less than 63,000 miles on it and according to service persons that have looked at my car, it is in excellent condition. However, Audi service told me that because the protocol for the recall was performed on my car back in 2017, there was nothing they could do except replace my fuel pump and charge me for the work done. The noxious fumes were so bad that I could not drive my car without having all the windows down. I found out that when the intake fuel pump goes bad, so does the high pressure fuel pump and both have to be replaced along with the pressuer sensor. This cost me $2,700. After getting my car back and driving it less than 25 miles, I was stranded on the road and had to have my car towed back to the shop with a broken steering rack and a dead battery. Come to find out, the steering rack is another issue going on with Audi vehicles. These are very serious and life threatening situations, especially with noxious fumes from gasoline which is highly flammable. Audi needs to reimburse me the $2,700 for the fuel pump replacement cost that I would not have incurred if my fuel pump had actually been replaced in 2017, instead of a band-aid being put on it, which was negligence on Audi's part. By not replacing the fuel pump, I ended up with a gas leak in my car, my car dangerously breaking down in the middle of the road and having to be towed and ultimately a very costly repair for me of which Audi doesn't want to own any responsibility in.

Filed Dec 2, 2024 · Fuel system · FL

My words: An overheated electrical connection near the fuel tank overheated, thus cutting off the fuel pump system. This is similar to other fuel pump recalls with Audi A3 vehicles. BEGINNING OF MECHANIC REPORT: Concern? = Customer states he was on a trip driving on the highway, parked it and it wouldnt restart. Vehicle is cranking and not starting. Codes were pulled from the vehicle is there are fuel pump related codes. Cause = Confirmed concern vehicle does not start. fault codes P0087, p3073, p3043, removed rear seat and checked pump control module. found power supplied to control module but no power to pump. also found connector to control module melted. advise replacement of control module, in tank pump, and control module connector to start." END OF MECHANIC REPORT The markings on the fuel pump control module are as follows, line by line: "VW emblem" "Audi emblem" Germany 1j0 973 726 >PBI< FEP 1/3 3699

Filed Mar 29, 2024 · Fuel system · PA

In tank fuel pump cracked on top ,leaking fuel to flange and electrical conection on top of tank and down to under vehicle .no recall on audi site for this year -2010 vehicle has 138000 miles only . I was not expecting material problem -plastic not suitable for fuel ...

Filed Jan 9, 2024 · Engine · NJ

Too many engine issues/misfire/oil leaks on coils, air intake issues- hard to find the issue, engine burns/consumes way too much oil. Had gasket cover, PCV valve replaced, all coils replaced on 2 occasions due to oil leakage, spark plugs replaced, fuel pump replaced, intake valve replaced, water pump replaced, mass airflow sensor replaced, electric throttle body module replaced and I’m still experiencing misfires etc.

Filed Nov 29, 2023 · Fuel system · FL

in 2017 Audi repaired a leaky fuel pump in my Q5 due to a recall. My vehicle now has less than 35k miles since that repair and the new-replacement fuel pump flange is failing again. Fuel was coming out and created a significant fire risk to life and property. Audi has refused to deal with the issue and speaking with mechanics at 3 dealerships revealed that the replacement parts are failing at an alarming rate. I would like this looked into.