The contact owns a 2006 BMW 325I. The contact stated while driving at undisclosed speeds, the air bag warning light illuminated. The contact received notification of the federal safety agency Campaign Number: 24V513000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The dealer offered an inspection but declined to repair the vehicle. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The manufacturer referred the contact to the federal safety agency Hotline. The failure mileage was approximately 130,000. Parts distribution disconnect.
2006 BMW 325I: airbag warning light
126 of the 515 complaints about the 2006 BMW 325I describe airbag warning light.
- owner complaints
- 126
- of this car's complaints
- 24%
- typical repair cost reported
- $700
- typical mileage
- 75,000
- recalls
- 5
Is there a fix? There are 5 recalls and 6 service bulletins for this area of the car. See below
Airbag warning light by model year
What owners say
Put a box of moderate weight into the passenger seat (hard drives) - probably 40 lbs. After driving for a few minutes and over a few bumps, the seat belt warning light came on because the seat sensor was tripped by the weight. Put the seat belt on to silence the warning. Shortly thereafter, both the seatbelt and passenger airbag warning lights showed on the dash, regardless of occupancy. Hooked up to scanning tool and cleared the codes but they always return. This is not a rare event from reading the online forums - it is likely due to the sensor mat in the seat for occupancy being defective, or a combination of that and the seat belt pre-tensioner being defective, for the passenger side only. The vehicle operates normally other than the warning lights. Obviously have not tested the airbag, but that is highly unlikely to be the actual problem from my investigation of the symptoms.
The contact owns a 2006 BMW 325i. The contact stated that the dealer had previously replaced the passenger's side front seat air bag sensor and steering wheel air bag sensor; however, the failure recurred while his wife was driving at an undisclosed speed, with the air bag warning light being illuminated. The dealer was made aware of the failure; however, the vehicle was not diagnosed nor repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 130,000.
Component failed: passenger seat occupancy sensor (BMW error code: 0x93C3) Implication: passenger airbag will not deploy in case of accident if the occupancy sensor is defective. Similar problems: similar recalls were issued by BMW for the same model and year but with only sports seat; regular seats were not recalled. Previous inspections: this issue has not been previously inspected, but personal inspection leads to faulty seat occupancy sensor. Prior warnings: dashboard shows seatbelt and airbag lights; roof indicator lamp shows passenger airbag off.
The contact owns a 2006 BMW 325i. The contact stated that while operating the vehicle, the front passenger’s side air bag warning light would remain illuminated. The vehicle was taken to the local dealer who diagnosed that the seat mat sensor was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was not yet notified of the failure. The failure mileage was 180,000.
The airbag warning light is on. No code is being given by the diagnostic tool. I see that this is an ongoing problem, involving several models. This vehicle does not seem to be part of the recall. I don't get any cooperation from the dealership. They just say that it's not anything covered under a recall. I feel with the well known problem with a critical safety device such as an airbag system needs to have a recall notice issued soon. I'm not sure how this slipped through the cracks. But it seems like that's what happened. Sincerely [xxx] redacted to protect personally identifiable information pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6). *cc
Tamara airbags. My car has both airbag lights on and there is no recall on it at all and it has not been in an accident at all. I received a warranty extension but with conditions. Conditions were if it's not the particular fault they will charge me $200 just for a scan. And then some more to actually fix the issue. I do not want to take it in due to that issue. I don't have $200 to give up like that.
Tl* the contact owns a 2006 bmw 325i. While driving approximately 10 MPH, the passenger side air bag warning indicator illuminated. The contact placed a briefcase with a laptop on the seat and the system warned that the passenger side air bag was off. The warning indicator first illuminated in february of 2018 and flashed on and off. Currently, the air bag indicator remained permanently illuminated. The vehicle was not taken to the dealer for diagnostic testing. The manufacturer was notified of the failure and stated that the contact must pay for diagnostic testing. The contact also mentioned receiving tsb number: sib-01-09-14 (passenger air bag seat occupancy sensor 063) limited warranty extension. The vehicle was not repaired. The approximate failure mileage was 130,000.
I am frightened to death that the aforementioned recall of almost the entire SRS controls was not properly fixed. Duplicated warnings for both have been a daily problem and an exact replica of the symptoms prior. No accident to report, yet a completely valid potential cause for bodily harm! My other car is 16 years old and just was in for a new and active recall as the bags were deploying shrapnel and plastic....and she's 16 years old! I appreciate your help and consideration! Looking forward to a prompt response! I'll be driving it to my nephew's wedding at fort campbell army base.
Defective passenger air bag sensor mat. Even when an adult is sitting in the passenger seat, the air bag light turns on, as if the airbag is disabled. This is a common issue, as you can see from google search results: https://www.google.com/search?q=e90+replace+air+bag+sensor+mat&oq=e90+replace+air+bag+sensor+mat&aqs=chrome..69i57.12429j1j7&sourceid=chrome&ie=utf-8
Air bag lights on without crash also seat belt light on.
Tl* the contact owns a 2006 bmw 325i. The contact stated that the air bag warning indicator remained illuminated each time the vehicle was driven. The vehicle was previously serviced on june 6, 2017 per a recall notification for the driver side frontal air bag at classic bmw dealer (located in dallas, tx). The contact informed the dealer that the air bag warning indicator remained illuminated after the repair. The dealer informed the contact that a diagnostic fee had to be paid before the vehicle could be serviced. The vehicle was not repaired due to the diagnostic fee. The manufacturer was not made aware of the failure. The approximate failure mileage was 145,000. The VIN was not available.
Service bulletins that may apply
- Takata air bag recall-related short-term alternate transportation and consequential repairs
- Takata class action settlement
- In an effort to improve the completion rate on Takata air bag recall affected vehicles; BMW NA has...
- This Service Information bulletin supersedes SI B65 69 06 dated June 2008
- Enabling and Replacing New OC3 Seat Mat. The replacement OC3 seat mat (front passenger seat occupancy)...
Related recalls
Air bags: frontal: driver side: inflator module
- What is wrong
- BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
- Risk
- An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
- Remedy
- Dealers will inspect and replace the driver's air bag module as necessary, free of charge. Owner notification letters were mailed August 30, 2024. Owners may contact BMW customer service at 1‑800‑525‑7417.
Recall number 24V513000 · Recall details
Air bags: frontal: driver side: inflator module
- What is wrong
- BMW of North America, LLC (BMW) is recalling certain 2008-2013 128i and 135i Convertibles, 128i, 135i, and M Coupes, 2007-2010 X3 30si and X3 xDrive30i, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i, 2007-2013 328i, 328i xDrive, 335i, 335is, 335i xDrive and M3 Coupes, 2006-2011 328i, 328xi, 328i xDrive, 325i, 325xi, 330i, 330xi, 335i, 335xi, 335i xDrive and M3, 2009-2011 335D, 2006-2012 325xi, 328i, 328xi and 328i xDrive, 2010-2011 X6 ActiveHybrid, 2007-2013 328i, 335i, 335is, M3 Coupes, X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M, 2009-2013 X5 xDrive35d and 2008-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles equipped with non-desiccated driver frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
- Risk
- An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
- Remedy
- BMW will notify owners, and dealers will replace the driver air bag. On X5 and X6 vehicles, only the inflator will be replaced. All repairs will be performed free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1‑800‑525‑7417.
Recall number 20V017000 · Recall details
Air bags
- What is wrong
- BMW of North America, LLC (BMW) is recalling certain model year 2000 323i sedans, coupes, convertibles, and Sports Wagons; 2000 328i sedans and coupes; 2001-2005 325i sedans, coupes, convertibles, and Sport Wagons; 2001-2005 325xi sedans and Sports Wagons; 2006 325i coupes and convertibles; 2001-2006 330i sedans, coupes, and convertibles; 2001-2005 330xi sedans; and 2001-2006 M3 coupes and convertibles to address a safety defect in the passenger side frontal air bag which may produce excessive internal pressure that could cause the air bag inflator to rupture upon deployment of the air bag.
- Risk
- In the event of a crash necessitating deployment of the passenger's frontal air bag, excessive internal pressure could cause rupturing of the inflator resulting in metal fragments striking and potentially seriously injuring the passenger seat occupant or other occupants.
- Remedy
- Owners are advised not to drive their vehicles until they have been repaired. BMW will notify owners, and dealers will replace the passenger side frontal air bag, free of charge. An interim notice was mailed to owners in September 2014. A second notice was mailed when an adequate supply of parts became available, on December 1, 2014. Owners may contact BMW customer service at 1‑800‑525‑7417 or email BMW at [email protected].
Recall number 14V428000 · Recall details
Air bags: sensor: occupant classification
- What is wrong
- BMW of North America, Inc. (BMW) is recalling certain 2006 325i, 325xi, 330i, 330xi, 525i, 525xi, 530i, 530xi, and 550i vehicles equipped with the Sport Seat option and certain 2006 525i, 525xi, 530i, 530xi, 550i vehicles with standard seats. The front passenger seat occupant detection mat that determines if, and how, the passenger frontal air bag should deploy in a crash may fatigue and develop cracks which could lead to a system failure.
- Risk
- Should the system fail, in the event of a crash, the front passenger air bag would be deactivated, increasing the risk of personal injury.
- Remedy
- BMW will notify owners, and dealers will repair the occupant detection mat to eliminate the possibility that it may crack, replacing it as necessary, free of charge. The recall began September 1, 2017. Owners may contact BMW customer service at 1‑800‑525‑7417.
Recall number 17V428000 · Recall details
Air bags: sensor: occupant classification
- What is wrong
- BMW of North America LLC (BMW) is recalling certain model year 2006 325i, 325xi, 330i, 330xi sedans and 325xi sports wagons, model year 2007 328i, 328xi, 335i, 335xi sedans and 328i and 328xi sports wagons, model year 2006-2007 525i, 525xi, 530i, 530xi, 550i sedans and 530xi sports wagons, model year 2006 760i sedans, model year 2006-2007 750i, 750Li, and 760Li sedans, and model year 2006 X5 sports activity vehicles, equipped with certain seat types. The front passenger seat occupant detection mat that determines if and how the passenger frontal air bag should deploy in a crash may fatigue and develop cracks which could lead to a system failure.
- Risk
- Should the system fail, in the event of a crash, the front passenger air bag would be deactivated, increasing the risk of personal injury.
- Remedy
- BMW will notify owners with an interim notification letter in January 2014 since parts are not currently available. When parts are available, BMW sent a second letter in August and dealers will repair the occupant detection mat to eliminate the possibility that it may crack, free of charge. Additionally, owners of model year 2006-2007 3 Series with standard seats, 5 Series with comfort seats, and Z4 models, will receive an extended warranty on their front passenger seat occupant detection mat. Owners may contact BMW customer relations at 1‑800‑525‑7417 or email BMW at [email protected].
Recall number 13V564000 · Recall details
Questions about the 2006 BMW 325I airbag light
Is airbag warning light a common problem on the 2006 BMW 325I?
126 of 515 owner complaints about the 2006 BMW 325I (24%) mention airbag warning light. The model year with the most reports is 2006.
How much does it cost to fix airbag warning light on the 2006 BMW 325I?
Owners who mentioned a price put the repair at about $700 (median of 12 complaints that include a dollar amount). Costs vary with mileage, warranty and where the work is done.
Is there a recall or service bulletin for this on the 2006 BMW 325I?
There are 5 recalls and 6 service bulletins for the same area of the car. Check them below with your VIN.
Other symptoms on the 2006 BMW 325I
Door locks 39Fire or smoke 23Steering lock-up 21No deployment 15Won't start 14Overheating 13Key fob 12Headlights 8Stalling 8Seat belt 7Check engine light 6Loss of power 6ABS 5Engine failure 5Fuel smell 5
VIN decoder
See the problems and recalls for an exact car
Buying a used 2006 BMW 325I?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history