2011 BMW 328I: engine stalls while driving

Filed Nov 2, 2026 · Engine, Fuel system · CA

Dealership performed VANOS bolt replacement recall on 2011 BMW 328i. Vehicle has 63K miles and is otherwise in excellent condition. Post recall, vehicle experiences unstable idle with rpm dipping low when stopped in gear during initial engine warm up period. Issue stabilizes somewhat but not completely gone once engine is at operating temperature. This is a safety issue with engine surging, hesitating, and potentially stalling when stopped at stoplight or intersections.

Filed Oct 26, 2026 · Electrical · TN · fire

VIN [XXX] 2011 BMW 328i 4dr. Disabled widow, and on [XXX] while driving with my 3 minor children in vehicle, vehicle attempted to stall/loss of complete electrical power, smoke from trunk/rear seat. After stopping, got the trunk opened and discovered that the Battery Safety Terminal (BST) box and Battery Distribution Box in my trunk was on fire. After researching, it came to my attention that this incident matches the federal safety agency Recall 13V‑044 (positive battery cable to fuse box stall/loss) and 2012 battery cable fire recall (1.3M BMW 5/6/3 series - BMW stated "can result in electrical malfunction, failure to start and, in some cases, to charring or fire") re-expanded 2019. Obviously, I contacted BMW, and to say I was surprised at the complete lack of support, respect and help with this incredibly important and serious matter, would be an understatement. BMW NA rep 'Eddie' closed my case on Oct 21 (after telling me 2 days, yet waiting over a week, mind you) citing salvage/total loss, absolutely refused inspection and then with attitude, REFUSES to give me a supervisors info, told me he’s not allowed to give me any info in order to speak to anyone higher up, that he can pass along my info and if they WANT to, then THEY can contact ME. TN Certificate of Title [XXX] issued 07-31-2026 shows CLEAN title Remarks: Actual Mileage only, no brand. IF the title is/was salvaged, it was absolutely not disclosed by private seller at sale [XXX], nor stated on my title. Retaining burnt BST box and battery distribution box. Safety fire with children. Request investigation. Absolutely disgusted with the behavior from the BMW rep, ‘Eddie’ 🙄 Just completely careless and not even acknowledging how terribly close this came to ENDING THE LIVES of my 3 children and I. This has completely traumatized my daughter, as she felt the heat through the right of the backseat. Literal nightmares for her and crying if I even mention the car now. Incredibly difficult. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)

Filed Mar 25, 2026 · Engine · 157,637 miles · CA

The contact owns a 2011 BMW 328I. The contact stated that upon starting the vehicle, the low oil pressure warning light illuminated, and the vehicle stalled. The vehicle was towed to an independent mechanic, where it was diagnosed, and determined that the VANOS bolts had failed and needed to be replaced. The vehicle was not repaired due to the cost. The contact related the failure to TSB Number: SIB 11 04 14. The manufacturer was notified of the failure and informed the contact that the vehicle was covered under the TSB. The failure mileage was approximately 157,637.

Filed Mar 9, 2026 · Engine · 200,000 miles · IL

The contact owns a 2011 BMW 328I. The contact stated that on several occasions while driving on the streets and the highway, the vehicle lost automotive power. There were no warning lights illuminated at the time of the failure. The contact stated that the vehicle jerked unexpectedly, stalled, and failed to accelerate over 30 MPH. The vehicle was towed to an independent mechanic but was not diagnosed or repaired. The mechanic referred the contact to the dealer for further assistance and stated that the failure could be related to a recall. The vehicle was towed to the dealer, but was not diagnosed or repaired. The contact stated that the failure started after the vehicle was repaired under an air bag recall by the dealer, and the failure persisted. The manufacturer was made aware of the failure. The approximate failure mileage was 200,000.

Filed Mar 9, 2026 · Engine · 133,000 miles · CA

The contact owns a 2011 BMW 328I. The contact stated that while driving at various speeds, there was a burning odor coming from the vehicle. The odor was more prominent while the vehicle was idling. The RPM fluctuated while idling, causing the vehicle to stall. The contact would depress the brake pedal, place the vehicle in neutral, turn off, and restart the vehicle to accelerate and continue driving. The air bag warning light was illuminated, and the message, "Check Engine Soon," was displayed. The vehicle was taken to a certified mechanic, and a diagnostic code was retrieved for Positive Crankcase Ventilation (PCV) failure; however, no repairs were completed. The contact completed some research and learned that the failure could be occurring due to air entering the brake lines. The contact also found information about the federal safety agency Campaign Number: 22V119000 (Engine); however, the VIN was not included. The vehicle was not taken to the dealer, diagnosed, or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 133,000.

Filed Mar 2, 2026 · Fuel system · CA

Fuel Pump Control Module and Fuel Pump Failed at highway speeds. There was a notification warning for a failed fuel pump and then the engine shut down and stalled at highway speeds within seconds.

Filed Feb 25, 2026 · Engine · PA

> While driving the car, low oil pressure indicator came on and within less than a mile later there was a sudden loss of power, engine stalled and then would not start again, requiring vehicle to be towed off the road and to a repair garage. Yes, vehicle is available for inspection upon request. >Vehicle was immobile on the road putting driver of vehicle and other vehicles on the road at risk of accident and injury. > Attached documentation reviews the issue. > Vehicle originally inspected by non-dealership garage that strongly recommended the vehicle be evaluated by BMW. Vehicle was towed to and inspected by BMW Sewickley [XXX] . BMW states not covered under Vanos recall. >Only immediately prior to stall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Feb 19, 2026 · Engine · PA

> While driving the car, the low oil pressure indicator came on, and within less than a mile later there was a sudden loss of power, engine stalled and then would not start again, requiring the vehicle to be towed off the road and to a repair garage. > Vehicle was immobile on the road putting driver of this vehicle and other vehicles on the road at risk of an accident and injury. > Vehicle originally inspected by non-dealership garage that strongly recommended the vehicle be evaluated by BMW. Vehicle was towed to and has been inspected by BMW Sewickley [XXX] . > Only immediately prior to stall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jan 29, 2026 · Engine · CA

Engine lost all oil pressure, smoke came through vents with the smell of burnt oil. Engine stalled, intake camshaft no longer moves when the engine is trying to turn over. Vanos system failed.

Filed Dec 15, 2025 · Engine · 120,000 miles · MA

The contact owns a 2011 BMW 328I. The contact stated that while driving approximately 65 MPH, the check engine warning light illuminated, and the vehicle hesitated and stalled. The vehicle was restarted several times but continually stalled. The vehicle was later towed to the residence. The contact examined the engine and discovered metal shavings in the VANOS solenoid engine oil. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure. The vehicle was not yet repaired. The failure mileage was 120,000.

Filed Oct 6, 2025 · Engine · 126,657 miles · FL

The contact owns a 2011 BMW 328I. The contact received notification of the federal safety agency Campaign Number: 23V707000 (ENGINE AND ENGINE COOLING). The recall repair was completed; however, on the drive home after the vehicle was retrieved, while driving 60 MPH, the engine seized. The contact stated that the vehicle was sluggish and hesitated before stalling in the middle lane of the highway. The oil pressure warning light was illuminated. The contact attempted to restart the vehicle, and after several attempts, the vehicle failed to restart. The contact was able to coast to the side of the road. The vehicle was towed to the dealer, where it was determined that the incorrect oil filter was installed on the vehicle. The vehicle was repaired. The contact towed the vehicle back to the residence. The manufacturer was made aware of the failure and offered the contact a 10% discount on a new engine. The failure mileage was 126,657.

Filed Apr 30, 2025 · Airbags, Engine · LA

RE: Recall on 2011 328i Vin# [XXX] I drove the car to run an errand, car was running ok but had a miss. During my drive home, the car stalled. I had to quickly coast to a parking lot in order not to get hit by the car behind me. I tried to restart the car, but it acted as if it needed a jump. Tried to jump the car but it turned over slowly without starting. Ended up getting it towed to Metairie very early the next morning, due to parades. Had a friend of mine, a BMW shop owner, take a look at the car. He told me that he found out that it had a few recalls and he thought that may be the problem. I spoke with a service advisor at BMW dealer that checked the vin and said the recalls would be taken care of along with anything it caused. I made the appointment and had it towed to BMW dea;er. I was assigned to Erin C, Service Advisor, when I made my appointment. My appointment was for 7:30 AM on the 28th of March. I heard from Erin at 4:30 that afternoon with an update. She told me that I had a seized engine and it was going to cost ten thousand or more to replace the engine. I asked if the recall was done on it, because the recall stated that one of the indicators of the Vanos issue was that it would not start any more. I also found information saying that stalling, engine seizing, and oil starvation can be dangerously caused by the recall. Erin stated that they would take the valve cover off to confirm. Didn’t hear from her on Friday, or over the weekend. I got her on the phone Monday evening at 5:30 PM. Erin told me the same information that after they took off the valve cover and videoed it (have not seen that video yet). That my engine was seized. She assured me that they hooked up the car to communicate with the engineers who confirmed, from all the evidence, that the engine seizing was not caused by the recall but lack of oil circulation. If she had a diagnostic done on the car, she had not shared any codes found with me at this INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATIO