2011 BMW 328I problems

Filed Nov 2, 2026 · Engine, Fuel system · CA

Dealership performed VANOS bolt replacement recall on 2011 BMW 328i. Vehicle has 63K miles and is otherwise in excellent condition. Post recall, vehicle experiences unstable idle with rpm dipping low when stopped in gear during initial engine warm up period. Issue stabilizes somewhat but not completely gone once engine is at operating temperature. This is a safety issue with engine surging, hesitating, and potentially stalling when stopped at stoplight or intersections.

Filed Oct 28, 2026 · Acceleration · 65,000 miles · IL · crash

The contact owns a 2011 BMW 328I. The contact stated that while coming to a stop the brake pedal was depressed; however, after releasing the brake pedal, the vehicle independently accelerated. The contact stated that on a separate occasion while coming to a stop in front of a garage, the brake pedal was slightly released and the vehicle accelerated independently and crashed into the garage door. The manufacturer was notified of the failure. The vehicle was taken to the dealer, but the dealer was unable to duplicate the failure. The failure mileage was 65,000.

Filed Oct 26, 2026 · Electrical · TN · fire

VIN [XXX] 2011 BMW 328i 4dr. Disabled widow, and on [XXX] while driving with my 3 minor children in vehicle, vehicle attempted to stall/loss of complete electrical power, smoke from trunk/rear seat. After stopping, got the trunk opened and discovered that the Battery Safety Terminal (BST) box and Battery Distribution Box in my trunk was on fire. After researching, it came to my attention that this incident matches the federal safety agency Recall 13V‑044 (positive battery cable to fuse box stall/loss) and 2012 battery cable fire recall (1.3M BMW 5/6/3 series - BMW stated "can result in electrical malfunction, failure to start and, in some cases, to charring or fire") re-expanded 2019. Obviously, I contacted BMW, and to say I was surprised at the complete lack of support, respect and help with this incredibly important and serious matter, would be an understatement. BMW NA rep 'Eddie' closed my case on Oct 21 (after telling me 2 days, yet waiting over a week, mind you) citing salvage/total loss, absolutely refused inspection and then with attitude, REFUSES to give me a supervisors info, told me he’s not allowed to give me any info in order to speak to anyone higher up, that he can pass along my info and if they WANT to, then THEY can contact ME. TN Certificate of Title [XXX] issued 07-31-2026 shows CLEAN title Remarks: Actual Mileage only, no brand. IF the title is/was salvaged, it was absolutely not disclosed by private seller at sale [XXX], nor stated on my title. Retaining burnt BST box and battery distribution box. Safety fire with children. Request investigation. Absolutely disgusted with the behavior from the BMW rep, ‘Eddie’ 🙄 Just completely careless and not even acknowledging how terribly close this came to ENDING THE LIVES of my 3 children and I. This has completely traumatized my daughter, as she felt the heat through the right of the backseat. Literal nightmares for her and crying if I even mention the car now. Incredibly difficult. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)

Filed Sep 9, 2026 · Engine · IA

"My vehicle is experiencing a complete mechanical breakdown with a fast-crank, no-start condition and an active fault code for exhaust valve timing. This matches the exact failure mode of active Safety Recall 23V‑707 (VANOS Bolts). BMW's official safety recall report states that if a vehicle shows these symptoms, owners must not drive it and must contact them to arrange pickup and transportation. However, BMW Corporate Case Manager Jasmine has officially refused to cover the tow, stating over the phone that the transport language in the recall letter 'doesn't mean they cover a tow.' BMW is failing to execute its federally mandated safety recall remedy for an inoperable, broken-down vehicle."

Filed Sep 3, 2026 · Engine · WA

I took my car to the Tigard Oregon bmw dealership for my three recalls that were needing addressed. I turned my car over to them in good working order. After picking it up after the repairs my service engine light came on. My car started knocking and rattling louder and louder. I returned to the dealership and requested they fix the issue. After a few days they contacted my and told me it needs a new engine. They say they checked over their work and the problem isn't their fault. I disagree. They say they found metal shavings in my oil. They did an oil change a week earlier and mentioned no metal in my oil.

Filed Aug 31, 2026 · Electrical, Engine · 110,000 miles · CA

The contact owns a 2011 BMW 328I. The contact stated that the headlights and taillights remained illuminated after the vehicle was turned off. Additionally, the vehicle intermittently failed to start up. The contact stated that AAA jump-started the vehicle, and it was determined that the battery was in good working condition. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact associated the failure to the federal safety agency Campaign Number: 17V676000 (Electrical System); however, the VIN was not included in the recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 110,000.

Filed Aug 16, 2026 · Engine · PA

I believe my car is effected by the active bmw recall the federal safety agency Campaign 23V‑707. I have called bmw and gave them my vin number and was rudely rushed off the phone being told my car has no active recalls. I have done a ton of research and the car sounds just like every other car effected by this recall. The car starts and idles fine initially but as soon as it drops to normal idle rpms it makes a loud clanking noise and vibrates really bad. When i go into the engine bay i hear the noise coming directly from the vanos area. The car had one code which was 2a7c before the noise. I cleared the code it has not come back but the noise is still there and therefore the vehicle is unsafe to drive. It feels and sounds like if i drive this car on public roads something catastrophic will happen. I believe that my vehicle should be covered under this recall even though they are saying my vin has no outstanding recalls. This is literally the same exact issue for the recall in the first place and it would be amazing if they could help me out.

Filed Jul 17, 2026 · Engine · MD

I brought my vehicle to an authorized dealer for three open safety recalls. Two were performed at no charge. The third, the VANOS adjustment unit screw connection recall, was not performed. The dealer stated in writing on the repair order that the vehicle has a broken valve cover bolt, that the valve cover will not seal properly, and that a new valve cover is recommended to complete the recall. They quoted $1,077.43 for a valve cover as a customer-pay repair and stated the recall could not be completed until that was done. I declined the valve cover. The recall was not performed. The bolt is not broken and the valve cover is not broken. The threads in the cylinder head bolt boss are stripped, and a larger bolt was installed that holds. There is no oil leak. A new valve cover would thread into the same stripped hole in the cylinder head and would not repair the damaged threads. The dealer's proposed repair does not address the condition they described. The manufacturer's dealer bulletin for this recall lists a cylinder head cover profile seal as a recall part and does not list a valve cover in any parts list. The remedy requires removing the cylinder head cover regardless. I left without signing the repair order. The recall remains open. I am reporting that a free safety recall remedy was conditioned on a customer-pay repair. The dealer could have performed the recall, documented the pre-existing thread damage on the repair order, noted that the customer was advised and declined the valve cover, and disclaimed responsibility for any future seepage at the cover. I would have accepted that. Instead they performed neither the recall nor any repair, and left a federal safety recall open.

Filed Mar 25, 2026 · Engine · 157,637 miles · CA

The contact owns a 2011 BMW 328I. The contact stated that upon starting the vehicle, the low oil pressure warning light illuminated, and the vehicle stalled. The vehicle was towed to an independent mechanic, where it was diagnosed, and determined that the VANOS bolts had failed and needed to be replaced. The vehicle was not repaired due to the cost. The contact related the failure to TSB Number: SIB 11 04 14. The manufacturer was notified of the failure and informed the contact that the vehicle was covered under the TSB. The failure mileage was approximately 157,637.

Filed Mar 9, 2026 · Engine · 133,000 miles · CA

The contact owns a 2011 BMW 328I. The contact stated that while driving at various speeds, there was a burning odor coming from the vehicle. The odor was more prominent while the vehicle was idling. The RPM fluctuated while idling, causing the vehicle to stall. The contact would depress the brake pedal, place the vehicle in neutral, turn off, and restart the vehicle to accelerate and continue driving. The air bag warning light was illuminated, and the message, "Check Engine Soon," was displayed. The vehicle was taken to a certified mechanic, and a diagnostic code was retrieved for Positive Crankcase Ventilation (PCV) failure; however, no repairs were completed. The contact completed some research and learned that the failure could be occurring due to air entering the brake lines. The contact also found information about the federal safety agency Campaign Number: 22V119000 (Engine); however, the VIN was not included. The vehicle was not taken to the dealer, diagnosed, or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 133,000.