2015 BMW 328I: engine overheating

Filed Oct 25, 2025 · Electrical, Engine · FL · fire

My 2015 BMW 328i xDrive (VIN [XXX] ) experienced an engine-compartment fire that began shortly after coolant sprayed from the front of the vehicle. This incident occurred before BMW’s official recall announcement for the federal safety agency Campaign 24V‑608 / BMW 24V‑608:474 (Safety: Engine Coolant Pump Electrical Connector). The fire originated near the coolant pump area, consistent with the recall’s described defect involving electrical shorting and overheating at the pump connector. The vehicle was declared a total loss by my insurance company. I believe this event was caused by the same defect identified in the recall and request that this incident be investigated and documented under campaign 24V‑608. Supporting photos and insurance documentation are available upon request. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 31, 2025 · Electrical, Engine · 95,000 miles · KY

The contact owns a 2015 BMW 328I. The contact stated while driving approximately 45 MPH, the A/C was blowing hot air, and the temperature gauge was rising. Additionally, there was white smoke coming from under the hood. The contact stated there was no warning light illuminated. The contact related the failure to the federal safety agency Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System). The contact had received the recall notification from the manufacturer. The contact called a local dealer and was informed that a plastic shield was to be installed on the water pump, but that the shield would not stop the engine from overheating. The vehicle was not repaired. The manufacturer was informed of the failure . The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was approximately 95,000.

Filed Apr 29, 2025 · Electrical, Engine · 125,000 miles · GA

The contact owns a 2015 BMW 328I. The contact stated that while the vehicle was parked, there was fluid leaking on the ground. Additionally, the message "Engine Overheated, Please Stop Now" was displayed while driving, and smoke was coming from under the hood. The contact pulled over and waited for the engine to cool down. Upon inspection under the hood, the contact discovered a hole in the coolant reservoir, with coolant all over the engine compartment. There was smoke coming from the coolant pump. The vehicle was towed to an independent mechanic, who replaced the coolant pump and coolant hoses; however, the failure persisted, with the engine overheating and the vehicle failing to accelerate above 60 MPH while driving. The vehicle was not repaired. The contact later received notification of the federal safety agency Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and confirmed that parts were not yet available. The failure mileage was approximately 125,000. VIN tool confirms parts not available.

Filed Jan 2, 2025 · Engine · CA · crash · 1 injury

The contact owned a 2015 BMW 328I. The contact stated that while her husband was driving at undisclosed speeds, the vehicle lost automotive power and stalled. As a result, the vehicle was rear-ended by another vehicle. The contact stated that the vehicle spun around and was struck head-on by another vehicle. The air bags deployed. The contact’s husband suffered injuries to the ribs, both arms were fractured, cerebral hemorrhage, and internal bleeding. The contact was taken to the hospital by an ambulance. The contact was unsure if a Police report was filed. The Fire Department used the jaws of life to remove the driver’s side door. The vehicle was towed to the city impound lot and deemed totaled. The contact stated that the engine had overheated weeks before the vehicle stalled and was involved in the crash. The manufacturer was not made aware of the failure. The failure mileage was unknown.

Filed Nov 26, 2024 · Electrical, Engine · 112,000 miles · TN

The contact owns a 2015 BMW 328I. The contact received notification of the federal safety agency Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The contact stated while driving at approximately 45 MPH, the engine was overheating. The contact noticed white smoke coming from under the hood on the passenger's side. The check engine warning light was illuminated. The contact pulled over to the side of the road and stopped the vehicle. The message "Engine Overheating" was displayed. The vehicle was towed to the residence, where two independent mobile mechanics diagnosed the vehicle and determined that the water pump had failed and needed to be replaced. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 112,000. VIN tool confirms parts not available.

Filed Oct 23, 2024 · Electrical, Engine · 59,000 miles · NY · fire

The contact owned a 2015 BMW 328i. The contact stated that while driving at various speeds, and while at a complete stop, there was smoke coming from underneath the hood and through the A/C vents. The contact stated that the vehicle was overheating. Several unknown warning lights were illuminated. The contact stated that the A/C only blew hot air. The vehicle was taken to the dealer, where the timing belt, the oil gasket, the oil pan, and unknown fuses were replaced; however, the failure persisted. Additionally, the contact stated that upon starting the vehicle, there was smoke coming from the A/C vents and from the charging port. The contact stated that the infotainment system then caught on fire. The contact exited the vehicle. The contact was able to extinguish the fire with two extinguishers and with the assistance of the fire department. A fire department report was filed. No police report was filed. The vehicle was towed and totaled. The dealer was not contacted. The manufacturer was notified of the failure and informed the contact that the fire had not occurred due to a manufacturing defect. The contact later received notification of the federal safety agency Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System), which she related to the failure. The failure mileage was approximately 59,000.