BMW 328I fuel pump problems

Filed Aug 5, 2026 · Fuel system · MN

On XXX, while driving on Interstate XXX with my family near [XXX], the engine shut off and the vehicle lost all power. The event was preceded by a "Reduced Power" error displayed on the dashboard. Traffic was moderate and I was able to pull over to the right shoulder. The engine shutting off while on an interstate highway is obviously quite dangerous. After waiting for a few minutes I was able to restart the car and continue travel. I took my vehicle to a mechanic and several potentially relevant codes were found: 110001: Cylinder injection shutdown: pressure too low in high pressure system 11A002: Fuel high pressure, plausibility: pressure too low 481B03: EKPS control current too low Review of the issue and codes with the mechanic and internet forums indicates the fuel pump control module (EKPS) is failing. This can be exacerbated by hot weather. A failing EKPS can cause sudden stalling at any time, including at highway speeds, making the vehicle unsafe to drive until repaired. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 22, 2026 · Fuel system · MS

When the fuel gauge reads 1/4 of a tank or less the car stalls sporadically and comes to a jerking stop. This causes the cars behind us to either slam on their brakes or swerve to avoid hitting us. We reported this to our local BMW dealer and were told this is a known issue on many models, including ours. However, our car was not included in the existing recalls, so we could either pay for a diagnostic test and the fix OR keep the tank filled. Existing recalls involved the following: In-tank fuel tank sensor getting stuck In-tank fuel line incorrectly attached In-tank fuel pump wires crimped Improper nickel plating within fuel pump Engine control unit software failure

Filed Mar 2, 2026 · Fuel system · CA

Fuel Pump Control Module and Fuel Pump Failed at highway speeds. There was a notification warning for a failed fuel pump and then the engine shut down and stalled at highway speeds within seconds.

Filed Jun 27, 2025 · CA

DRIVE TRAIN MALFUNCTION. On June 25th 2025, for the second time I got this Drive Train Malfunction Issue on my 328i 2012 Model. The car just stopped in middle of road ( thank GOD not on a freeway ; otherwise, this would have resulted in multi car accidents and could have costed people's life including mine ). The car just died and STOPPED all of a sudden in middle of road and when I tried to start it, it only crank's . After waiting for about 10 minutes, it started . I had exactly same issue earlier in July 2024 and that time BMW service found high pressure fuel pump to be defective and they changed that. I was told by my BMW dealer that certain model and year BMW has this issue and it is well know. But I do see BMW issuing to its customers or doing anything. If the car just stops without any warning to pull over etc. while you are driving is very serious is VERY SERIOUS and LIFE- THREATENING ISSUE . Imagine one is driving at 70 miles an hour on a busy freeway and car abruptly stops ( like my car did , twice in last 11 months, thank god not on freeway though) and there are several cars behind you driving at more or less at same speed; this will result in multi cars collision and multiple accidents and deaths. I request the federal safety agency to take this serious issue on priority basis and do something ASAP.

Filed Jun 9, 2025 · Electrical, Engine · 126,000 miles · NJ

The contact owns a 2014 BMW 328i. The contact stated that while coming to a stop, the vehicle lost motive power with the check engine warning light illuminated. The vehicle was towed to an independent mechanic, where it was diagnosed that the fuel pump module had failed and needed to be replaced. The vehicle was not repaired. The contact received notification of the federal safety agency Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 126,000. VIN tool confirms parts not available.

Filed May 2, 2025 · Fuel system · CA

Fuel leak from factory fuel pump housing

Filed Apr 11, 2025 · Electrical, Engine · 65,000 miles · AR

The contact owns a 2014 BMW 328I. The contact stated while driving at an undisclosed speed, the vehicle lost motive power with a fuel pressure low warning message displayed. The vehicle was towed to the dealer where it was diagnosed that the fuel pump module had failed and needed to be replaced. The vehicle was not repaired. The contact received notification of the federal safety agency Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System ); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer confirmed that parts were not available. The manufacturer was made aware of the failure. The approximate failure mileage was 65,000. VIN tool confirms part not available.

Filed Oct 7, 2024 · Engine, Transmission · PA

I was driving and my car began to lose power and Drivetrain Malfunction appeared on the screen. I had to pull over to a side street and turn the car off. I turned it back on but it was very sluggish and moved very slow. Once I parked it I turned it off and tried to start it back up but it wouldn’t turn over. I contacted BMW and they said they couldn’t do anything. I need a new engine and timing chain, fuel pump and oil pan.

Filed Mar 25, 2024 · Fuel system · CA

Yesterday morning 3/24/24 , car stalled on highway with Fuel Pump message on dashboard. Car would not start and had to be towed.

Filed Sep 6, 2023 · Engine, Fuel system · AZ

Drivetrain malfunction warning comes on when the car runs for a few hours in the heat or when randomly driving. Sometimes the warning will clear itself after waiting a few minutes, but it might come back after a few minutes driving or not. In other instances, the drivetrain will not clear itself and will take more than a few hours. Took it to the repair shop 3 times and they indicated it could be the fuel pump modular or spark plugs or it could just be that the heat is messing up the software system. The mechanic has mentioned that drivetrain malfunctions have been occurring more regularly with BMWs. The issue is that this drivetrain can malfunction at any random time. Driving on a highway, street, or just starting up the car after letting it sit for a few minutes or days. It's a safety hazard because it can happen at any time unexpectedly. When it does, the car goes into neutral and this is dangerous if driving on the highway at higher speeds and needing to pull over into right hand lane. I've not yet taken it to a dealer to look at, just a certified BMW repair shop. There have been no warning issues and the car clears whenever it is taken to the repair shop.