Check Engine light on due to lower radiator blind jammed and closed. BMW has extended car warranty for this fault for various other models produced 2020 and beyond for up to 150,000 miles, under si B01 03 25 and si B01 12 19 However They do not cover my car, 2020 BMW 530e which has 78,000 miles where most of their 5 series and 3 series are covered under extended warranty for this exact problem for 150000 miles or 15 years. This is an emission part and jamming of flaps put at tremendous risk of car catching fire while driving due to heat. They must cover all their car for this manufacturing defect including 530e models.
The worst 2020 BMW 530E problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Electrical2
- Engine1
- Lights1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Electrical2
- Engine1
- Lights1
Recalls 3
Back over prevention: software
- What is wrong
- BMW of North America, LLC (BMW) is recalling certain 2019-2021 X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, X4 xDrive30i, X4 M40i, M550i, X4M, X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5M, X5 M50i, X7 xDrive40i, X7 xDrive50i, X7 M50i, Alpina XB7, 330i, 330i xDrive, M340i, M340i xDrive, and 8 Series Coupe, Convertible and Grand Coupe, 840i, 840i xDrive, M850i xDrive, M8, 2020-2021 530e, 530e xDrive, 330e, 330e xDrive, 745Le, 745Le xDrive, X5 xDrive45e, X3 xDrive30e, X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6 M50i, X6M, 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 740i, 740Li, 740Li xDrive, M760i Drive, M760Li xDrive, 750Li xDrive Alpina, Alpina B7 xDrive, and 2021 4 Series Coupe 430i, 430i xDrive, M440i xDrive vehicles. When shifting into Reverse, a small portion of the rearview image may be obscured, or the screen may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
- Risk
- If the driver relies on only the rearview camera image, the missing or reduced rearview image view can increase the risk of a crash or injury.
- Remedy
- BMW will notify owners, and dealers will inspect the rearview camera software and update it if necessary, free of charge. The recall began April 16, 2021. Owners may contact BMW customer service at 1‑800‑525‑7417.
Recall number 21V096000 · Recall details
Electrical system: propulsion system: traction battery
- What is wrong
- BMW of North America, LLC (BMW) is recalling certain 2020-2021 530e, 530e xDrive, 530e iPerformance and X3 xDrive30e and MINI Cooper Countryman All4 SE, 2020 BMW i8, and 2021 330e, 330e xDrive, 745Le xDrive and X5 xDrive45e vehicles. Debris may have entered one or more of the hybrid battery cells during their production.
- Risk
- The debris could result in a short-circuit, increasing the risk of fire or injury.
- Remedy
- BMW will inspect and, if necessary, replace the battery module free of charge. The remedy is currently being developed. Until the remedy is completed, drivers are instructed to not charge their vehicles. Drivers are instructed to not drive in manual mode, sport mode, and to not use the shift paddles. Owners were notified of the safety risk October 23, 2020. The recall began November 24, 2020. Owners may contact BMW customer service at 1‑800‑525‑7417.
Recall number 20V601000 · Recall details
Back over prevention: sensing system: camera
- What is wrong
- BMW of North America, LLC (BMW) is recalling certain 2018 540d, 2018-2020 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 530e, 530e xDrive, X3 sDrive, X3 xDrive, X3 M40i, X3 M, and 2019-2020 X4 xDrive, X4 M40i, X4 M, X7 xDrive, X7 M50i, 740Li, 740Li xDrive, 750Li, 750Li xDrive, 8 Series Convertible and Coupe 840i, 840i xDrive, M850i xDrive, X5 sDrive, X5 xDrive, X5 M50i, X6 xDrive, X6 M50i, 330i, 330i xDrive, M340i, M340i xDrive, Z4 sDrive, Z4 M40i, 740Le xDrive and 745Le xDrive, 2018-2019 640i xDrive Gran Turismo and Rolls-Royce Phantom, 2019 M850i xDrive Gran Coupe and Rolls-Royce Cullinan and 2020 Toyota Supra vehicles. The back-up camera and display settings can be adjusted such that the rear view image is no longer visible and the system will retain that setting the next time the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."
- Risk
- The lack of an image in the back-up camera display increases the risk of a crash.
- Remedy
- BMW will notify owners, and dealers will update the back-up camera software, free of charge. The recall began November 8, 2019. Owners may contact BMW customer service at 1‑800‑525‑7417 or Rolls-Royce at 1‑877‑877‑3735. Toyota owners may contact Toyota customer service at 1‑888‑270‑9371.
Recall number 19V684000 · Recall details
See all 3 recalls for the 2020 BMW 530E
Defect investigations
Pedestrian alert sounds
the federal safety agency received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, the federal safety agency opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified the federal safety agency he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by the federal safety agency regarding the subject matter of the petition.
DP22005
Technical service bulletins for the 2020 BMW 530E 247
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- The high-temperature (HT) coolant expansion tanks breathing line/pipe limited warranty for defects in...
- One or more of the LED daytime running lights are dim or discolored.
- Check Control message (CCM) indicates: (ID 213): Stop, exercising due care
- The basic conditions for initializing the power windows are not met.
- The electrical system of BMW vehicles has been subject to an ongoing development process over the last few...
- At low outside temperatures (below 40 degrees F) and slow driving speeds (i.e. when parking,...
- The Central Information Display goes black intermittently due to resets of the Head Unit (HU-H3)....
- Situation
- Engine will crank but not start
- Customers may state that the alarm system (DWA) is not active after locking their unoccupied vehicle
What 2020 BMW 530E owners say
Most recent owner complaints, unedited.
The contact owns a 2020 BMW 530E. The contact stated while driving at an undisclosed speed, the check engine and starter failure warning lights illuminated. The dealer was made aware of the failure. The contact was informed that parts were unavailable to repair the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact later received notification of the federal safety agency Campaign Number: 26V441000 (Electrical System); however, the part to do the recall repair was unavailable. The manufacturer was made aware of the failure. The contact was informed that parts were not available. The failure mileage was approximately 107,000.
The car’s instrument cluster has no indicator light to inform the driver whether or not low beam headlights are active. I took the car into BMW to get this addressed early on after purchasing the vehicle and BMW service technicians informed me that these cars don’t have such a light. Even though the manual includes documentation for the light. This poses a safety hazard as a driver may put the headlight switch in the wrong position and would have no indication they’ve done so. Daytime running lights may confuse them to thinking they have their headlights on. This poses a safety risk as tail lights would also not illuminate reducing visibility for other drivers and could increase the likelihood of a collision.
Compare the 2020 BMW 530E
Other model years
Questions about the 2020 BMW 530E
Is the 2020 BMW 530E reliable?
Owners have filed 3 complaints about the 2020 BMW 530E, close to a typical 530E model year.
What is the most common problem with the 2020 BMW 530E?
Electrical system, with 2 complaints. Next is engine (1).
How many recalls does the 2020 BMW 530E have?
3 recalls, covering back over prevention and electrical system.
Was there a recall on the 2020 BMW 530E electrical?
Yes, 1 recall: 20V601000. Check your VIN to see if your car still needs the free repair.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2020 BMW 530E?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history