ValveTronic motor and eccentric shaft is a very common issue that my specific car has. Affects the timing and makes a loud sound. Dangerous to drive in this condition.
The worst 2011 BMW 535I problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Engine41
- Fuel system35
- Electrical17
- Transmission17
- Wheels7
- Acceleration6
- Airbags5
- Lights5
- Brakes3
- Tires3
- Visibility3
- Body2
- Locks1
- Seats1
- Suspension1
Specific symptoms reported on the 2011 BMW 535I
Fuel pump 18Stalling 14Headlights 7Check engine light 6Loss of power 6Won't start 5
Recalls 4
Power train: driveline: constant velocity joint
- What is wrong
- BMW of North America, LLC (BMW) is recalling certain 2011-2012 135i Coupe, 1 Series M Coupe and 135i Convertible vehicles, 2011 Z4 sDrive 35i, 335i, 335d, 335i Coupe, 335is Coupe, 335i Convertible, 335is Convertible, 535i, 535i xDrive, 535i Gran Turismo and 550i xDrive Gran Turismo vehicles and 2012 740i and 740Li vehicles. The rear driveshaft constant velocity (CV) joint on the affected vehicles may fatigue and break.
- Risk
- If the CV joint breaks, the vehicle may have a loss of propulsion, increasing the risk of a crash.
- Remedy
- BMW will notify owners, and dealers will inspect the rear driveshaft CV joint and, based on its production date, will replace it, free of charge. The recall began April 21, 2017. Owners may contact BMW customer service at 1‑800‑525‑7417.
Recall number 17V067000 · Recall details
Air bags: frontal: sensor/control module-inactive
- What is wrong
- BMW of North America, LLC (BMW) is recalling certain model year 2011 BMW 528i, 528xi, 535i, 535xi, 550i and 550xi vehicles manufactured March 1, 2010, through August 31, 2011. The affected vehicles may have received a replacement Sensor Cluster Unit (SCU) during a service visit. These SCUs have an acceleration sensor that may have been incorrectly programmed and, as a result, the SCU may not accurately determine if activation and deployment of the air bags, safety belt pre-tensioners and head restraints is necessary in the event of a crash.
- Risk
- Depending on the severity of the crash, inadequate activation of the driver and/or passenger air bags, safety belt pre-tensioners and active head restraints may increase the risk of injury.
- Remedy
- BMW will notify owners, and dealers will replace the SCU, free of charge. The recall began on December 16, 2016. Owners may contact BMW customer service at 1‑800‑525‑7417.
Recall number 16V832000 · Recall details
Fuel system, gasoline: delivery: fuel pump
- What is wrong
- BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 BMW X5 3.0si, X5 4.8i, X5 M, X5 xDrive30i, X5 xDrive35i, X5 xDrive48i and X5 xDrive50i, 2008-2011 X6 x Drive35i, X6 xDrive50i and X6 M, 2010-2011 X6 ActiveHybrid, 535i xDrive Gran Turismo, 535i Gran Turismo, 550i xDrive Gran Turismo and 550i Gran Turismo, 2011-2012 528i, 535i, 535i xDrive, 550i and 550i xDrive and 2012 535i ActiveHybrid, 640i Convertible, 650i Convertible, 650i xDrive Convertible, 650i Coupe and 650i Coupe xDrive vehicles. The affected vehicles have in-tank fuel pumps that may have insufficiently crimped wire contacts.
- Risk
- The loose wires may cause the connector to melt, resulting in a fuel leak. Additionally, the fuel pump may stop working, possibly causing an engine stall and increase the risk of a crash.
- Remedy
- BMW will notify owners, and dealers will replace the fuel pump module, free of charge. The recall began February 2017. Owners may contact BMW customer service at 1‑800‑525‑7417.
Recall number 16V746000 · Recall details
Engine and engine cooling: engine
- What is wrong
- BMW of North America, LLC (BMW) is recalling certain model year 2010-2011 128i Coupe, 128i Convertible, 328i Sedan, 328i xDrive Sedan, 328i Coupe, 328i Convertible, 328i Sports Wagon and Z4 sDrive 30i, 2011-2012 135i Coupe, 135i Convertible, 335i Sedan, X5 xDrive 35i, and X6 xDrive 35i, 2011 335i xDrive Sedan, 335i Coupe, 335i Convertible, 528i Sedan, 535i Sedan, 535i xDrive Sedan, X3 xDrive 28i, and X3 xDrive 35i, 2010 X3 xDrive 30i, and X5 xDrive 30i, 2012 640i Coupe, and 640i Convertible and 2010-2012 535i Gran Turismo vehicles. In the affected vehicles, the bolts that secure the housing for the variable camshaft timing adjustment (VANOS) unit can loosen over time and may possibly break.
- Risk
- If the bolts loosen or break the engine may have reduced power or stall. An engine stall increases the risk of a crash.
- Remedy
- BMW will notify owners, and dealers will replace the four VANOS housing bolts for both VANOS units (intake and exhaust), free of charge. In addition, owners of approximately 170,172 model year 2010-2012 BMW vehicles equipped with inline 6 cylinder engines not covered by this recall, will receive an extended warranty to address this condition. The recall began on September 24, 2014. Owners may contact BMW at 1‑800‑525‑7417.
Recall number 14V176000 · Recall details
Technical service bulletins for the 2011 BMW 535I 355
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Badge Return
- The basic conditions for initializing the power windows are not met.
- The electrical system of BMW vehicles has been subject to an ongoing development process over the last few...
- Engine will crank but not start
- Customers may state that the alarm system (DWA) is not active after locking their unoccupied vehicle
- The Dynamic Stability Control (DSC) warning light comes on while driving
- After programming the head unit (HU-H2), activating the FSC (German word Freischaltcode) Enabling Codes...
- With the court's FINAL approval, BMW of North America, LLC (BMW NA) has entered into a nationwide...
- For the eligible vehicles, BMW of North America, LLC (BMW NA) is extending the limited warranty for the...
- According to the customer, the airbag warning light was on, but it may not be illuminated when the vehicle...
2011 BMW 535I fuel economy
Official EPA estimates in miles per gallon (MPGe for electric). Ranges cover trims that share the same engine.
| Engine | Drive | City | Highway | Combined |
|---|---|---|---|---|
| 3.0L 6‑cyl | RWD | 19-20 | 28-30 | 22-24 |
What 2011 BMW 535I owners say
Most recent owner complaints, unedited.
The contact owned a 2011 BMW 535I. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed, however the vehicle failed to accelerate as intended. The contact stated that the accelerator pedal became stuck. No warning lights were illuminated. The contact stated that the vehicle accelerated into oncoming traffic. The contact's vehicle was crashed into by two oncoming vehicles. No warning light. The contact was taken to the local medical center, where the contact received multiple X-rays. In addition, the contact sustained bruises and pain to the left and right knees and to the middle of the chest. The contact stated that the pain in the chest was severe because of a pre-existing illness of male breast cancer. The vehicle was towed to a local tow yard. In addition, the vehicle was condemned as a total loss by the insurance company. A police report was filed. In addition, the contact was unsure of any injuries to the other drivers. The manufacturer was not made aware of the failure. The failure mileage was approximately 143,000
The contact owns a 2011 BMW 535i. The contact stated that when pressing the accelerator pedal to drive from being idle at a red light, the driver's side air bag deployed out of the steering wheel without impact. The contact sustained burns to the left arm, right cheek, and chest area. The contact had suffered stomach issues due to inhaling the dust and fumes from the air bag. Medical attention was required. The vehicle was towed by AAA to an independent mechanic, where it was diagnosed that the horn module needed to be replaced; however, the part was not available. The vehicle was towed to another independent mechanic, where the vehicle remained for a month, and Liberty Mutual was to retrieve the vehicle and investigate the failure. The contact stated that the vehicle was not investigated to her knowledge, and the vehicle was returned without being repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 132,000.
I purchased the BMW 535 and it continues to have drivetrain malfunction issues. This feels like a safety concern for several reasons. The first is that were not able to identify the issue, but I believe it has to do with the systems diagnostics being triggered or misfiring this is an unfortunateissue because wherever we are, we can get stuck randomly. Lastly, the car has an issue with Oberheu. Issue because wherever we are, we can get stuck randomly. Lastly, the car has a issue with overheating believe it has to do with the radial hose
My car suddenly shut off when I came to a stop at a red light while on a busy state route. The information cluster then began to read “Fuel supply” and “Battery Discharge” My car would not turn back on and still has not turned back on since and it's been over a month now. According to the OBD results, the fuel pump and injectors were somehow seized and therefore have caused the car to become inoperable. I was forced to spend over $1000 just to get my car out of the police tow yard and towed to my home because I could not afford the cost of the repairs needed. The NHSTA website states that there is a recall on both the fuel system and the electrical system for my exact vehicle, but according to my Vin search results, there are 0 recalls. That doesn't make sense. I had just got my new inspection done maybe a month prior to my car breaking down.
The contact owned a 2011 BMW 535i. The contact stated that while the vehicle was unoccupied and parked in a parking lot, it was brought to the attention of the contact that the vehicle caught on fire. The local fire department arrived on the scene to extinguish the fire. The contact stated that it was unknown if a fire report was filed. A police report was filed. No injuries were sustained. The origin of the fire was unknown. The contact stated that the fire damaged one other parked and unoccupied vehicle that was nearby. The vehicle was towed by the insurance and was deemed a total loss. The vehicle remained in the possession of the insurance provider for further investigation. The local dealer was contacted. The manufacturer was not made aware of the failure. The failure mileage was approximately 140,000.
Product Safety Alert: Jan 30, 2025 Stop using the following item because of a potential safety issue. Visit the public recall notice for more guidance. 245/45R18 100Y XL RFT PIR CINTURA P7 (M0E)(BMW/RR) 245/45R18 100Y XL RFT PIR CINTURA P7 (M0E)(BMW/RR)
From very low speed (less than 5 MPH), car would not stop with full brakes applied. Front brakes were fully locked as evidenced by skid marks, but car kept pushing forward until stopped by solid object.
The contact owns a 2011 BMW 535I. The contact stated while driving approximately 35 MPH, the vehicle was losing motive power and was running rough. The contact stated that the instrument cluster went black. The contact turned into a parking lot as the vehicle stalled. The contact attempted to restart the vehicle but after several attempts failed to restart. The contact had the vehicle towed to the residence. The contact had an independent mechanic diagnose the vehicle at the residence. The mechanic diagnosed the vehicle and determined that the VANOS bolts had fractured and the timing camshaft had detached. The mechanic advised the contact to take the vehicle to a dealer. The contact researched online and related the failure to the federal safety agency Campaign Number: 23V707000 (Engine and Engine Cooling) however, the VIN was not included. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 130,000.
The vehicle is having cooling/ heat problems. Does not overheat while driving but rather driving on high temp. Cools to norm temp here and there. My best thought is electrical. Also same vehicle rattles in rear center when going 65mph.. not sure the cause is.
Compare the 2011 BMW 535I
Other model years
Questions about the 2011 BMW 535I
Is the 2011 BMW 535I reliable?
Owners have filed 112 complaints about the 2011 BMW 535I, 2.1 times a typical 535I model year. It is one of the years we flag to avoid.
What is the 2011 BMW 535I year score?
The 2011 BMW 535I scores 44 out of 100 (below average). The score compares it with the other model years of the BMW 535I: 75 is a typical year, 50 means twice the usual complaints, and serious complaints and recalls lower it.
What is the most common problem with the 2011 BMW 535I?
Engine and cooling, with 41 complaints, typically around 96,000 miles. Next is fuel system (35).
How many recalls does the 2011 BMW 535I have?
4 recalls, covering power train, air bags and fuel system, gasoline.
Was there a recall on the 2011 BMW 535I engine?
Yes, 1 recall: 14V176000. Check your VIN to see if your car still needs the free repair.
What year does the BMW 535I have bad engine?
The BMW 535I model years with the most engine complaints are 2011 (41 complaints), 2009 (28 complaints) and 2008 (27 complaints).
What gas mileage does the 2011 BMW 535I get?
Official estimates for the 2011 BMW 535I range from 22 to 24 mpg combined. The most efficient version (3.0L 6-cyl, RWD) gets 19-20 city and 28-30 highway.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2011 BMW 535I?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history