Abs system failed at 26k, upon research,found this to be very common to this year/model, and ,of course, very dangerous on a motorcycle.a replacement ABS unit cost is more that the value of the vehicle!, as a retired firefighter, I can't afford this ridiculous expense,ans as a result,have removed the system, resulting in no power brakes,no ABS, and no speedometer.
The worst 2004 BMW K1200 S problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Brakes3
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Brakes3
Recalls 1
Engine and engine cooling
- What is wrong
- On certain motorcycles, frequent short trips particularly during cold temperatures, can cause water to accumulate in the oil tank, and when the engine is running, escaping water vapor can condense on the oil tank air bleed valve. In freezing temperatures, this water could freeze and block the air bleed valve.
- Risk
- It is possible that a pressure build up in the oil tank could cause it to rupture, allowing oil to leak onto the rear tire. An oil leak could cause a fire. Oil on the rear tire could cause loss of control.
- Remedy
- Dealers will install a new oil tank cap containing a valve to prevent overpressure in the tank free of charge. The recall began on april 10, 2007. Owners may contact bmw at 1‑800‑831‑1117.
Recall number 07V066000 · Recall details
Technical service bulletins for the 2004 BMW K1200 S 14
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- The electrical system of BMW vehicles has been subject to an ongoing development process over the last few...
- One of the following situations can occur when connecting to BN2000 motorcycles: 1. The installed control...
- IT is no longer necessary to place a PMP coded part order to obtain a Repair Enabling code
- Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been...
- Map data should be stored on a 64 GB SD card
- Bluetooth issues between Navigators, mobile phones, communication and audio systems.
- Within the framework of quality monitoring, BMW Motorrad has ascertained that sporadic hot-starting faults...
- Bmw: procedure for determining and replacing incandescent and halogen light bulbs under warranty
- Bmw vehicles: fuel level sensor repairs
- Bmw motorcycle: wheel speed dependent, clearly audible clanking noise occurs when braking to adjust speed....
What 2004 BMW K1200 S owners say
Most recent owner complaints, unedited.
I-ABS pump module failure on very low mileage vehicle, maintained per manufacturer specifications. Abs pump failure causes "residual braking" default, which is about 20% of normal brake performance and significantly less than needed to reasonably stop and control this very heavy motorcycle. Advance warning of ABS pump failure is not assured, so this may result in death or life threatening conditions.
Tl* -the contact stated that there was a loud noise coming from the back of his motorcycle a 2004 bmw k1200 s. The contact took the motorcycle to a dealer and was told that the rivets on the rear brake assembly were separating from the anti- lock braking system. The mechanic told the contact this was a common problem with bmw motorcycles. The bmw dealer said that they would pay for the parts, but not the labor. The 2004 k1200 bmw motorcycle has 43,000 miles.
Compare the 2004 BMW K1200 S
Other model years
Questions about the 2004 BMW K1200 S
Is the 2004 BMW K1200 S reliable?
Owners have filed 3 complaints about the 2004 BMW K1200 S, fewer than a typical K1200 S model year.
What is the most common problem with the 2004 BMW K1200 S?
Brakes, with 3 complaints.
How many recalls does the 2004 BMW K1200 S have?
1 recall, covering engine and engine cooling.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2004 BMW K1200 S?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history