The contact’s son owns a 2009 BMW X5. The contact stated that while driving at approximately 30 MPH, the vehicle stalled. The contact was able to veer the vehicle off the road. No warning light was illuminated. The vehicle was towed to an independent mechanic where it was diagnosed that the fuel pump module failed and needed to be replaced. The contact was then informed by the mechanic of the federal safety agency Campaign Number: 16V746000 (Fuel System, Gasoline). The dealer was notified of the failure and confirmed that the VIN was included in the federal safety agency Campaign Number 16V746000 (Fuel System, Gasoline). The vehicle was then towed to the dealer where the contact was informed that the VIN was included the federal safety agency Campaign Number: 22V119000 (Engine and Engine Cooling) but not the recall related to the failure. The vehicle had not been repaired. The manufacturer was notified of the failure and confirmed that the VIN was not included in the recall and advised the contact to call the federal safety agency Hotline. The failure mileage was approximately 140,000.
2009 BMW X5: fuel pump failure
16 of the 138 complaints about the 2009 BMW X5 describe fuel pump failure.
- owner complaints
- 16
- of this car's complaints
- 12%
- typical mileage
- 87,050
- recalls
- 3
Fuel pump failure by model year
What owners say
During extreme hot days car has just stopped without warning three times. Fuel pump has been replaced twice , now they are saying wiring from the fuel pump to the computer system the wiring bad? No warning ever!
I just went to Union Park Bmw about my car, they stated that my car fuel pump was recalled in 2017 so it was fixed, in 2021 l was stranded twice in 100 degree weather on the side road when the fuel pump went out, so this is the third time this vehicle has had new fuel pumps, now this month on Tuesday 7 /19 when it was hot as hades it stopped again same way it did prior , had it towed and they stated it was wiring that leads to the engine from the fuel pump. They made sure as part of there man made 358.00$ diagnosis that it was not related to the fuel pum.
I was returning home from work and the engine started to sputter/vibrate. I was right next to a gas station and as I was pulling into the gas station, the engine died and would not restart. I had the car towed and then I proceeded to troubleshoot the problem. I did a fuel pressure test and found that there was no fuel pressure. I tested the fuel pump relay and found it to be operational. I accessed the primary fuel pump to check power and found the fuel pump wiring to be missing an inch of insulation on both wires and the insulation is brittle for another inch or two. There were two splices on the fuel pump wiring where recall #16V746000 was performed and a new connector was spliced in. Those two splices were melted together. Recall #16V746000 was a problem with the fuel pump connector melting due to loose wiring. I have concern that there is still an issue with the fuel system wiring overheating or the repair process is not adequate to solve the issue.
There have been two occasions that I have changed the fuel pump on my vehicle. It is extremely dangerous that it turns off suddenly. I am so afraid that this might just happen worst thing is that there are no light indicators that will tell you that there is something wrong.
Letter from congressman pramila jayapal on behalf of constituent regarding vehicle safety recall that dealer won't honor for his 2009 bmw x5. *ld the consumer stated 5 minutes after getting an oil change, the fuel pump failed leaving the consumer stranded.
Tl* the contact owns a 2009 bmw x5. The contact stated that the vehicle failed to start and the fuel cap warning indicator illuminated. The vehicle was taken to mckenna bmw (located at 10900 firestone blvd, norwalk, ca 90650, (562) 219-4570), but was not diagnosed or repaired. The contact stated that the vehicle was previously repaired per the federal safety agency campaign number: 16v746000 (fuel system, gasoline) and the fuel pump was also repaired under warranty at mckenna bmw; however, the repairs did not correct the failure. The manufacturer was notified and referred the contact to the federal safety agency. The approximate failure mileage was 74,025.
My car caught fire while driving under my passenger backseat where the fuel pump is located up under. The fire department came, snatched out seat and put the flame out.
Bmw fuel pump recall vehicle is hard to start and it is progressively getting worse. There is a mandatory the federal safety agency mandated fuel pump recall on this vehicle. We received the owner notification letter. I was told by the dealer at first that the fuel pump is not available. After I persisted the dealer stated that the fuel pump is available but that they have to perform a diagnostic first. A) it is unlawful to charge a diagnostic fee in conjunction with a federally mandated recall. B) the fuel pump issue has been known to bmw for many years (bmw had a voluntary reimbursement of fuel pump repairs in place until the federal safety agency mandated the recall of all vehicles with the affected fuel pump.) the fuel pump should be installed and the parts should be readily available. I just talked with bwm of north america customer service. They stated: * I would have to take the vehicle to the dealer and have a diagnostic run * I would be charged for the diagnostic if it turns out to be an issue other than the fuel pump * if it turns out that the fuel pump module is defective, then I would not have to pay the diagnostic fee this illegally ties a different service (that I may have to pay) to a federally mandated recall. It is not in dispute that the fuel pump recall is mandatory. It is bmw's allocation of parts availability that may result in me having to pay the diagnostic fee.
Tl* takata recall. The contact owns a 2009 bmw x5. The contact stated that the check engine and small vacuum system leak warning indicators illuminated. The vehicle was taken to an independent mechanic who diagnosed that the fuel pump was leaking fumes and needed to be replaced. The contact received notification of the federal safety agency campaign numbers: 16v071000 (air bags), 16v364000 (air bags), and 16v746000 (fuel system, gasoline). The part needed for the repair was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The contact called two local dealers. One dealer informed the contact that the recall was too new and they would call the contact back. The other dealer informed the contact they would not service the recall. The manufacturer was not made aware of the failure. The approximate failure mileage was 140,000. Parts distribution disconnect and VIN tool confirms parts not available.
2009 bmw x5. Consumer writes in regards to replacement parts not available to repair driver front air bag module and fuel pump recall notices.
Takata recall, in 3/2016, bmw sent me a notice to replace driver's front air bag module, however until now, bmw does nothing. In december 2016, bmw sent me a notice to replace in-tank fuel pump because my bmw smells gas badly when parking and driving. However until now, again bmw does nothing. I appreciate your consideration for safety.
Service bulletins that may apply
Related recalls
Fuel system, gasoline: delivery: fuel pump
- What is wrong
- BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 BMW X5 3.0si, X5 4.8i, X5 M, X5 xDrive30i, X5 xDrive35i, X5 xDrive48i and X5 xDrive50i, 2008-2011 X6 x Drive35i, X6 xDrive50i and X6 M, 2010-2011 X6 ActiveHybrid, 535i xDrive Gran Turismo, 535i Gran Turismo, 550i xDrive Gran Turismo and 550i Gran Turismo, 2011-2012 528i, 535i, 535i xDrive, 550i and 550i xDrive and 2012 535i ActiveHybrid, 640i Convertible, 650i Convertible, 650i xDrive Convertible, 650i Coupe and 650i Coupe xDrive vehicles. The affected vehicles have in-tank fuel pumps that may have insufficiently crimped wire contacts.
- Risk
- The loose wires may cause the connector to melt, resulting in a fuel leak. Additionally, the fuel pump may stop working, possibly causing an engine stall and increase the risk of a crash.
- Remedy
- BMW will notify owners, and dealers will replace the fuel pump module, free of charge. The recall began February 2017. Owners may contact BMW customer service at 1‑800‑525‑7417.
Recall number 16V746000 · Recall details
Fuel system, diesel: pre-heater
- What is wrong
- BMW is recalling certain model year 2009-2010 X5 xDrive35d vehicles equipped with a diesel engine and manufactured from June 13, 2009, through November 9, 2009. The fuel filter heater, which is used for warming up the diesel fuel during vehicle operation at low outside temperatures, could experience an electrical overload condition and become permanently activated.
- Risk
- The fuel filter heater could remain activated even when the ignition is off and lead to a dead battery. The unit could also overheat, possibly resulting in a vehicle fire.
- Remedy
- BMW will notify owners, and dealers will replace the fuel filter heater, free of charge. The safety recall began on September 26, 2013. Owners may contact BMW customer relations at 1‑800‑525‑7417.
Recall number 13V339000 · Recall details
Fuel system, diesel: pre-heater
- What is wrong
- Bmw is recalling certain model year 2009 x5 xdrive35d vehicles equipped with a diesel engine and manufactured from october 1, 2008, through june 12, 2009. The fuel filter heater, which is used for warming up the diesel fuel during vehicle operation at low outside temperatures, could experience an electrical overload condition and become permanently activated.
- Risk
- The fuel filter heater could remain activated even when the ignition is off and lead to a dead battery. The unit could also overheat, possibly leading to a vehicle fire.
- Remedy
- Bmw will notify owners, and dealers will replace the fuel filter heater free of charge. The safety recall began on october 11, 2011. Owners may contact bmw customer relations and services at 1‑800‑525‑7417.
Recall number 11V441000 · Recall details
Questions about the 2009 BMW X5 fuel pump
Is fuel pump failure a common problem on the 2009 BMW X5?
16 of 138 owner complaints about the 2009 BMW X5 (12%) mention fuel pump failure. The model year with the most reports is 2014.
Is there a recall or service bulletin for this on the 2009 BMW X5?
There are 3 recalls and 1 service bulletin for the same area of the car. Check them below with your VIN.
Other symptoms on the 2009 BMW X5
Check engine light 10Fire or smoke 9Stalling 9Overheating 7Brake failure 6Loss of power 6Power steering loss 5Won't start 5
VIN decoder
See the problems and recalls for an exact car
Buying a used 2009 BMW X5?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history