2007 Chevrolet Express problems

Filed Oct 16, 2026 · Tires · AZ

Tread belt separated on highway. LT225/75R 16

Filed Mar 30, 2026 · Electrical · 230,000 miles · NV

Odometer Fraud. The contact purchased a 2007 Chevrolet Express. It was later discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the mileage was 71,000; and at the time of registration, it was discovered that the mileage was 230,000.

Filed Aug 4, 2023 · Lights · 200,000 miles · NC

The contact owns a 2007 Chevrolet Express. The contact stated that while driving at an undisclosed speed, the rear passenger side wheel locked without warning. The vehicle was taken to the nearest service station where the rear brakes were replaced. The vehicle was then taken to the dealer where it was diagnosed that the ABS system module needed to be reprogrammed. The vehicle was repaired however, the contact stated that six months later the failure recurred. No warning lights was illuminated. The contact then stated that while driving at an undisclosed speed, he then depressed the brake pedal to stop the vehicle however, after the accelerator pedal was depressed, he noticed a substantial drag and failed to accelerate. The dealer was notified of the failure, but no further assistance was provided. The vehicle was not repaired. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 200,000.

Filed Jan 28, 2022 · Tires · CA

Update to case 11444012 I replaced the 2 tires and Goodyear inspected my other tires and said no problem selling 3 year old tires. Now another one of these tires is cracking. I have removed the tire and it's a clear defect causing cracks and bubbles. 245/75R16 111T SL WRL AT ADVENTURE OWL Tire failed on the inside side wall while the Van was parked for about 2 hours. Tires were purchased in 2019 but has a built year of 2016. AAA service inspected the Van and could not locate reason for issue. I also examined Ring video footage during the event and did not see anything near the Vehicle at the time of the event

Filed Dec 16, 2021 · Tires · CA

245/75R16 111T SL WRL AT ADVENTURE OWL Tire failed on the inside side wall while the Van was parked for about 2 hours. Tires were purchased in 2019 but has a built year of 2016. AAA service inspected the Van and could not locate reason for issue. I also examined Ring video footage during the event and did not see anything near the Vehicle at the time of the event

Filed Aug 13, 2021 · Brakes · CA

2007 chevrolet gm3500. Consumer writes in regards to braking system failure. The consumer stated while driving the brakes locked up. The consumer was able to pull the vehicle to the shoulder. The brake lights did not illuminate. After sitting a few minutes, the vehicle went back to normal operation. The brake failure would continue to occur often. The consumer stated the engime light would illuminate when the failure occured. The vehicle was repaired following a service bulletin, but was too soon to tell if the failure would recur.

Filed Jan 9, 2020 · Lights · PA

Light switch is malfunctioning, I replaced it approximately 3 years ago and I am experiencing the same problem. I think it's a manufactures defaults.

Filed Sep 2, 2018 · Body · 60,000 miles · NC

The paint was constantly peeling off. Big splotches from hood would fly up to windshield and distract while driving. I have recently had whole van painted in order to prevent any more of this.these bare spots were rusting badly also. Very disappointed in this. I am seeing many other vans in town that have the same issue.

Filed Mar 29, 2018 · Electrical · 131,000 miles · TX

Electric window/mirror control panel affixed to the interior of the driver's side door. Electrical thermal event causing smoke and physical damage to the interior side of the door and electrical control cluster and wiring. Vehicle was in use but was not in motion and off roadway. Control panel aftermarket installation prior to purchase. No previous maintenance/repair work performed on door or door control panel. Prior to the event, rain water was observed dripping on to the control panel from the roof which overhangs the door when the door was in the open position. We've experienced with other similar make/model school buses electrical shorts in the driver's side door control panel, which did not result in a 'thermal event" nor fire as experienced on 3/27/18, but did require repairs.

Filed Jun 17, 2016 · Suspension, Wheels · 34,000 miles · NC · fire

Tl* the contact owns a 2007 chevrolet express. While driving at an unknown speed, the ABS warning light illuminated. After all the passengers exited the vehicle, the front passenger side tire exploded and caught on fire. The fire department extinguished the fire. The vehicle was towed to an independent mechanic where it was diagnosed that the hub bearing was fractured and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 34,000.