Tl* the contact owns a 2004 chevrolet impala. The contact stated that the vehicle's pass lock security light illuminated continuously.also, the engine failedto turn over and start. The contact stated that the vehicle took up to an hour to start. The contact was able to remove the key completely from the ignition while the engine was running. The vehicle was not diagnosed nor repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 126,000.
2004 Chevrolet Impala: engine failure
7 of the 1,074 complaints about the 2004 Chevrolet Impala describe engine failure.
- owner complaints
- 7
- of this car's complaints
- 1%
- recalls
- 2
Is there a fix? There are 2 recalls and 70 service bulletins for this area of the car. See below
Engine failure by model year
What owners say
Tl* the contact owned a 2004 chevrolet impala. While driving approximately 45 MPH, the vehicle independently accelerated to approximately 70-80 MPH then seized without warning. As a result, the vehicle lost power steering causing the vehicle to crash into a guardrail. The contact sustained a cracked or broken rib, which required medical attention. A police report was filed. The vehicle was towed to a salvage yard and was deemed destroyed. The contact received a notice for the federal safety agency campaign number: 14v400000 (electrical system) after the crash. The manufacturer was not made aware of the failure. The failure mileage was unknown.
Tl* the contact owns a 2004 chevrolet impala. While driving approximately 65 MPH, the driver lost control of the vehicle due to the wet road surface. The driver failed to bring the vehicle to a stop and the steering and brakes seized. As a result, the driver crashed into an embankment and a tree. The air bags failed to deploy. The driver sustained neck, head, and back injuries and medical attention was received. A police report was filed and the vehicle was destroyed. The contact referenced the federal safety agency campaign number: 14v355000 (electrical system), but it was not confirmed if the vehicle was included in the recall. The manufacturer was not notified. The failure mileage was unknown.
Tl* the contact owns a 2004 chevrolet impala. The contact stated that while driving at approximately 60 MPH, the wheels seized and caused the contact to crash into a concrete barrier. The air bags did not deploy. The contact restarted the vehicle and the vehicle stalled. A police report was not filed. The vehicle was towed to an independent mechanic. The vehicle was not repaired. The failure mileage was 87,000. Updated 09/17/14*lj updated 02/12/2015
Tl* the contact owns a 2004 chevrolet impala. The contact was driving approximately 35-40 MPH when the engine stalled without prior warning. The engine failed to restart and the vehicle was towed to an independent repair shop for diagnosis. The technician informed that the pass lock system was designed with two incorrect pins which resulted to the failure. The pass lock system was replaced. The failure was approximately 123,000.
Tl*the contact owns a 2004 chevrolet impala. While driving at an unknown speed, the temperature for the engine failed. One month later, the speedometer failed. The vehicle has not been diagnosed by a dealer. The fuel system was unknown. The current mileage was 62,500 and failure mileage was 61,000.
Clunking noise in front end steering , went to dealer was told I would have to replace steering part that was beginning to seize , I think that this is a real safety issue seeing that if the steering seized I would be unable to steer the car.
Service bulletins that may apply
- This service bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves...
- This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake...
- This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil...
- This PI bulletin advises the technician on the proper way to install the pistons in an engine.
- This service bulletin provides graphics, information and guidelines for engine component wear to assist...
- Engine
- This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter...
- This service bulletin provides service information on new torque specification and installation procedure...
Related recalls
Engine and engine cooling: engine
- What is wrong
- General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V‑118, 09V‑116, and 15V‑201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
- Risk
- Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
- Remedy
- The remedy applied under recalls 08V‑118, 09V‑116, and 15V‑201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V‑118, 09V‑116, or 15V‑201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1‑800‑222‑1020, Buick customer service at 1‑800‑521‑7300, Oldsmobile customer service at 1‑800‑442‑6537 and Pontiac customer service at 1‑800‑458‑8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Recall number 15V701000 · Recall details
Engine and engine cooling: engine
- What is wrong
- General Motors LLC (GM) notified the agency on April 2, 2015, that they are is recalling certain model year 2004 Buick Regal vehicles manufactured April 9, 2003, to June 1, 2003, 2004 Chevrolet Impala vehicles manufactured April 8, 2003, to June 23, 2003, and 2004 Chevrolet Monte Carlo vehicles manufactured April 7, 2003, to June 23, 2003. On May 18, 2015, GM expanded the recall to cover an additional 49,751 2004 Pontiac Grand Prix vehicles manufactured January 6, 2003, to June 25, 2004. In the affected vehicles, the valve cover gasket may leak.
- Risk
- The leaking engine oil can drip onto the hot surface of the exhaust manifold, increasing the risk of a fire.
- Remedy
- GM will notify owners, and dealers will remove the plastic cover and plastic oil fill tube extension and replace the front valve cover and gasket. These repairs will be done free of charge. The recall began on April 24, 2015. Owners may contact Buick customer service at 1‑800‑521‑7300, Pontiac customer service at 1‑800‑762‑2737 or Chevrolet customer service at 1‑800‑222‑1020. GM's number for this recall is 14574.
Recall number 15V201000 · Recall details
Questions about the 2004 Chevrolet Impala engine failure
Is engine failure a common problem on the 2004 Chevrolet Impala?
7 of 1,074 owner complaints about the 2004 Chevrolet Impala (1%) mention engine failure. The model year with the most reports is 2000.
Is there a recall or service bulletin for this on the 2004 Chevrolet Impala?
There are 2 recalls and 70 service bulletins for the same area of the car. Check them below with your VIN.
Other symptoms on the 2004 Chevrolet Impala
Headlights 89Won't start 86Fuel gauge 66Stalling 40ABS 36Overheating 29Grinding brakes 22No deployment 21Fire or smoke 17Check engine light 16Adaptive cruise 15Jerking 13Steering noise 13Warning lights 13Loss of power 10Slipping 10Harsh shifting 9Airbag light 7Transmission failure 7Wipers 7Knocking 6Premature wear 6Fuel pump 5Hesitation 5
VIN decoder
See the problems and recalls for an exact car
Buying a used 2004 Chevrolet Impala?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history