2021 Chevrolet Silverado 1500 brakes problems

Filed Sep 2, 2026 · Brakes · TX

While coming to a stop, a snap ring came off the brake master cylinder. Vehicle top speed was 40mph, with the parking brake automatically engaged. ***Note from mechanic: Vehicle has several brake faults, C05CC and C05CF master cylinder piston position sensor performance, C2A17 hydraulic brake sponginess, and C0277 brake pedal position sensor fault. Tech recommends Hydraulic Brake Unit replacement***

Filed Aug 12, 2026 · Airbags, Brakes · NV · crash

Turned from [XXX] into my street, about 9 houses down, i could not brake or turn steering wheel. Ended up hitting 2 cars, the problem was that the air bags did not deploy and the seat belt did not lock. truck was totalled. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 14, 2026 · Brakes, Electrical · 110,881 miles · KS

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed, the message that the rear seats were occupied and that the windows were rolled down was displayed, which required the contact to press the OK button. The vehicle was taken to the dealer where it was purchased, but no assistance was provided. The traction control and the ABS warning lights were illuminated while depressing the brake pedal. Additionally, the cruise control mode was inoperable. The contact replaced the brake pedal position sensor independently, and the vehicle was taken to an independent mechanic, who reprogrammed the sensor. The contact stated that after the repair, the brake lights erroneously illuminated while the vehicle was turned off, causing the battery to drain. The contact disconnected and reconnected the battery, which reset the vehicle; however, the failure recurred. The vehicle was not further diagnosed or repaired. The manufacturer was not contacted. The failure mileage was 110,881.

Filed Jul 1, 2026 · Brakes, Driver assistance · NC

I was on the highway doing 70 MPH with my family driving down I-40 through western NC (mountainous terrain) when my brakes went out and the vehicle went into limp mode. I was able to safely pull over thank God and then had my vehicle towed to the dealer. The dealer just informed me that a software update is needed, and not covered under warranty. There are multiple safety bulletins coming out for related years and issues related to the braking system of this make/model and I would like this documented as well as Chevy to cover the cost of repairing this defect.

Filed Jun 10, 2026 · Brakes, Engine · AR

Loud ticking noise and power loss. Transmission shift slips from 2nd to 3rd . Called factory and dealership for check up. Said no problem… Told to Change oil. Did this, NO CHANGE.

Filed May 25, 2026 · Brakes · AR

While driving my 2021 Chevrolet Silverado 1500 Trail Boss, multiple warning lights and messages suddenly appeared related to the ABS and brake system. The brake pedal became extremely difficult to press and the truck became unsafe to drive. The issue happened unexpectedly while the vehicle was in operation, creating a serious safety hazard and risk of accident or injury. After the incident, the truck was inspected by a mechanic who advised that the brake booster had essentially fallen apart and that I effectively had little to no braking capability. I was also informed that the condition and quality of the braking components were not acceptable for a vehicle of this age. This vehicle is only five years old and has been regularly maintained. For approximately the last three years, routine maintenance including oil changes, tire rotations, and inspections were performed at a Chevrolet dealership. At no time was I warned of any brake-related issue or safety concern. A major brake system failure should not occur suddenly on a properly maintained vehicle, especially without warning. This incident was extremely dangerous and could have resulted in a serious crash. I am submitting this complaint because I am concerned there may be a defect involving the brake system, brake booster, ABS system, or related components on this vehicle.

Filed May 14, 2026 · Brakes, Driver assistance · CA

Once I disengaged the auto stop on my vehicle, I would accelerate from a stop and I would loose my brakes. This happened several times. I took it to the shop and was told it was fine. Finally, one day I was descending on an overpass, disengaged my auto stop and my brakes were complete failure, even my emergency brakes, my check engine light engaged (the code read emissions issue). Was able to stop in a field, get it back to the dealership to find out I lost the master break cylinder but no indication on prior visits. The truck, check engine light will spontaneously start blinking but hold no codes. I have had it routinely serviced and it will overheat and oil will run hot but mechanics find no issues

Filed May 4, 2026 · Brakes, Electrical · OH

Two grounding straps failed on my 2021 Silverado Trail boss lt. GM has a recall for this exact problem under N252515590, model years 2019-2024. Apparently my vin number is not associated with this recall, yet my dealer just did the recall repair. They said my truck did not qualify for the GM recall and I was forced to pay for the repair. The failing grounding straps caused my power steering to go out and my brake system and safety traffic sensors to fail as well. This was very dangerous as it would fail randomly while driving the truck. There were no warning signs or lights on the the truck to indicate any problems.

Filed Mar 16, 2026 · Brakes, Driver assistance · 125,000 miles · FL

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated while driving at various speeds, the vehicle started shaking abnormally. The Service Electronic Stability Control (ESC) warning light, Parking Brake warning light, a wrench warning symbol, and the check engine warning light were illuminated. The vehicle was not taken to the dealer to be diagnosed or repaired. The manufacturer was informed of the failure and confirmed that there was no recall associated with the VIN. The contact was referred to the federal safety agency Hotline to report the failure. The failure mileage was approximately 125,000.

Filed Mar 10, 2026 · Brakes · TX

Master Brake Cylinder failed according to dealership. This however is the second time this issue has occurred. This system failure caused brakes to not respond correctly leading to risk of collision. My safety and my kid's safety was put at risk due to issue happening while vehicle was in drive. Part was initially replaced in April of 2025 and issue has occurred two more times since then in December of 2025 and February of 2026. Vehicle has been inspected by dealership multiple times but has not been fixed. Symptoms of issue included clicking sound when pressing brake pedal and becomes stiff. There were warning in the dash and lights: "Brake System Failure", "43MPH Top Speed", "Service ESC" and "Service Brake System". Along with Check Engine light, Brake light and Traction Control light.