2021 Chevrolet Silverado 1500 fuel system problems

Filed Oct 12, 2026 · Engine, Fuel system · WI

On my way home to [XXX] from [XXX] around XXX, my 2021 Chevy Silverado with 84,xxx miles with the 6.2 L engine started to make a popping sound. I checked my dash for any error codes and there were none. The oil pressure, temp, and transmission temp gauges all read normal. I stopped and topped the gas tank off with premium gas and checked the oil level, which was good. I was able to limp the truck back to my house. The next morning when I started it, there were error codes and the engine was still making the popping noise as well as a louder knocking noise. I started researching the symptoms, called two local independent shops and concluded the DFM system that shuts cylinders off to conserve gas has failed and caused the lifters to fail. I was told the failed lifter could and probably did damage the cam shaft(s). If I kept driving it, the camshaft damage could cause complete engine failure and more safety consequences. One shop quoted $5000 to replace lifters and $8000 if the camshafts were damaged. The other shop was similar, but offered a rebuilt engine for $12,000 because the lifters, camshafts, and new GM crate engine were all back ordered with no ETA from the local Chevy dealership. After weighing my options, and needing a truck, I decided to trade in my damaged truck. I contacted the GM concierge on XXX and was told to call back when the dealership had my damaged truck and could diagnose it. On XXX I called them back and they said they wouldn’t help because I traded it in. I had no plans to trade it before the engine failed and took a substantial hit on the trade in price that GM should have helped with to cover their faulty DFM system that caused the lifters to fail, which the dealership confirmed was the problem. They said they wouldn’t know if the camshafts were damaged until they took it apart, which they decided to not do and send it to auction instead. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 6, 2026 · Engine, Fuel system · MI

I was traveling on a 55mph road. My Chevy Silverado started to shake and lose propulsion. I pulled off on the side of the road. In idle it shook. The dealership was one mile to my south. I turned on the hazard lights and went to the dealership. I could only get the vehicle to 45mph as in shook very bad the whole way. It felt as if the engine was going to explode the whole way there. The vehicle was taken to the dealership where it has been initially diagnosed as a bad lifter.

Filed Oct 4, 2026 · Engine, Fuel system · TX

I am submitting this complaint regarding a 2021 Chevrolet Silverado 1500 Trail Boss 4WD with the [6.2L V8 (L87)], VIN [XXX], 101,000 miles. The truck was assembled in Mexico in XXX, about six weeks before XXX, just outside the build range of GM recall 25V‑274 (N252494000, Engine Failure). On 10/2/2026, [XXX], [XXX] a certified GM dealership, diagnosed crankshaft and lifter failure, matching the recall condition. Codes: P0300, P050D, P0016. The truck was shaking violently, the ESC and emergency braking system failed, reducing engine power. GM's Part 573 filing attributes the defect to out-of-specification crankshafts and identifies a Mexico-based crankshaft supplier. I ask GM to confirm my engine's build date and crankshaft source. A six-week gap in build date should not exclude a truck with the same failure. Engine failure can cause sudden loss of power while driving, a safety risk. The dealer quoted repairs of up to $10,292.00. I request: That GM cover the repair in full as a goodwill adjustment. That GM and the federal safety agency review expanding the recall population to trucks built near my date. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 27, 2026 · Fuel system · FL

Truck stalled out while driving as if it had run out of fuel. Had to be towed to my house

Filed Sep 9, 2026 · Electrical, Engine · FL

My 2021 Chevrolet Silverado 1500 RST with the 6.2L engine experienced an engine seizure. The engine was replaced by a Chevrolet dealership under a GM safety recall. Immediately after picking up the vehicle following the recall engine replacement, the truck stalled while still in the Chevrolet dealership parking lot. There was no warning before this first stall. We continued our trip because we did not realize at the time that the stall could indicate a problem following the engine replacement. During the drive from [XXX] to [XXX], the problem continued. In [XXX], the check engine light illuminated and the truck began malfunctioning. The vehicle subsequently stalled again. The problem continued after returning to [XXX]. A Chevrolet dealership in [XXX] inspected the vehicle and reproduced/confirmed a problem involving the camshaft position sensor wiring/connector. The dealership demonstrated the problem by manipulating the connector/wiring and recorded a video of the diagnostic procedure. The vehicle is currently at the Chevrolet dealership and is available for inspection. The affected component should also be available for inspection because it has not yet been repaired. The [XXX] dealership has characterized the wiring/connector condition as normal wear. However, the first stall occurred immediately after the GM recall engine replacement, while the vehicle was still on the repairing Chevrolet dealership's property. Unexpected engine stalling creates a serious safety risk because the vehicle can lose propulsion without warning while driving, including at highway speeds or in traffic. I am concerned that the camshaft position circuit/wiring/connector problem may be associated with the recall engine replacement procedure or replacement engine. I am requesting that the federal safety agency investigate whether other vehicles receiving this GM 6.2L engine recall remedy have experienced similar camshaft position circuit failures or unexpected stalling after engine repair. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FO

Filed Aug 6, 2026 · Engine, Fuel system · OK

On August 22, 2025 the malfunction indicator lamp (code: P146B Evap. purge pump) illuminated with no noticeable change. Ran codes at auto zone which stated engine failed and emissions not ready. August 25, 2025 drove to certified Chevy dealer dropped off vehicle and showed the service advisor the fix finder test results from auto zone as well as the illuminated indicator lamp (check engine light). August 26, 2025 picked up my vehicle with receipt stating "found dtc's P146b and P1467 stored in ECM (engine control module) for evap purge pump fault. inspected evap canister for any signs of fuel and none were found. replaced evap purge pump per special policy #N232395310. Cleared dtc and road tested vehicle to verify repair". September 9, 2025 my engine indicator light illuminated and my engine entered limp mode, a safety feature which reduces cylinder output/capacity. September 12, 2025 while in limp mode, I returned to the service dealer and informed them of the reduced power (limp mode) and my confusion as the second engine symbol that has been illuminated is in a different area than the first and my truck has ONE engine. (editor note: malfunction indicator lamp is for the emissions). My original transmission (8L90) was replace, because my vehicle was under power train warranty and the service advisor took it upon himself to approve the disassembly of my running, in good condition 8L90 transmission without consulting me or my approval. the 8L90 was "discontinued" for the 2020-2022 years without recall come to find out (sarcasm). I now have a new transmission (8L86-85) with the "special coverage" part (#N232395310) still connected, only now I have NO additional powertrain coverage for a new transmission, but the "special coverage" originally issued in 2023, BY MAIL, for 15 yr/150,000miles has extended two years plus mileage. (15 yr / 152,955) .The "special coverage" part should NOT affect the engine! Engines produce power/HEAT not CO2 . Sarbane - Oxley Act.

Filed May 29, 2026 · Fuel system · FL · 1 injury

2021 Chevrolet Silverado 1500 Custom 2.7 L Turbo 4 cylinder with 34,000 miles When Truck cranks and put in gear begins moving at low speed between 1-2 gear (low speed 5-10 mph forward and also in put into reverse) hard jolted severely injuring passenger. Felt like being rear-ended by another car. Passenger was hurt & required Trauma 1 EMS & 2 surgeries (Spinal Fusion Surgery) hospitalization from 12/2/2025 to 12/13/2025. The truck jolt directly caused this accident and there were many recalls for this truck yet we had no direct knowledge of this information & was never notified of any of these issues. Truck was services at same dealership just weeks prior to accident. The truck check engine light came on only after the accident. It happened on a private gated property. Only select trucks have been said to do this very hard jolted injuring passenger and owners are not made aware using Silverado 1500 trucks. Please acknowledge receipt of this report and advise. Thank you.

Filed May 5, 2026 · Engine, Fuel system · CA

Lifter failure at 50,100 miles- just out of powertrain warrant by 136 days. Failure occured on freeway. After hearing metallic sound service brake system light, traction control and service engine light came on. This occured 5/3/26.

Filed Feb 23, 2026 · Fuel system · GA

At 62000 miles, I was having a transmission problem but had no check engine lights associated with the issue. The day I took it to the dealership for the transmission, the check engine light came on for the first time ever when I started the vehicle. The dealership first said it was a faulty solenoid on the purge valve, replaced that part, but it didn’t fix the problem. The dealership then said it needed a new fuel pump control module, which was heavily back ordered due to demand. I needed the vehicle because it had already been at the dealership for a transmission replacement for many weeks and is my only transportation. The dealership told me other vehicles were there for the same problem, parts were on a national back order and being rationed to dealerships around the country. They could not provide an estimate for when my vehicle would be ready and pushed me to trade in my vehicle as a solution. The sales manager offered a very low trade in value, told me I couldn’t get the part faster by purchasing it myself, and was very pushy. She said my vehicle was devalued because it didn’t have the fuel pump control module needed for the check engine light to turn off, and had a history of transmission problems (even though it just got a new transmission). I got frustrated and ordered the new GM part from summit racing and had it on my doorstep in two days. I took it to the dealership and all of a sudden they had received a shipment of this part, and replaced the faulty one in my vehicle. Their repair resolved the problem, but I still had reliability concerns. Despite all repairs being completed, the sales manager said the vehicle trade in value remained unchanged. It was a complete nightmare and I felt my vehicle was being held back from repair resolution to convince me to trade it in for a new truck. I kept my vehicle and extra part I ordered in case this happens again.

Filed Feb 15, 2026 · Electrical, Engine · KY

I just bought this truck off a used car lot certified dealer and I noticed the engine light on then the truck would hesitate to start and I know the battery is dying so I looked it up and I got a recall on 2021 Chevy Silverado just like mine just wondering why mine is not under recall or why won’t mine get fixed but everybody else is the same year in the same problems can get fixed. I think mine should be fixed.