2022 Chevrolet Silverado 1500: excessive oil consumption

Filed Sep 28, 2026 · Engine · 7,000 miles · TN

The contact owns a 2022 Chevrolet Silverado 1500. The contact stated that the vehicle was consuming an excessive amount of engine oil, Additionally, the vehicle rattled abnormally and lost motive power intermittently while driving 70-75 MPH on the interstate and while driving uphill. The driver pulled over to the side of the road on several occasions; however, the vehicle stopped in the middle of the road on one occasion while driving uphill. After waiting for several seconds, the vehicle became drivable. The contact stated that the engine was previously replaced twice due to similar failures, after which the vehicle needed to be towed. The manufacturer was notified of the failure and referred the contact to the dealer, where an oil consumption test was recommended. However, the contact stated that the oil consumption test required driving the vehicle. The contact associated the failure with the federal safety agency Action Number: EA26005 (Engine). The failure mileage was approximately 7,000.

Filed Sep 14, 2026 · Engine · KS

Engine is the 6.2L V8. Engine has started consuming oil. Consumed approximately 3 quarts of oil over 4k miles. 0 signs of external leakage.

Filed Sep 3, 2026 · Transmission · 81,700 miles · CA

The contact owns a 2022 Chevrolet Silverado 1500. The contact stated that while driving 55 MPH, the vehicle unexpectedly stalled while attempting to accelerate, with the check engine warning light illuminated. The contact stated that the rear wheels locked up due to the failure. The vehicle was pulled over to the side of the road but was unable to exceed 3 MPH. The vehicle was restarted. There was a burning oil odor, but the contact was unsure if the odor was coming from the vehicle or another vehicle nearby. The vehicle was taken to the dealer to be diagnosed, and DTC: P0700 (Transmission Control System) and P2714 (Pressure Control Solenoid Performance/Stuck Off) were retrieved. The contact was informed that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure by phone, and the contact was referred to the federal safety agency Hotline for further assistance. The failure mileage was approximately 81,700.

Filed Sep 2, 2026 · Engine · MS

I did the 0w-40 oil swap and now my truck is having more issues than before the recall, doing a “oil consumption test”

Filed Aug 14, 2026 · Engine · NC

* Engine/ Yes available for inspection. * Has not happened yet, however the risk exists. * Yes, oil consumption and has been confirmed by dealer and monitored every 1,000 miles. * Been inspected by local dealer only. * Yes, low oil pressure light came on. I was 2 qtrs. LOW, XXX My vehicle was inspected and according to them "passed". 0W-40 was introduced and a new oil cap indicates the change. GM explains that it is acceptable to burn up to 2 qtrs. of oil between oil changes. They have me come to the dealer every 1,000 miles to check the oil level. I came back from a work-related function, putting approx. 220 miles. It was time for oil level inspection, and my engine was found to be 1/2qtr. LOW. I ask them to top it off and I was told; “we do not stock this oil in bulk; you have to buy a qt. and we'll put it in." I have been a car owner since I was [XXX], now [XXX] and have never heard such nonsense in my life. In fact, in my lifetime, I have NOT experienced engine burning oil. This is a 6.2 liter with 57,700 and my fear is that something catoptric will happen to the motor resulting in no recourse. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jun 10, 2026 · Engine · TX

Low engine oil level appeared on my 2022 Silverado LTZ with the 6.2L engine for the first time of ownership. The truck is on the first 0W40 oil change performed for the engine recall with 42% engine oil life left. I get the oil changed around 30% left. Up until this point while running the 0W20 this hasn't happened. I'm now concerned that because of the oil viscosity difference that this may become an on going issue.

Filed Mar 24, 2026 · Engine, Fuel system · FL

Year: 2022 Make: Chevrolet Model: Silverado 1500 Engine: 2.7L TurboMax (L3B) VIN: [XXX] Mileage at Failure: 119,139 Description of Problem: 2022 Chevrolet Silverado 1500 2.7L L3B TurboMax engine is completely inoperable due to Cylinder 4 exhaust roller follower failure causing exhaust camshaft failure and bent exhaust valves. Vehicle shakes severely, will not accelerate, check engine light on, and has gone into limp mode. Diagnostic codes P0304 (Cylinder 4 misfire) and P2101 (electronic throttle actuator fault triggered by engine shaking and limp mode) were recorded. All external components including spark plugs, coils, and injector harnesses were inspected and ruled out as causes. Failure is confirmed mechanical and internal. This failure was diagnosed and documented in writing by an authorized Chevrolet dealership on March 12, 2026 (Repair Order XXX, Service Advisor [XXX] ). The dealer's written estimate states verbatim: "Failed Cylinder 4 exhaust roller follower failure causing exhaust camshaft failure and bent exhaust valves. Cylinder head replacement required to correct this concern. Direct cause of engine noise and misfire condition." Dealer repair quote: $10,371.34. A second independent shop confirmed the same failure and cited Active Fuel Management (AFM) and Direct Fuel Injection (DFI) as known contributing design factors in this engine's oil consumption and internal wear pattern. That shop quoted between $11,876.88 and $14,897.35. This is a known pattern in the L3B engine platform. Consumer Reports has documented a 4% catastrophic failure rate in this engine. Multiple the federal safety agency complaints exist for this same failure across 2019-2022 model years. GM has issued technical service bulletins but has not issued a recall. General Motors was formally notified of this failure via certified mail and executive email on March 24, 2026. Vehicle is inoperable and poses a safety risk as the failure causes sudden loss of power and engine shaking w INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOI

Filed Feb 9, 2026 · Engine · AL

On 2/5/2026, the 6.2 liter L87 engine in my 2022 ZR2 Silverado locked up and is currently located at Edwards Chevrolet on highway 280 in Birmingham, AL. While on I-65 in Birmingham, AL. and prior to locking up, the engine power decreased, and RPM's increased, followed by a dash message that oil temperature is high; pull over and idle. After idling the engine the dash message disappeared and oil pressure was good. We drove approx. 1.5 miles to a parking lot where the engine seized or locked up. The truck was towed to the above referenced dealership. The dealership confirmed the engine was locked up the next day. During the Summer of 2025, the dealership inspected the engine and performed an oil consumption test after I reported the engine had burned two quarts of oil between oil changes. Their fix was to transition from 0W-20 to 0W-40 oil, which has been adhered to since. The truck only has 56,000 miles on it.

Filed Jan 21, 2026 · Engine · MN

I took my truck in for the recall on the L87 6.2 engine PCOED test and they said it passed. They changed to the 0-40 oil. I noticed a significant fuel mileage drop from mid 20 to low 14 on long highway drives. I had an oil change done and drove 500 miles the next day and there was just a trace of oil on the dipstick. I called my chevy dealership and they said that is normal for oil consumption. I topped off the oil before heading back home and used 3/4 of a quart. I am watching my oil consumption and looking to do an oil consumption test done by the dealership. They did not recommend this test I researched it. I am concerned my engine will blow up.

Filed Dec 27, 2025 · Engine · VA

I've owned the 2022 Silverado High Country with 6.2L engine. Over the past 3.5 years, the engine has had oil consumption issues where I was required to take the vehicle to Chevrolet dealership every 500 miles in Hampton, VA to have the oil level checked. I kept getting the message "low Oil Level" on the information center. I also kept hearing loud ticking noise coming from the engine. Chevy service would top off the oil level (sometimes 1/2 or 1+ quart low), and send me on my way. After oil consumption and ticking noise continued, I was notified by Dealer that a Safety Recall April 2025 was issued by GM. I met with GM Representative and Chevy Service Manager April 2025, and based on my truck history with oil consumption and lifter noise, decision was made to replace engine. New Engine was installed May 2025 and all appeared to be good to go. However, in November 2025 I heard the loud clicking noise in the new engine. Hampton, VA Chevy service conducted an inspection and found a bent push rod in new engine. Service replaced the push rod and all lifters based on history of lifter issues.

Filed Nov 13, 2025 · Engine · NC

Since brand new engine has had oil consumption issues. Countless times I have been told it is ok and there is no problems with it. I took it to a different dealer and I am now being told I need to replace pistons and rings.

Filed Sep 23, 2025 · Engine · TN

Vehicle has used an abnormal amount of oil since new Now uses 1 quart of oil every 500 miles Have been trying to get recall inspection done for three weeks with no response from dealer or manufacturer