2023 Chevrolet Silverado 1500: misfire or rough idle

Filed Oct 12, 2026 · Engine · CA

My 2023 Chevrolet Silverado 1500 ZR2 equipped with the 6.2L L87 V8 has exhibited abnormal engine behavior since shortly after purchase, well before GM announced the engine recall. Symptoms include extremely loud intermittent metallic lifter/valvetrain noise during cold starts, persistent rough idle, and noticeable engine vibration that causes the truck to rock back and forth after warming up. Paradise Chevrolet and Bunnin Chevrolet subsequently performed GM's prescribed PicoScope inspections, and both reported passing results. The oil-viscosity recall remedy was also completed, but the symptoms remain unresolved at 47,133 miles. I am concerned about potential internal engine damage and the possibility of sudden engine failure or loss of propulsion. Given the federal safety agency's investigation into L87 engine failures following recall repairs, I am requesting further investigation into the adequacy of GM's recall remedy.

Filed Sep 24, 2026 · Engine · WA

Engine failure on our 4-cylinder- it just quits same problem as on the 6-cylinder - it just stops running or runs rough. No warning signs and no indication that it is about to fail. Hazardous on the freeway. Vehicle has been at the mechanics for a month now and GM keeps saying the engine is on backorder.

Filed May 28, 2026 · Engine, Fuel system · CA

While driving, the vehicle suddenly displayed “Service ESC” and “Service Traction Control” warnings. Shortly after, the engine stalled and the vehicle became difficult to restart. Vehicle experienced rough running/misfires and loss of power. Diagnostic trouble codes retrieved included P0300, P0106, P3498, P00FF, and U1962. The issue appears intermittent but creates a serious safety concern due to unexpected stalling while driving. Concerned about possible electrical, engine management, or stability control system failure affecting safe operation of the vehicle. No prior warning before incident.

Filed May 13, 2026 · Engine · TX

What component or system failed or malfunctioned, and is it available for inspection upon request? ENGINE How was your safety or the safety of others put at risk? The truck exhibited an abnormal, rough idle, severe shuddering, poor acceleration, unable to maintain speed on highway and in traffic Has the problem been reproduced or confirmed by a dealer or independent service center? Yes Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No, only the dealer Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Yes, check engine light appeared and was cleared by dealer, then reappeared a week later

Filed Mar 19, 2026 · Engine · TX

The vehicle is currently exhibiting a loud, rhythmic metallic ticking/tapping noise from the top of the engine. This is a known precursor to a sudden, catastrophic loss of motive power as documented in GM Service Bulletins PIP5847A and PIP6101. The cause is attributed to manufacturing debris within the hydraulic valve lash adjusters, which prevents proper lubrication and causes valvetrain desynchronization. This defect leads to severe engine misfires (DTC P0300), "Reduced Engine Power" mode, and potential engine seizure. ​1. Component/System: The 2.7L L3B Engine Valvetrain / Hydraulic Lash Adjusters. The vehicle is available for inspection. ​2. Safety Risk: The audible ticking indicates imminent mechanical failure. This defect causes sudden and unexpected loss of motive power at highway speeds. Driving in this condition puts me at extreme risk of being stranded in active traffic or losing power while merging/passing, creating an immediate risk of high-speed rear-end collisions. GM is aware of this debris-related defect via TSBs but has not issued a safety recall to prevent the resulting power loss. ​3. Dealer Confirmation: Yes, confirmed by Chevrolet dealer on 3/18/26. The dealer knows about this particular issue, and decided not to act. ​4. Inspection History: Inspected by authorized Chevrolet service technician. ​5. Warning Symptoms: Loud metallic ticking/clacking that increases with engine RPM. This is a known precursor to a sudden, catastrophic loss of motive power as documented in GM Service Bulletins PIP5847A and PIP6101.

Filed Nov 17, 2025 · Engine, Fuel system · IN

The contact owns a 2023 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed, the engine was running rough. The message "Service ECM" was displayed. The vehicle was taken to Auto Zone, where diagnostic trouble codes displayed fuel injector misfiring on cylinders 1 and 4. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was unknown.

Filed Oct 28, 2025 · Engine, Fuel system · TX

While driving and idling, my 2023 Chevrolet Silverado 1500 High Country equipped with the 6.2L v8 engine began experiencing a persistent audible ticking/clicking noise from the engine bay, rough idle during cold starts, and noticeable/abnormal engine vibration. Shortly after, the check engine light came on. When scanned, diagnostic codes P0304 (Cylinder 4 Misfire Detected) and P050D (Cold start Rough Idle) were retrieved. The vehicle was inspected by an authorized Chevrolet dealership, and the service advisor and technician confirmed hearing a consistent clicking noise and documented that they contacted GM's Technical Assistance Center (TAC case #80413912). The service order report states: "Due to unknown noise cannot perform recall. Called TAC 80413912 and was told need to figure out top end noise and misfire before proceeding with recall. If repairs are related to top end, will not be covered under recall." The technician indicated this could be related to a camshaft and lifter issue, which matches the symptoms outlined in GM's active propulsion system recall for 6.2L engines. Suggests GM aware & has not yet confirmed full recall coverage/repairs. This issue presents a significant safety risk because the engine could experience sudden power loss or failure while driving, potentially leading to loss of propulsion or control. These symptoms are identical to those described by GM in their recall documentation concerning valve lifter and camshaft failures. The issue has been reproduced and confirmed by the dealership, and all documentation, diagnostics reports, and service notes are available for inspection upon request. Warning/check-engine lights first appeared in October 2025, and the problem persists. Based on GM's recall acknowledgment of similar failures, I believe this defect should be fully covered under the existing recall, and I am requesting the federal safety agency's review to ensure manufacturer addresses this safety-related defect promptly and without cost to owners.

Filed Aug 4, 2025 · Engine · 49,500 miles · AZ

The contact owns a 2023 Chevrolet Silverado 1500. The contact received notification of the federal safety agency Campaign Number: 25V274000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that while driving 65 MPH uphill, the check engine warning light illuminated. The contact pulled over to the side of the road and turned off the vehicle. The contact was able to restart the vehicle after waiting for several minutes. Additionally, the contact stated that vehicle was idling rough while driving. The contact stated that the rough idling persisted. The vehicle was taken to the dealer but was not diagnosed or repaired because the recall repair part was not available. The contact scanned the vehicle with a diagnostic code reader and retrieved DTC: P0016, which indicated that the powertrain control module (PCM) had detected that the crankshaft and camshaft were not synchronized. The vehicle was not repaired. The manufacturer was not made aware of the failure. The contact had safety concerns while driving the vehicle. The failure mileage was approximately 49,500.

Filed Apr 25, 2025 · Engine · CA

I have had an intermittent, aggressive engine knock and rough idle since i bought the truck. I'm assuming it has to do with the collapsing lifter issue from the fuel management system. when I bring it to the dealership (paradise chevrolet ventura) , they tell me that they cannot replicate the issue and that if there is no check engine light on the dash, there is nothing they can do. I am concerned for my families safety and my truck becoming an issue after my warranty runs out. my chief complaint has been documented by the dealership multiple times and I have video of me replicating the issue.

Filed Dec 30, 2024 · Engine · FL

I was driving and received a check engine light with “Service ESC” and traction control was disabled. Performed diagnostics and found P0300, P0304 and P0204 all relating to cylinder 4 misfire and injector issues on cylinder 4. Truck has just over 47,000 miles and may be related to the lifter issues that plague this engine design.