1996 Chevrolet Suburban airbags problems

Filed Jun 20, 2006 · Airbags · OH · crash

From: david b parker comments: in a crash on 5/27/06 where another driver pulled out in front of me and I hit him at approximately 45 MPH or slightly below the driver's side airbag in my 1996 chevy. Suburban 1500 lt. If this is a known problem, please add this to your database; if not you may want to investigate other such models. I do have photos of the aftermath of the crash but was not able to attach them here.

Filed Jan 20, 2005 · Airbags, Brakes · 174,000 miles · MO · fire

Driving from work-snowy/icy conditions. Smelled a strange odor in vehicle going from I-270s to I-370w ~ 1/4 mile from ramp. Traffic moderate. Traveling 45 MPH I tapped brakes, they went all way to floor. Turned off electrical equipment. Used engine braking selecting 3-2-1 to slow vehicle. Vehicle slowed, applied emergency brake - drove to brake down lane. Vehicle stopped-white smoke coming around edges of hood. Lower portion of windshield had couple of heat discoloration marks about 1/4 size of a penny in the middle lower portion. Air bag light came on. Dash did not feel hot, nor the instrument panel - no smoke inside vehicle. Hood would not open by hood release. Power windows worked. Egressed vehicle and driver sdie air bag inflated. Called 911 awaited fire/polcie dept. Opened driver's and passenger doors. Flames coming from steering column where it enters fire wall. Flames underneath vehicle from engine near skid plate/transfer case. Used small fire extinguisher on flames in cabin and under vehicle to no avail. Front driver's side from center console to driver's side door melted away at about 45 deg angle from top to bottom of console. Inside engine the thydraulic drive unit and barke master cyclinder had melted. Significant burn damage from fire in engine. Vehicle-total loss. Very fortunate to recognize bad smell, id brake malfunction, use engine braking to control vehicle; use emergency braking to stop - moderate traffic. Minimized potential hazard to single vehicle-no injuries or fatalities.

Filed Feb 3, 2001 · Airbags, Electrical · UT

Original battery leaked acid, replacement battery leaked as well. Acid corroded airbag sensor and wiring, causing airbag system failure.

Filed Dec 28, 2000 · Airbags · KS · crash

While driving 55 MPH, had a frontal impact with a smaller vehicle on which driver's and passenger's airbags did not deploy, and did not protect occupants in this crash. No prior problems with airbag system. Dealer claimed that because vehicle was large impact did not trigger airbag sensor, and did not deploy airbags unpon impact. Please provide further information.

Filed May 26, 2000 · Airbags, Brakes · TX

The battery leaked/sprayed acid onto the engine and right front side components of the suburban. The air bag sensor had to be replaced, but the rest of the components were just cleaned off (this included brake hydraulic cables and lines, brakes, air conditioning hoses, radiator, etc.). The dealer/manufacturer said they don't cover the battery because it is not made by them althought I think the company is owned by them. We had to buy a new battery and pay for all the damage to the car and still don't know what the long term affects of this corrosive acid will be. It left a huge orange puddle in our garage floor which we can't get rid of. We took video and pictures of the damage to the car, battery and garage. The cracked front transaxle casing was only diagnosed after they had replaced the seal on the front axle twice since it was always leaking fluid. The rear differential had the seal replaced 2 or 3 times but it still leaks. The fuel pumped failed on our car leaving us stranded. We were told that the truck needs to keep a 1/4 tank of gas at all times in the tank so that this does not happen. The air conditioner has never really worked well on this model, it appears that it is undersized to handle the thermal load. We also had to have the spot welds on the door jams filed because many sharp burrs existed which were a safety hazard.

Filed Dec 2, 1999 · Airbags · NE

Airbag light comes on, indicating a problem with driver's airbag system. Dealer says it's due to faulty wiring. Please provide further information.

Filed Sep 14, 1999 · Airbags · TX · crash

While traveling at 55 MPH driver hit a deer, and there was no deployment of driver's side air bag. Vehicle is being held at the body shop. Owner not sure if the truck would be totalled. Please provide any further information.

Filed Oct 13, 1998 · Airbags, Brakes · MS

Abs brakes failed, vehicle lost control, resulting in a collision. No deployment of driver's air bag upon impact.

Filed Jun 24, 1998 · Airbags · OK · crash

Air bag did not deploy during impact.

Filed Jun 27, 1997 · Airbags · NY · crash

Driving at 20 -25 MPH the vehicle had a frontal collision at a rear end of other vehicle which caused the passenger's side airbag to deploy, but the driver's side airbag didnot deploy, causing injuries to the occupant.