2016 Chrysler 300 technical service bulletins
305 technical service bulletins and manufacturer communications cover the 2016 Chrysler 300, including one warranty extension.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Emissions Recall UB4 Rev 8
- The vehicle will exhibit a service transmission/check engine warning indicator for the following...
- Active Diagnostic Trouble Code (DTC) B1A10-00, B1A11-00, B1A12- 00, B1A13-00-, B1A14-00, B1A15-00,...
- Pad kit - rear disc brake, front disc brake
- Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges...
- Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges...
- Decreased Remote Start And RKE Range
- Air bag - side curtain
- Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges...
- Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC)...
- Lifter
- Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair...
- Suspected engine coolant leak.
- Warranty Bulletin D-16-03
- FCA Caribbean Warranty Bulletin ID-23-20 "Can / Am" Warranty Coverage
- Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review...
- Fuel Pump Connector Replacement The technician may experience a crank/no start after the fuel pump module...
- Water Quality When Mixed With Engine Coolant
- WiTECH Small Leak Verification Test (SLVT)
- Adapter
- Adapter
- Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges...
- Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges...
- Approved Use of Weld Through Primers
- No Start Condition After A Fuel Pump Replacement, Multiple Fuel System Level Related DTC?s Setting
- Panasonic 8.4" CTP/FCTP Radio, Update Failure
- Oil Filter If a Mopar Oil Filter is not available, use a filter that meets or exceeds USCAR36...
- If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is...
- Oil Filter If a Mopar Oil Filter is not available, use a filter that meets or exceeds USCAR36...
- Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire
- No Start, Cannot Complete Module Replace, Proxi Or Module Proxi Configuration
- Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement...
- Wiring
- Customer Complaint May Include Engine Oil Leak Or Consumption
- No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle,...
- Battery Tester Warranty Code Procedures, Midtronics Charger Update Process
- Gear Ratio DTC?s, Transmission Shift Concerns, Does Not Shift At Times, Shudders
- Battery Tester Warranty Code Procedures, Medtronic Update Process
- Steering System Inspection After a Collision
- Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles
- High Beam Headlamps Flicker
- Adapter
- Customer complaint may include engine oil leak/consumption.
- Rattle Noise From Rear Package Shelf
- Headlamp Condensation and Fogging
- (Rev. A) Battery Tester Warranty Code Procedures, Medtronic Update Process
- Aluminum Body Panel Corrosion Repair
- Flash: Powertrain Control Module (PCM) Updates
- No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle
- Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions...
- Blind Spot Or Park Assist Warnings, False Activation
- Disinfectant Solution Recommended for COVID-19
- Charging System, Battery Diagnostic Tools and Warranty
- Possible Driveability Issues due to the Winter-Blend Fuel into the Warmer Season
- Hands On Steering Wheel Message In EVIC
- Emissions Recall UB4 Evaporative Emissions Canister
- LED Front Fog Lamps Flicker Or Intermittently Light, Are Dim Or Inoperative
- Revised Emissions Recall UB4 Evaporative Emissions Canister
- High Beams Are Inop, Shutter Door On High Beams Open And Then Close In Cold Ambient Temperatures
- CORE, Heater (with tubes) When replacing the heater core for LA, LX, and LD vehicles, make sure to return...
- Key Programming, Security Pin Request, Pin Invalid
- Air Suspension Components Star Parts Catalog has been updated to show individual service parts for the...
- RA3 and RA4 GPS Calibration Update
- Revised Customer Satisfaction Notification VB3 ? Navigation Flash
- Repair Parts Used For Structural Repairs
- Authentic Mopar® Glass Replacement
- Use of Salvage/Recycled Parts
- Use of Aftermarket Parts
- RRT 19-090 (Service Bulletin 08-111-19) 2013-2018 Multiple Vehicles RA3/RA4 Radio GPS Certification Error
- RA3 and RA4 GPS Radio Update
- Radio, multi
- Flash: HVAC System Enhancement
- Flash Over The Air (FOTA) Software Update RA3 and RA4 Radio
- Radio [res]
- ACTUATOR, A/C and Heater Before replacing HVAC actuator, please contact either Thomas Conway (248)...
- Motor, Windshield Wiper For Jeep Grand Cherokee, Dodge Durango, Chrysler 300, Dodge Charger, and Dodge...
- Lower Control Arm If replacing Lower Control Arm due to worn bushings, please note that replacement...
- Servicing Lower Control Arm Inner Pivot Bushings
- Cam Phasers, Oil Control Valve For Malfunction Indicator Light (MIL) issues related to 2012-2017 3.6L...
- Trans Oil Pan, Heater Tube or O-ring, Heater Applies to vehicles equipped with 8 speed transmissions only;...
- Res / rha / reb
- Valve Cover and Gasket, Left and Right Pertains to vehicles equipped with a 3.6L V6 V.V.T. Engine only:...
- Flash: Hands Free Module Software Enhancements
- RA3 and RA4 Radio Over The Air Software Updates
- Housing, Fuel Fill Before ordering or replacing this part please contact Dennis Gauthier at cell (248)...
- Flash: Powertrain Diagnostic and System Improvements
- Flash: Transmission Diagnostic and Shift Enhancements
- Flash: Powertrain Diagnostic and System Enhancements
- Restraints Information Sheet (I-Sheet) has been added to Star Parts
- Rain light sensor Rain sense wipers do not operate: 1. Visual Inspection--> Check if the sensor is...
- Pentastar Oil Filter Adapter All vehicles equipped with a 3.2L or 3.6L engine; If replacing the Oil Filter...
- This bulletin provides information regarding the latest Flash Over The Air update (FOTA) and provides a...
- Pentastar Oil Filter Adapter All vehicles equipped with a 3.2L or 3.6L engine; If replacing the Oil Filter...
- Accelerator Pedal Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures...
- RA3 and RA4 Radio Enhancements
- Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the...
- Door Hinge Assembly Side door hinge noisy
- Electric Power Steering Gear If any of the following DTCs exist, it is okay to replace the steering gear:...
- Trans Pan or Gasket If your repair requires replacing one of the two part numbers for a leak, prior to the...
- RA3 And RA4 Radio Over The Air Software Updates
- Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for...
- Rear Axle Assembly If replacing Limited Spin Differential (LSD)/Anti-Spin Differential rear axles for any...
- Restraints Remove I-Sheet from packaging
- Variable Valve Timing (VVT) Solenoid, Variable Valve Timing (VVT) Phaser For a 2016/2017 MY 6.4L SRT with...
- Electronic Shift Module If DTC's U11C3, U0074 are present Stored or Active, please contact Pemi Sabageh at...
- Hands Free Module
- Res / rha / reb
- Vibration While Braking
- Electric Power Steering Gear Noisy
- RA3 And RA4 Radio Enhancements
- Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the...
- Powertrain diagnostic and system improvements.
- Return: Wiring Assy
- Inspect and Return: Trim Cover Assy
- Lamp Assy ?Tail Light LT You have been identified as either having stock, or have stock in transit to your...
- Flash: Transmission Shift And Drivability Enhancements
- CBXDP361AA
- Warranty Operations Newsletter Updates from Warranty Operations
- Electric Power Steering Gear For LA, LD and LX Models ONLY; Before this part is replaced for: A)...
- Return: Lamp Assy
- Inspect and Return: Solenoid Module
- 1NT30XDVAC
- P/n CBSZR068AA
- Seat back panel loose or, has poor fit at top edge, side and bottom.
- Flash: HVAC System Enhancement
- Flash: Transmission Shift And Drivability Enhancements
- MY16 RA3 & RA4
- Intake Manifold Gasket Intake Manifold Gaskets on Pentastar Upgrade (Sales Code ERC/ERF) are reusable...
- Inspect and replace propeller shaft this bulletin involves inspecting and replacing the propeller shaft...
- Inspect And Replace Propeller Shaft
- Flash: transmission shift and drivability enhancements
- Flash: diagnostic and system improvements
- Flash: 3.6L powertrain diagnostic and system enhancements.
- Flash: Diagnostic And System Improvements
- Flash: 3.6L Powertrain Diagnostic And System Enhancements
- Flash: Transmission Shift And Drivability Enhancements
- Anti-lock brake module (ABS) before replacing the ABS module, please call fadi korkis at cell (586) 722-4100
- Keyfob 2016 vehicle keyfobs with passive entry keyless go feature
- Anti-Lock Brake Module (ABS) Before replacing the ABS module, please call Fadi Korkis at cell (586) 722-4100
- Keyfob 2016 Vehicle Keyfobs with Passive Entry Keyless Go Feature
- Integrated Center Stack If vehicle is found within 50 mile radius of the Detroit Metro area please hold...
- 9-spd Transmission: FOR NAFTA Market Only: If you are ordering this transmission please follow all wiTECH...
- Tighten Generator Mounting Bolts
- Speakers: For 2016 speakers issues (all bodies), before replacing this part please contact one of the...
- Panasonic 8.4" CTP/FCTP Radio, Update Failure Issue 1: Hand Free Module inoperative, can't pair phone
- RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free...
- RES / RHA / REB radio that supports Bluetooth and Hands-Free
- 3.0L V6
- Subject: RA3 RA4
- RA3 RA4
- Subject
- Subject
- Body Control Module (BCM) Re-configure for Non-functional SD Card
- Subject
- Flash: Intrusion Transceiver Module Enhancements
- Intrusion Transceiver Module Enhancements
- Adaptive Cruise Control Sensor 1) If you are replacing this part due to the cluster displaying Clean Radar...
- Adaptive Cruise Control Sensor
- Radio Frequency Module RF_HUB
- 12 Volt Battery Return Process
- Bad cell" reading
- Rotor
- Rotor
- Rotor
- Side Rearview Mirror Cover
- Pump
- Parts.
- Transmission, Oil Pump, Torque Convertor, and Flexplate
- 2016 JK WRANGLER wind noise or water leak coming from a void in the windshield sealer
- Urea tank shell
- Actuator Motor, Front Axle Locker
- A/C Compressor
- Flash: Heated Steering Wheel Temperature Enhancement Depending on vehicle architecture:
- Flash: 6.4L Powertrain Diagnostic And System Improvements
- If vehicle DTC Code U114C-00 (Loss of Communication with PRNDL Display) is either stored or active, please...
- WIN Module
- Center Console USB Hubs
- Can/Am Warranty coverage
- Summary to be provided on a future date.
- Flash: Heated Steering Wheel Temperature Enhancement Depending on vehicle architecture:
- This bulletin involves updating the Comfort Seat and Wheel Module (CSWM) software for
- Load Floor Handle.
- This bulletin involves reprogramming the Instrument Panel Cluster (IPC) with the latest
- NAG1 (5A580)
- Accelerator Pedal
- W5A580 (NAG1)
- Part Description: Accelerator Pedal Issue Description: Vehicle has accelerator pedal fault code
- Fuel Tank
- Part Description: MY16 RA3 & RA4 Replacement Radios Issue Description: Issue 1:~ All MY16 RA3 and RA4...
- Radio Software Enhancements
- Flash: Heated Steering Wheel Temperature Enhancement Depending on vehicle architecture:
- This bulletin involves updating the Comfort Seat and Wheel Module (CSWM) software for the KL/UF
- Flash: Transmission Shift And Drivability Enhancements
- Flash: Transmission Shift And Drivability Enhancements
- Transmission Shift And Drivability Enhancements.
- RL4 RK4 RM4
- 82212076, 82203694
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Chrysler 300?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history