2005 Dodge Durango: fuel pump failure

Filed Oct 12, 2021 · Fuel system · UT

When filling up vehicle, fuel pump spits fuel back out when full instead of shutting off. Or pump will not fill at full speed and pump continually shuts off. Then it cannot tell when full, spitting fuel back out the filler

Filed Aug 19, 2021 · Fuel system · AZ

After filling gas tank to completion and hearing the auto stop on the fuel pump engage I saw about a liter of fuel spill out from the gas tank. Fuel was all over the vehicle and ground.

Filed Jun 14, 2019 · Fuel system · 200,000 miles · WI

When fueling with fuel at the end if not stooped regulatory to allow the fuel to empty into the tank the fuel will come out of the filling hole and keep going until you stop the fuel pump. Once you stop the fuel p[ump it will take about 3 sec to stop coming out but until then you will have about 1 quart to half a gallon of fuel all over the side of the durango, tire, and ground

Filed Mar 5, 2019 · Fuel system · 30,109 miles · CO

Fire hazard. Gasoline fume after turning off engine. Fuel line will lose pressure after sitting 24hrs and hard initial starting. Engine run fine. No leak detected on long drive. After several short trips, enough leaking gas will pool on top of gas tank and spill over passenger side and rear of gas tank. Gas leak from the plastic housing of oem fuel pump. Fuel pump was replaced at owners expense. Core charge on new fuel pump indicate that the old fuel pump is being rebuilt and small leaks will not be detected from the rebuilt unit.

Filed Apr 17, 2017 · Fuel system · 129,494 miles · NJ

Tl* the contact owns a 2005 dodge durango. While attempting to fuel the vehicle, the contact was unable to insert the entire fuel pump nozzle into the fuel filler neck. The fuel filler neck would only allow a certain amount of fuel to enter at a time. The vehicle was taken to the dealer where it was diagnosed that the fuel filler neck and fuel tank parts needed to be replaced. The vehicle was repaired, but the failure recurred. The manufacturer was made aware of the failure. The failure mileage was 129,494.

Filed Apr 22, 2016 · Fuel system · 99,000 miles · MT

Tl* the contact owns a 2005 dodge durango. The contact stated that when filling the tank with fuel, the fuel pump would not automatically stop as intended. As a result, fuel overflowed and leaked from the vehicle. The vehicle was taken to the dealer where it was diagnosed that the shut off valve was faulty and needed to be replaced. The manufacturer was notified of the failure. The failure mileage was 99,000.

Filed Jan 12, 2016 · Fuel system · 60,000 miles · NJ

Tl* the contact owns a 2005 dodge durango. While refueling the vehicle, fuel spewed out of the filler neck without warning. The vehicle was taken to an independent mechanic. The technician diagnosed that the fuel pump module seal fractured and needed to be replaced. The manufacturer was not made aware of the failure. The vehicle was not repaired. The failure mileage was 60,000.

Filed Sep 3, 2015 · Fuel system · 66,432 miles · MN

Large evap leak - code p0455: inlet & outlet fuel tank rings have rusted out. Previous recall e01 repaired in 2010 complete. After effects from previous fuel leakage has caused rust damage to the fuel tank connector rings. The safety of the vehicle is a huge concern as this can cause the vehicle to catch on fire at any time. Solution recommended: replace fuel tank & fuel pump.

Filed Mar 3, 2015 · Fuel system · GA

Fuel system - replce fuel pump still check engine light stays on denostic says fuel tank sensor ,I replace with new pump still say same thing .gas over flow when pumping full tank of gas .gas evaporate quickly.

Filed Jun 4, 2014 · Fuel system · 70,000 miles · AZ

Tl* the contact owns a 2005 dodge durango. The contact stated that the inside of the vehicle had a gasoline odor after the fuel pump assembly was replaced. The contact discovered pools of gasoline on top of the fuel pump assembly. The vehicle was not taken to a dealer or independent mechanic for diagnostic testing. No repairs were performed. The manufacturer was made aware of the failure. The failure mileage was 70,000. The current mileage was 71,000.

Filed Mar 11, 2014 · Fuel system, Visibility · 79,000 miles · WY

2 problems: 1) even though our local dealership is insistent that we don't have a recall, I can see a recall on your page about windshield wiper motors. Our wipers come on every time we start the vehicle, and they work sporadically. Sometimes while they're on, they won't come on at all, as mentioned in the recall information. Why isn't mine covered? 2) biggest problem: several times (upwards of ten times) I have been going slow, usually making a turn, and my engine stalls. I have to turn the key off and then restart, and I'm okay again. Took it to a mechanic in the last part of july/first part of august last year, and he replaced the fuel pump. It didn't occur again until december, while we were on vacation- we were slowly going up a hill and it stalled. Had to turn the key off and then re-start it. It hadn't done it again until a couple days ago. It did it three times in one day, then has been doing it each day since. I'm really afraid that the durango is going to die in the middle of traffic and I'll get hit. I have four young kids, and I am panicked thinking about having to drive it with them inside, because I'm afraid that we're going to get hit and hurt. It's so scary that I'm tempted to trade it in- though I can't really afford it, we just bought this thing used last year. I'm wondering if it did this for the previous owners as well. There are complaints all over the internet about this same problem, but no fix for it. Even if I could get a mechanic to tell me what it is and fix it, I'd do that, but nobody seems to know what the answer is. It's obviously a huge safety issue!! Please help!!

Filed Jul 16, 2013 · Fuel system · 140,000 miles · KS

Tl* the contact owns a 2005 dodge durango. The contact stated that after refueling, the instrument panel erroneously displayed that the fuel tank was full.the vehicle was towed to a private mechanic where it was diagnosed that the fuel pump module needed to be replaced. The manufacturer was made aware of the failure and stated that the vehicle was not included in the federal safety agency campaign number: 05v034000 (fuel system, gasoline). The vehicle was repaired but the failure recurred on three occasions. The approximate failure mileage was 140,000 and the current mileage was 202,000.