2019 Dodge Grand Caravan engine problems

Filed Sep 29, 2026 · Engine · CA

The vehicle has experienced repeated serious engine/cooling-system problems. It ran hot/overheated and would lose some power on even very slight inclines; when this occurred, the temperature gauge would rise. It never completely lost power or stalled. The vehicle developed an engine ticking noise that continues. An oil-pressure warning appeared, and the check-engine light repeatedly came on. In approximately March 2026, the engine failed and was replaced with a used engine reportedly having approximately 40,000 miles. Within approximately six months, the replacement engine developed additional oil-pressure/oil-system problems and continues to make a ticking noise. The vehicle has required substantial additional repairs. These problems create a safety concern because overheating, loss of power and possible engine failure could occur while driving and could leave the vehicle unable to safely maintain speed or operate normally in traffic. The problems have been diagnosed and repaired by independent automotive service facilities. The vehicle has not been inspected by the manufacturer, police or an insurance representative. The vehicle is available for inspection upon request. The symptoms began after we purchased the vehicle used on September 2, 2023, at approximately 68,000 miles. It now has approximately 109,000 miles. We have limited driving to very short trips because of these ongoing concerns. I HAVE RECIEPTS FOR the MOST RECENT 2026 REPAIRS , However the system here wont allow my picture/files

Filed Sep 5, 2026 · Acceleration, Engine · GA

I just started having this issue 3 days ago. When I put the car in reverse it does not directly go into drive. I have to go back to park to get the car back in drive. I put a brand new transmission in this car in 2024 and since I can only drive 45 miles per hour. When the drive or reverse does not light up in green, the camera in the back does not operate or show up at all.

Filed Feb 15, 2026 · Engine · NC

Engine loss of power, failure to accelerate, sudden forward lurch when stopped, Check engine light diagnosed by dealership and independent shop as Cylinder 2 failure. Purchased from Carvana 11/2024 with just over 70,000 miles on it. Currently has about 77,000. Cylinder head is currently being replaced at a cost of $6,500.00

Filed Feb 14, 2026 · Engine, Fuel system · CO

2nd cylinder head and exaust valvue part # r3602014aa intake manifold part #5184199af defective oil filter housing adaptor parts defective: 68228480aa

Filed Feb 5, 2026 · Engine · SC

I went into the Dodge place for my routine oil change on 2/3/26. While waiting, it was discovered by a technician that I had a very bad oil leak. This is very alarming to me. One reason is, there were no signs that I had an oil leak. A few examples: my oil sensor light did not come on, no oil spots recognized on concrete, or no smell of possible oil burning. The Dodge automotive technician determined the cause to be my engine oil cooler. Engine oil leaked all over everything under the housing (can provide a video). Another reason this alarms me is that this particular part is not covered under my warranty. This is expensive to have repaired. Lastly, the technician stated to us that there are over 30,000 or more vehicles from the Chrysler/Dodge Corporation with this same part that people are having to have replaced, and in some cases, replace multiple times. In conclusion, this cheaply made part should be a recall in all of these vehicles. The engine oil cooler should be made of metal material.

Filed Oct 11, 2025 · Electrical, Engine · NV

I have the oil changed regularly and keep all records and receipts. I've had the coolant and transmission fluid flushed, the thermostat changed twice, the coolant temperature sensor changed, the oil cooler changed and i checkmy transmission fluid regularly. My van was over heating frequently and no one could figure out why. I changed the coolant our and the temp. Sensor. It doesn't overheat now, but the heater quit working the day it was changed out. It hard shifts from 40 mph and up. Transmission fluid is good. I reset the power module by unhooking the battery for an hour. Still hard shifts . Scanner doesn't bring up any codes. 98,800 miles on it. Back sliding doors won't lock and tire sensor and radio dont work. What can I do? I cant afford a new transmission. The van was bought 2020 and for $19,000. I'm broke.

Filed Sep 3, 2025 · Engine · TX

Recently while leaving home my van started to make a type of noise. I cant quite describe it as it wasn't very whistling or clicking it was just an abnormal sound that it had not been making and I could hear it more when turning my wheel to the left. It started to jump while I drove. Like it was fine then would just jolt forward. When putting it in park I noticed that it wasn't making noise in the neutral position. But then when I was going to drive again it did not want to go forward. And at the first few tries I was able to reverse it. It did not want to accelerate and when I tried it would make a revving noise like if I was trying to race. I reversed and parked and my husband put some transmission fluid thinking that was the problem. The noise stopped and I was able to drive it briefly without the issues but then as I got further if started again and I had to get back home. It completely stopped accelerating and my husband and son had to push it. And once it got some speed j was able to accelerate just a little enough to drive it home. At home it stalled on me again and I was stuck in the middle of the street trying to reverse. Thats when my husband and son got back to push. It was a very scary situation as I had all my little children with me. And not only that it was so hot and we got stuck in the heat with the vehicle stalling. Now we had a mechanic look at if and they say it's the transmission. So I of course googled transmission problems to find there have been other issues with transmission in the 2019 models but mine wasn't part of the recall according to the Vin #. Please look into this further as these vehicles should not be on the roads stalling out at random. Which had also happened to me previously but I did not think transmission at the time. And that time was even more terrifying I was getting onto the highway from the access road and it stalled right there.

Filed Apr 8, 2025 · Engine · FL

Engine light on. Only have 70k miles on vehicle. Giving cylinder misfire code. Apparently others also have this issue. Took vehicle to dodge dealership who can’t figure it out. Replaced gasket, coil pack and Spark plugs. They were still stumped and wanted another tech to do a diagnostic at a large amount of money. At another mechanic now who’s trying to figure it out. I have two young children, this vehicle could stop in the road? THERE SHOULD BE A MANDATORY RECALL OF THE ENTIRE ENGINE. Do they want lawsuits for injuries or worse on their hands? I wish I never bought this vehicle.

Filed Mar 10, 2025 · Engine, Transmission · 100,000 miles · KS

The contact owns a 2019 Dodge Grand Caravan. The contact stated while driving at approximately 40 MPH, while the brake pedal was depressed the vehicle violently shuddered and stalled. No warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the torque converter and spark plugs needed to be replaced, and the vehicle needed a software update. The vehicle was repaired; however, the failure persisted. The manufacturer was not notified of the failure. The failure mileage was approximately 100,000.

Filed Dec 26, 2024 · Electrical, Engine · ND · fire

The vehicle was running on idle parked after being driven and on for less than 20 minutes. I started the van at 8:35. Drove away at 8:41, let it run on idle for 5 minutes, drove away, let it idle for 2 minutes at 9:04, drove away, let it idle at 9:06 and was smoking and had flames by 9:23 when we noticed it. The heat gauge didn't change, there was no indication that my engine was on fire or there was any issue. It drove fine, no smell, nothing. We have zero idea what happened other than it started in the engine compartment. Is it currently still sitting in the parking lot that it was pushed to away from the building as to not cause more damage to the building. It was sitting outside a building, so everyone inside and outside were in the area of smoke and flames. There is not a police report, but there is a fire report. I can email that over if needed. I'm still waiting for the fire marshalls final report. I also have active videos of it with flames shooting out of the engine and from under the hood if needed that I can email over.