2012 Dodge RAM 1500: fuel pump failure

Filed Feb 4, 2026 · Fuel system · 100,300 miles · OR

The contact owns a 2012 Ram 1500. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended and stalled. No warning lights were illuminated. The vehicle was turned off; however, while attempting to restart the vehicle, the vehicle failed to restart. After several attempts, the vehicle restarted and was driven to the residence. The contact stated that after parking and turning off the vehicle, the fuel pump was still running. The vehicle was taken to an independent mechanic where it was diagnosed with a fuel pump relay failure. The contact was informed that the TIPM needed to be replaced. The dealer was made aware of the failure. The contact stated that it was a known failure with the vehicle. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,300.

Filed May 13, 2025 · Airbags, Electrical · 160,000 miles · FL

The contact owns a 2012 Ram 1500. The contact stated that the check engine, air bag, and the fuel pump relay failure warning lights were illuminated. The contact stated that the exterior lights failed to operate as needed, and the vehicle occasionally failed to start. Additionally, the contact stated that the vehicle stalled while driving. The vehicle was taken to an independent mechanic who diagnosed the vehicle and determined that the TIPM was faulty and needed to be replaced. The local dealer was not contacted. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 160,000.

Filed Mar 23, 2025 · Electrical, Fuel system · MD

Fuel pump won’t shut off when car is turned off, I had to pull out fuel pump fuse because my battery kept getting drain, I’ve had difficulty starting and it’s only been a month since I bought this car,I’ve had to buy a bypass cable to temporarily fix the issue, this has happen to so many people, there should be a recall on the timp failing

Filed Jan 16, 2025 · Driver assistance, Electrical · AZ

Fuel pump randomly shuts down while driving. Or no start condition. Loss of cruise control hitting bumps in the road. Service 4x4, no tc, no cc, trailer lights disconnect. Dealer has recalls on other same year vehicles w same motor w same TIPM defective part. Not on truck. Warranty will not cover due to common problem. Since fuel relay is part of fuse box, will not cover part. Part alone is $2200. Dealer only. Can't get remanfactured, rebuilt, or part store item. Stuck with a truck that barely runs and almost $3000 to fix a non warranty issue. And very common.

Filed Oct 16, 2024 · Electrical, Fuel system · TX

TIPM failure. Vehicle fails to start ("crank, no start" or it acts likes it's out of gas) and/or fuel pump continues pumping after turning the vehicle off (draining battery).The vehicle stalls while driving which has created very unsafe conditions. There has been recalls on other dodge vehicles with same problem. This needs to be a uniform recall on all affected vehicles.

Filed Sep 6, 2024 · Transmission · 310,000 miles · FL

The contact owns a 2012 Ram 1500. The contact stated while driving at various speeds, the vehicle shut off with unknown warning lights illuminated. The vehicle was restarted immediately after the failure; however, the failure persisted, and the vehicle would no longer immediately restart after the failure. The contact attempted to restart the vehicle several times before the vehicle eventually restarted. The contact used a code reader to determine the cause of the failure but was unable to diagnose the failure. Upon investigation, the contact discovered that the failure was likely related to a defective fuel pump relay. Both the dealer and the manufacturer were notified of the failure, and informed the contact that there were no recalls on the vehicle. The vehicle was not repaired. The failure mileage was approximately 310,000.

Filed Jul 23, 2024 · Electrical, Fuel system · WA

Shut off vehicle and fuel pump kept running. Tapped on Totally Integrated Power Managment module and stuck relay corrected, so the fuel pump shut off. Found a safety recall (Safety Recall R09/the federal safety agency 15v-115) for stuck relay in TIPM on same year Dodge Durango and Jeep Grand Cherokee. A quick search of many automotive enthusiast forums indicates this issue is common in my particular year, make, and model vehicle as well. I believe this recall should be expanded to include all Dodge products using similar TIMP/Fuel Relay configurations. It is very likely this relay could have been stuck off, while driving causing an unexpected engine shutdown. In my case I was lucky it was stuck on.

Filed Jun 4, 2024 · Electrical · TX

Vehicle has presented multiple electrical problems which I understand is caused by the TIPM module which controls all electrical components in the vehicle. I have replaced the vehicle battery on 5 occasions over the past 5 or 6 years. One reason is the fuel pump fails to shut-off after the vehicle is turned off and continously cycles fuel until the battery is drained. Secondly, the ignition module is faulty and presents a safety risk to the vehicle occupants and the public's safety as the power to the vehicle cuts off while in operation at various level of speed to include highway speeds.The vehicle becomes disabled when it hits a road bump or while making a turn, making it hard to maneuver and may cause operator to lose control of the vehicle and crash with other vehicles, objects or people.

Filed Apr 5, 2024 · Engine, Fuel system · 124,000 miles · TN

The contact owns a 2012 Ram 1500. The contact stated that the engine was previously replaced due to camshaft failure. Additionally, the contact stated while checking the tire with the vehicle parked and turned off, the contact became aware that the fuel pump was still running. The contact stated that the car key was in the basement during the failure. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 124,000.

Filed Feb 18, 2024 · Electrical, Fuel system · FL

The Totally Integrated Power Module (TIPM) system installed in 2009-2012 Ram vehicles is prone to premature failure, resulting in the sudden cessation of the fuel pump while the vehicle is in operation. This critical malfunction poses significant safety hazards, including the potential for collisions with other vehicles, pedestrians, or stationary objects. Despite the persistence of this issue over several years, no official recall has been initiated to address it. Furthermore, in an attempt to mitigate the TIPM's failure and maintain continuous fuel pump operation, some individuals have resorted to unauthorized modifications, commonly referred to as "Jerry rigging," by bypassing the system with improvised wiring to maintain a constant "hot status." However, this makeshift solution introduces additional risks, including the heightened potential for serious fires due to the bypassed safety mechanisms. Given the severity of these safety concerns and the absence of a comprehensive recall, there is a pressing need for the manufacturer to take decisive action to rectify the TIPM system's deficiencies and ensure the safety of affected vehicles and their occupants.

Filed Dec 14, 2023 · Electrical, Fuel system · VA

The TIPM is failing in several areas... Starter, fuel pump and passenger compartment heater. This seems to be a common problem and Ram has never been held accountable... This plastic box and wires that should cost under a hundred dollars to replace is being sold on line between $500 and $1500 The manufacturer also has a built in design flaw where the electrical auto start function is disabled if the consumer has to replace the battery. They must pay a dealer to reprogram the truck to auto start... Seems like Dodge new they would be robbing the public on both of these items...

Filed Oct 17, 2023 · Fuel system · IL

Vehicle i cranks but doesn't always start. I did notice even after it started it seemed to run normally .But when I turn the key off I can still hear fuel pump running. It never shut off. I had to pull the relay fuse. After doing some research. I found that there was or is a safety recall on the fuel pump relay on other Chrysler vehicles having the same issue .Safety recall P54/the federal safety agency 14V‑530. The vehicles that were recalled uses the same tipm as my vehicle. Just wanting to know if you can tell me if my vehicle falls under the same recall if so how can I get it repaired. And if it doesn't fall under the same recall why not. It doesn't seem to be very safe for a fuel pump to be running constantly. I do not have the best of hearing. My wife was the one that noticed that it was still running.