2022 Ford Bronco Sport: won't start

Filed Oct 5, 2025 · IA

I own a 2022 Ford Bronco Sport (VIN: [XXX] ) that experienced a premature and unsafe transmission failure at about 75,000 miles. The issue began earlier with jerking and hesitation after stops and worsened until the vehicle displayed “Transmission Not in Park” and would not start. This created a dangerous situation at intersections and parking areas. Sioux City Ford diagnosed the issue and replaced the valve body under partial goodwill in July 2025, but the problem persisted. My service advisor said the new valve needed to “relearn” after 700 miles, but symptoms continued and the vehicle eventually became undriveable. I contacted Ford multiple times and was assigned case numbers, but received no resolution. The transmission was later confirmed failed by an independent certified shop, which replaced it at my expense ($7,711.96) along with towing ($246.10) and rental costs ($511.63). The defective parts remain available for inspection. This is a 2022 vehicle with less than 80,000 miles, and a complete transmission failure at this mileage is unreasonable and unsafe. Many other Bronco Sport owners have reported similar failures, jerking, and “Transmission Not in Park” errors linked to Ford’s 8F35 transmission. Ford has also issued Recall 24V-267000 and TSB 22B38 for related issues. This failure is not isolated and poses a significant safety concern for drivers. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 1, 2025 · Electrical, Engine · OH · fire

I went to start my car it did not start but repeatedly kept trying to start itself over and over the car locked up completely i couldn't push the brake or anything it wouldn't stop it disappeared from my app..the car cranked itself repeatedly until it caught fire and electrical smoke was rolling i had to call the fire department i was parked at a dayhab for special needs had to run and have them to remove all of the special needs people in wheelchairs and or with other adaptive equipment had to run into another office building and tell them to remove their vehicles i had a serious worry that this could have hurt or even killed people they at the ford dealer that has had my car 21 days said it's the starter no way the starter just went nuts for no reason we had to call the fire department and everything they replaced the battery which my understanding has recall 24s24 which says causes glitches either someone is blaming a starter for something other than that

Filed Apr 20, 2025 · Driver assistance, Electrical · ND

I was trying to park my vehicle and it started blinking and saying park is not available, vehicle is not in park. Place the park brake before exiting the vehicle. I was on a downward slope, so I found an area where it was flat and tried to restart my vehicle, but it was doing the same thing. I had to go to work, so I parked my car and placed the brake on. Later I went out on lunch and the car wouldn't start. I had to call a tow truck because Ford refused to come tow my 2022 Ford Bronco Sport or give me a loaner. The next day after Ford replaced my battery, they told me my car now had transmission issues that were not there before I had a dead battery. I know there is a recall on the 12v battery, but a remedy has not yet been issued and many customers are suffering. I asked about the recall or my warranty and I was basically laughed at because I have too many miles on my car. Why is a vehicle manufacturer able to continuly sell recalled vehicles and leave lives at stake for a recall that can end up killing someone?

Filed Feb 27, 2025 · Brakes, Electrical · MS

On or around 17 May 2024, spouse was driving child to daycare. Residential speed limit was 35 mph, when dashboard alerts "Power terrain, Hill Assist, Backup Camera, Front Camera, 911 Service, Please Service Now, Shift System Fault, Parking Brake INOP" illuminated and parking brake was applied by vehicle without owner input. Upon pulling into parking lot and turning off vehicle and restarting, vehicle cleared all faults and indications. Scheduled service immediately, service center implemented recalls 22S73, 24S24, and replaced faulty gateway module and reprogrammed software, additionally test drove vehicle 5 miles without duplication of discrepancy. Upon return of vehicle, on approximately 3 June, driver alerts and parking brake self-applied and would not start. Arranged tow truck to pick up vehicle, driver tried to drive vehicle onto platform, but after starting vehicle flashed warnings across dashboard and applied parking brake without input. Service center could not duplicate problem and offered no further troubleshooting or guarantees on work. Reached out to corporate to escalate issue but was unable to reach satisfactory resolution.

Filed Feb 10, 2025 · Electrical, Engine · TX

I was approaching a stop light which turned green and as i slowed down my vehicle's power stopped. The vechicle notice said shift to park. I had to turn the car off - in the middle of a busy road - and turn it back on. it took a couple of tries. This was incredibly dangerous as cars almost hit me as the light was green. Ford knows about this recall but just sent us a notice saying to keep drving it but "be careful" and they will get a fix in the next quarter. I must drive but i do not feel like it is safe. why are people allowed to drive these cars that they know are in danger of stalling. They should all be told to stop driving these cars and give them a replacement until they can get it fixed. I have had to have the battery replaced in this vehicle several months ago despite very low mileage because the car would not start and it seems to be related to this same 12v battery issue. I frequently get "critical battery" notices from the vehicle even when I'm not in it.

Filed Jan 26, 2025 · Electrical · FL

The electrical system seemed to be experiencing temporary failure at stop lights. It initially seemed to be associated with the auto start/stop feature. However, one day the system would turn on (dash, radio, and air) however the engine would not turn over. The 3rd main incident was after purchasing a new battery (one week after doing so, to be exact) and the car wouldn't even open with a key fob. Everything was dead and the system said it only had a 20% charge left after being jumped and driven. My safety was at risk as I have a long commute and had the first battery incident happen nearly 1.5 hours from my home. My safety was also at risk for each of the three times that my car stalled at red lights, not knowing why or how to retart my car during heavily trafficked times. When stating my issues to the dealership (I've been having the stalling at lights issue for 5 months) they brushed the facts aside. When telling them my battery was dead after it being a week old, they said it was probably installed wrong (even though battery was replaced at reputable establishment and not personally installed) The issues started around August or September. I had called the dealership (as I've had all work done at the dealership I purchased the vehicle from other than the replacement battery). The engine light was on the time I was stranded at work (when I was able to get the radio on, but not able to get the engine to turn over). Shortly before the complete power failure, I had a "charging system error" light flash on and disappear. All of these issues were brought to the attention of the dealership in a timely manner. I had assumed they were related to the last recall that was in July, but I was given generic and un-sympathetic or relevant answers and was told I'd just have to keep paying diagnostic fees each time there was an issue and for each separate issue, even thought they all seemed centered around electrical/power issues.

Filed Jan 15, 2025 · Electrical · NC

I had a recall for “computer module programming done by Ford on my 2022 Bronco sport 38k miles on [XXX]. The next day my car shut off while at a light not auto/start on off. But sputtered and lost power. The next day it would not start right away. On [XXX] I parked at my children’s school in a temporary spot. Went to back up and my car was stuck trying to turn in and off for a solid 10 minutes. There was also a burning smell of something. No smoke. I finally could turn it off quickly randomly and then it would not start again. We jumped it by tow truck and took it home because the dealership said at 3 years 38k miles it was not under warranty. So my husband took the battery out and had it tested. It tested 100% at Autozone an hour later. Whatever recall they preformed caused my car to drain the battery or lost power. No way a car with only 38k miles and maintenance done every time at Ford regularly should even have a problem like this. It’s so frustrating. I hope they fix this problem and find a solution for us customers. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Nov 25, 2024 · Fuel system · MA · fire

Recall 22S73 from Ford states that fuel injectors can crack and cause an under the hood fire. We have documentation showing that the dealer applied the recommended fix on June 26th 2023. On [XXX] I was driving and felt a fuel smell, a few seconds later I started seeing smoke coming from under the hood. By the time I got to the emergency lane there was already an open flame that brushed my hair as I got off the car. In less than 5 minutes my car was completely burn down along with my personal belongings. I have pictures and video of the car on fire in the highway. The police and the fire department responded to my 911 call and they were able to confirm that the fire did not start because of any traffic accident. We have access to the car and the fuel injectors for inspection if necessary. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 30, 2024 · Electrical, Engine · FL

June 28th, 2024; the entire car turned off on its own while I was waiting for a red light. The engine was primarily off from the auto-start feature, like normal, except after I let go of the brake the entire car just shuts off. The start button would not press, the brake pedal was insanely stiff to press, and the dashboard had all the lights turned on an off, and I couldn't change gears whatsoever. Many displays on the dash appeared, parking brake was forced to turn on, pre-collision feature disabled, "System off to save battery" on the main screen, etc. I was in the middle of traffic, so I was putting myself and others in danger while my car suddenly shuts off without prior warning. There was never an indication that this would happen, and I only had the car for a year and a half, so I would think the only problem would be the system itself. I managed to turn the car on by putting the key fob on the center console where the Bronco can read it, and it immediately turned on after an hour. The dealership did check it out right after and said it only needed a small system update. Ever since, the car was fine until July 24th: the car did not start again. I was home and my car was parked, so no danger this time. However, I tried laying the key on the console again, including my spare key, but no luck. I had originally thought it was the battery in my key that was low, but it was working fine like always. However, when I locked the car, the horn and lights were faded, and weren't as strong as it should sound. Although this is the second occurrence in about a month, I've only had the dealership inspect it once. I am available for inspection after August 1st. Thank you.

Filed May 5, 2024 · Electrical, Transmission · WY

When driving down the highway at 80 MPH, vehicle lost all infotainment and instrument panel. This happened several times, battery and alternator were tested and returned nothing. Upon completion of the drive, the vehicle would not start and the alternator had to be replaced. Approximately 3 months prior the drive train lost power and the turbo had to be replaced.

Filed Apr 5, 2024 · Electrical · MI

On [XXX] I drove my 2022 Bronco to the local car wash, after washing my vehicle the vehicle would not start. I realized it was the battery when no electronics turned on. This occurred in the midafternoon, and I was fortunate to be parked in an area that was busy. Had this occurred at night this would not be a safe area to be in alone and for a female. I contacted AAA for a jump and also Taylor Ford so that I could bring the vehicle into them to look at the battery. They put the vehicle on their machine and stated nothing was wrong with the battery. I was advised to lock the doors when I park the vehicle after use this may resolve the issue. On [XXX] the battery was once again dead. I put the battery on a charger and contacted Taylor Ford about the situation. I brought it back and they stated I would have to make an appointment. The delay is over a month for me to get into them to look at the problem. The vehicle sends a message in Ford Pass that it is going into sleep mode which indicates that the battery is starting to weaken. This issue with the battery puts me in a situation which may eventually cause me to be stranded and at risk for my safety if this occurs in an isolated area. I have done research and found a lot of Ford vehicles are having the same issues with the battery and no resolution outside of replacing the battery with the same reoccurrences over time. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 3, 2023 · Engine · TX

My Bronco has power failure in the middle of driving, entire car shuts off screen reads it goes in power saving mode and everything locks up and it will not start back up. My safety and my entire families safety is put at risk because I'm losing power to my car and it stops working if this happens on a busy highway it could be fatal. Yes, I've had it towed to the Ford house every single time this has happened. They attempt to fix it but give it back and within two days it happens again. I don't believe they know how to fix it. Ford House has had my car off and on for two months it should have been inspected by everyone at this point. No warnings when it happens it just stops working. This all started within the last two months. I purchased my 2022 Bronco brand new drove off the lot with 12 miles. At this point I don't feel safe putting myself or my family back in this vehichle. It needs to be recalled!