Tl* the contact owns a 1991 ford e-250. The contact stated that the reserve tank began spilling over into the main fuel tank and causing the fuel tank to overflow. The failure was causing the main tank to spill into the reserve as well. The contact referenced the federal safety agency campaign id number: 91v146000 (fuel system, gasoline: storage: auxillary tank: selector devices), but was told by the manufacturer that the vehicle was not included in the recall. The vehicle was not repaired. The failure mileage was 150,000 and the current mileage was 200,000.
The worst 1991 Ford E-250 problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Fuel system3
- Tires2
- Transmission2
- Brakes1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Fuel system3
- Tires2
- Transmission2
- Brakes1
Recalls 1
Fuel system, gasoline: storage: auxillary tank: selector devices
- What is wrong
- The dual fuel tank selector valve may malfunction and cause an overfill condition in one of the fuel tanks, resulting in an overflow of fuel past the filler cap.
- Risk
- The overflow of fuel past the filler cap causes a fuelleakage, which can result in a fire when exposed to a source of ignition.
- Remedy
- Replace the dual fuel tank selector valve.
Recall number 91V146000 · Recall details
See all 1 recalls for the 1991 Ford E-250
Defect investigations
Alternator belt failure
There is no summary currently available
EA93014
Loss of brake effectivenes
===
EA91044
Fuel expulsion
There is no summary currently available
EA91031
Loss of brake effectivenes
There is no summary currently available
PE91077
Transmission fluid fires
There is no summary currently available
PE91064
Technical service bulletins for the 1991 Ford E-250 5
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Some vehicles may exhibit excessive brake pedal travel, irregular front lining wear, and brake pull
- Front caliper piston boots damaged
- Delayed forward engagement and/or heat stained forward clutch plates after installing center support service
- Unknown
- There may be a concern of poor performance, coolant in the oil and engine knocking and/or hydraulic lock...
1991 Ford E-250 fuel economy
Official EPA estimates in miles per gallon (MPGe for electric). Ranges cover trims that share the same engine.
| Engine | Drive | City | Highway | Combined |
|---|---|---|---|---|
| 4.9L 6‑cyl | RWD | 12-13 | 14-16 | 13-14 |
| 5.0L 8‑cyl | RWD | 11 | 16 | 13 |
| 5.8L 8‑cyl | RWD | 10 | 14 | 11 |
What 1991 Ford E-250 owners say
Most recent owner complaints, unedited.
Husband was traveling on interstate, approx. 65mph. Sudden metallic noises and rumbling. Pulled over safely to find rear of transmission housing has lost several large chunks, leaving a gaping hole aproximately 10 inches by 4 inches. Towed to repair facility. Mechanic could not remove drive line from tail piece of transmission. He contacted a speciallist who informed him that certain ford transmissions of certain years, including '91, had a defect causing them to not get lubricant to the rear part of the transmission, causing overheating, massive damage and failure. This malfunction could have caused a fire, property damage, or worse a crash with injuries or death.
Consumer states having the same problem as recall#91v146000 fuel tank. Dealer will not repair because VIN was not included. Mr
The federal safety agency#6238-91-v-146-000 fuel tank: the dual tank selector valve may malfunction and cause an overfill condition in one of the fuel tanks consumer states has the same problem. Recall has been issued on similar makes and models, however this vehicle is not included due to the VIN. *ts
Tire been punctured and water had damaged steel causing them to rust. No rust found at the time of fread coming off.
Brake pedal went to floor no brakes whatsoever.
Pe000020; firestone, steel tex radial r4s replacement tire on a 1991, ford, f250. While driving 45 MPH on highway right rear tire tread separated from the tire. *ak the vibration was very intense.
Transmission leaks/shifts hard/jerks.
Compare the 1991 Ford E-250
Other model years
1990199119921993199419951996199719981999200020012002200320042005200620072008200920102011201220132014201620172022
Questions about the 1991 Ford E-250
Is the 1991 Ford E-250 reliable?
Owners have filed 8 complaints about the 1991 Ford E-250, close to a typical E-250 model year.
What is the most common problem with the 1991 Ford E-250?
Fuel and propulsion system, with 3 complaints. Next is tires (2).
How many recalls does the 1991 Ford E-250 have?
1 recall, covering fuel system, gasoline.
Was there a recall on the 1991 Ford E-250 fuel system?
Yes, 1 recall: 91V146000. Check your VIN to see if your car still needs the free repair.
What gas mileage does the 1991 Ford E-250 get?
Official estimates for the 1991 Ford E-250 range from 11 to 14 mpg combined. The most efficient version (4.9L 6-cyl, RWD) gets 12-13 city and 14-16 highway.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1991 Ford E-250?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history