Ford Edge spongy pedal problems

Filed Jul 8, 2026 · Brakes · 120,000 miles · ME

The contact owns a 2016 Ford Edge. The contact received notification for the federal safety agency Campaign Number: 25V544000 (Service Brakes, Hydraulic); however, the part to complete the recall repair was unavailable. The contact stated that while the brake pedal was depressed, the pedal felt spongy and extended to the floorboard, and brake fluid leaked onto the ground. The local dealer was contacted and confirmed that the part was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was taken to an independent mechanic, who diagnosed that the passenger-side rear brake line had failed and needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure. The failure mileage was 120,000.

Filed Jun 28, 2026 · Brakes · CA

Break Booster Break fell to the floor, slow to stop, spongy. I was able to put on my hazards and roll to safety stop. Huge risk if I was going faster or turning a curve. Dangerous to me and others to not being able to stop The problem hasn’t been taken to the shop yet as it was closed and I had the same problem in 2025 and 2023 which were confirmed and fixed with ford parts. I am suspecting it is the same issue. Even if replaced the car is likely not safe wi the this part failing 3 times in less than 4 years. No warnings or symptoms, just falls to the floor and spongy break reaction

Filed Jun 28, 2026 · Brakes · CA

Brake Booster All of a sudden my brake went to the floor and made a hissing sound, spongy response. Took it to Cowin Ford and they diagnosed and replaced the brake booster. It was really dangerous as response to brake was really slow. I almost hit a car in front of me. No warnings or symptoms prior.

Filed Jun 24, 2026 · Brakes · 110,000 miles · MN

The contact owns a 2011 Ford Edge. The contact stated that while reversing out of the garage and depressing the brake pedal, the vehicle failed to immediately stop. The brake pedal was spongy. The contact stated that later, while driving at an undisclosed speed and depressing the brake pedal to stop the vehicle, the braking distance was extended. The vehicle was slowly driven to the local mechanic, who diagnosed that the brake booster had failed and needed to be replaced. The vehicle was not yet repaired. The local dealer was contacted. The manufacturer was not contacted or notified of the failure. The failure mileage was 110,000.

Filed Jun 14, 2026 · Brakes · TX

I am submitting this letter to report a serious safety defect involving the brake system on my 2013 Ford Edge (VIN: [XXX]). The vehicle is experiencing a brake failure consistent with known ABS/HCU pump issues that have affected similar Ford Edge model years. On XXX, the vehicle was inspected at Randall Reed’s Planet Ford 635 in Garland, Texas. Service Advisor Luis Rodriguez confirmed the brake concern and provided a repair estimate of $3,500. The dealership indicated that the failure is related to the ABS/HCU system. The symptoms include: A spongy brake pedal Inconsistent brake pressure Reduced braking effectiveness Increased stopping distance Unpredictable brake response These symptoms match those described in Ford Recall 16C10, which addressed ABS/HCU pump failures on certain 2012–2014 Ford Edge vehicles. Although my VIN is not included in the recall, the failure pattern is identical and presents a clear safety hazard. I have contacted Ford Motor Company multiple times, including through executive escalation channels, but I have not received a response or assistance. Given the nature of this defect and its similarity to a previously acknowledged safety issue, I believe this may indicate a broader pattern that warrants investigation. I respectfully request that the federal safety agency review this matter to determine whether the existing recall should be expanded to include additional VINs or model ranges affected by the same ABS/HCU defect. Thank you for your attention to this safety concern. I am available to provide additional documentation, including the dealership diagnosis, repair estimate, and service notes. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 25, 2026 · Brakes, Transmission · CO

I am reporting a safety issue involving a 2013 Ford Edge Sport AWD related to progressive brake failure. The affected components include the brake booster and master cylinder. The vehicle remains available for inspection upon request. In mid-2025, the vehicle developed a gradual loss of braking capability. The brake pedal required increasing force over time to bring the vehicle to a stop. Because the failure developed progressively rather than suddenly, the severity of the issue was not immediately apparent. At the time, the vehicle was primarily driven by my teenage son, a new driver, who continued operating the vehicle by pressing the brake pedal harder to compensate. This created a significant safety risk, as the vehicle did not reliably stop under normal braking conditions, increasing the risk of collision. The issue was confirmed by an independent mechanic, and repairs required replacement of the brake booster, master cylinder, and related components. The vehicle was later discussed with a Ford dealership; however, no warning of coverage or recall applicability was identified at that time. There were no clear warning lights or dashboard messages indicating brake system failure prior to the issue. The primary symptom was a progressive increase in required pedal force. After the repair, I learned that brake booster failure is a known issue for this vehicle platform and has been the subject of prior manufacturer service campaigns. I am concerned that this type of gradual brake degradation may not be recognized by drivers, particularly inexperienced drivers, and could result in unsafe operating conditions. The vehicle has also experienced repeated rear differential failures. Replacement parts are no longer manufactured by Ford, requiring use of used components with unknown condition and lifespan, further affecting vehicle reliability and safe operation. I have attached a receipt for the second time purchasing and replacing the rear differential.

Filed Jan 2, 2026 · Brakes · PA

Soft brake pedal that goes to floor

Filed Dec 9, 2025 · Brakes · 117,490 miles · AZ

The contact owns a 2016 Ford Edge. The contact stated that while driving approximately 45 MPH, the contact depressed the brake pedal, and the brake pedal felt spongy and depressed to the floorboard. There was no warning light illuminated. The contact was able to stop and exit the vehicle. The contact then observed a puddle of fluid by the passenger’s side rear wheel well. The vehicle was towed to a local dealer, where the vehicle was diagnosed and determined that the passenger’s side rear flexible brake line had ruptured. The dealer replaced the brake line, and the vehicle was repaired. The manufacturer was not informed of the failure. The contact recently received notification of the federal safety agency Campaign Number: 25V544000 (Service Brakes, Hydraulic); and related the failure to the recall. The failure mileage was 117,490.

Filed Oct 10, 2025 · Brakes, Transmission · TX

The contact owns a 2016 Ford Edge. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed, and the contact noticed that the brake pedal was extremely spongy. The contact stated that several unknown warning lights were illuminated. The contact stated that because of the failure, the contact had to drive the vehicle below the speed limit. The contact stated that the brake fluid reservoir was continuously refilled; however, there was no evidence of a brake fluid leak. The contact stated that the brake fluid may be leaking into the engine. In addition, the contact stated that the dealer was made aware of the failure several times; however, the contact was informed that the parts were not yet available. The contact stated that for two years, the dealer informed the contact that the parts were not available. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact received notifications of the federal safety agency Campaign Number: 20V469000 (Service Brakes, Hydraulic) and 22V413000 (Power Train). The manufacturer was made aware of the failure but did not assist. The failure mileage was unknown.

Filed Aug 19, 2025 · Brakes, Driver assistance · OK

My vehicle started having a "spongy" pedal feel when I pushed on my brakes going to work and returning home. I was going to be taking my grandchildren to Branson, MO, on Thursday morning, [XXX], and was able to get Marvin Merritt, mechanic, to look at my vehicle before leaving to make sure we would be okay traveling. Marvin notified me that my brake booster needed replace and it was not safe to travel. I made other arrangements to go to Branson. When I got back I paid Marvin for services rendered and got my letter from the Ford Motor Company Dated March 2024. I took my letter, the invoice from Marvin Merritt and turned it into Friendly Ford Dealership / Service man, Derrick and he filed a claim for me and said he did not see any reason why they would deny my claim based on the information I turned in. I waited 4 week, calling weekly for updates, before being told my claim was being denied. Derrick gave me the following number to call 1‑800‑392‑3673 and they stated they would not honor the warrenty because it was not fixed at a Ford Dealership. I asked for an email or mailing address so I could send my information to them and was denied. She stated she would give me a claim number which was case # [XXX]. and I shared the following information on the phone. 1.“I received Ford’s March 2024 letter stating that if my vehicle had exceeded 150,000 miles, coverage would continue through November 30, 2025. My vehicle had exceeded that mileage, so I relied on this written coverage.” 2.“I had the brake booster repaired on July 11, 2025—well within the coverage period Ford outlined. Despite this, my claim was denied.” 3.“I am requesting Ford to honor its written commitment and reimburse the cost of my repair. Given that this matter involves a brake system safety issue, I trust Ford will resolve this promptly. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)