2010 Ford Escape suspension problems

Filed Jul 16, 2026 · Body, Suspension · MN

1. I purchased a 2010 Ford Escape that had a preexisting rusted frame defect. That is shown by the Ford vehicle history report and related service documentation, which support that the problem existed before I took possession of the vehicle. The vehicle was determined as unsafe to drive and later broke down after the sale. Apple Ford Apple Valley documented that the vehicle was “not safe to drive due to rusted frame,” and after break down, Carlson Automotive also inspected the vehicle and confirmed serious issues. The vehicle and related records can be made available for inspection upon request. 2.My safety and the safety of others were put at risk because the structural defect caused loss of control, steering problems, and ultimately a breakdown while driving. This created a danger to me, my passengers, and other drivers on the road. 3.The problem was confirmed by a dealer ( prior to the sale to me) and an independent service center ( after it broke down ). I am not aware of any police or insurance inspection of the vehicle. The seller is not cooperating. Ford bought the vehicle through a trade in and then held it for resale, top gear obtains the vehicle which then sells it on kbids to me. 4. There were warning signs before the failure THAT WERE NOT DISCLOSED AND FORD ALLOWED THE VEHICLE TO LEAVE ITS LOT INSTEAD OF JUNKING IT. The Ford history report and service records showed the rusted frame condition before the vehicle failed, and Apple Ford Apple Valley documented that the vehicle was not safe to drive. The car fax report did not show detailed service notes. I was not able to find out more detail until I was listed as the owner at FORD. The vehicle was video recorded on top gear you tube page as drivable and operational WITHOUT restrictions.

Filed Jun 4, 2026 · Steering, Suspension · MN

Front subframe on the right side prematurely rusts, causing the vehicle to loose steering and pull to the right.

Filed Mar 28, 2026 · Steering, Suspension · MI

The complaint is regarding a 2010 Ford Escape, original owner and maintained mostly at dealer shop. Vehicle only has 79k miles on it, and has been garage stored. It has rust in the rear wheel wells and a crack in the rear right subframe due to rust.

Filed Apr 7, 2025 · Steering, Suspension · WY · crash

Power steering quits working without notice and ford says it’s not a recall in this vehicle but it says everywhere that it’s a known recall issue

Filed Feb 25, 2025 · Body, Suspension · WV

putting the car on a lift noticed the rust on frame the inspecting further notice the rear axle rusted away from body

Filed Aug 6, 2024 · Body, Suspension · 122,000 miles · MI

The contact owns a 2010 Ford Escape. The contact stated while his daughter was driving at an undisclosed speed, the vehicle continuously pulled to the right, requiring the driver to make constant corrections. Upon visual inspection of the vehicle, the contact observed that the front passenger's side tire was angled inward and had nearly detached from the vehicle. No warning lights were illuminated. The vehicle was towed to an independent mechanic, who diagnosed a failure with the front engine cradle after observing excessive corrosion. The vehicle was repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 122,000.

Filed Apr 29, 2024 · Body, Suspension · MI

Engine cradle rusted out. It was replaced and I have the old part. Problem was detected using the vehicle for a short drive at residential speed. If the part had failed on the freeway an accident may have occurred. Vehicle was left at a close by shop who confirmed part failure and warned vehicle could not be driven unless part replaced. Shop confirmed this is not uncommon. Called Ford Motor Company and was told to see my local dealer. Checked with dealer body shop. Body shop said never seen problem before. Parts confirmed common replacement part. Service would neither confirm nor deny quality of original part leading to failure. Concern is for younger drivers for whom this is a family hand me down.

Filed Dec 6, 2023 · Suspension · NJ

I had exhaust work done, 2010 Ford Escape, and shop pointed out huge rust hole in ''subframe'' (engine cradle) This has been hundred thousand recalls but NOT all model years, yet they ALL have the same fault. Ford recall only puts a cheap ''brace'' on it but it is NOT a repair!! What kind of country allows these maggots to threaten the driver with complete !! loss of steering control and yet not require repair for faulty frames? They did the half-ass repair on 2001 to 2004 but ALL years up to 2012 have this, and the ''brace '' in cheapo B S.

Filed Oct 21, 2023 · Suspension · MA

On 8/17/2023 My daughter was on the highway and said she was having a problem after hitting a pothole. I told her to return home. Subframe Broke after hitting a second minor pothole on a side road close to my home. Passenger side tire (fell off?) was turned 90 degrees under the wheel well while the driver side tire was still pointing straight forward. About a 60 foot skid mark dragging the passenger tire at a 90 degree angle until she could pull the vehicle over. If this happened on the highway, I fear the worst would have happened to my daughter. Also, I see that the rear frame is rotted on both sides near the rear shocks.

Filed Aug 7, 2023 · Suspension · IL

A/C drain line located above the crossmember(Engine Cradle-#9L8Z-5C145-A) caused it to prematurely rot on the passenger side of the vehicle. Issue was discovered during a routine oil change. Crossmember rot is directly above lower control arm attachment point. In the event of total failure, it would result in loss of control of the vehicle. The driver's side of the crossmember does not have any signs of corrosion.