2015 Ford Escape wheels problems

Filed Nov 21, 2024 · Wheels · 26,470 miles · CA

The contact owns a 2015 Ford Escape. The contact stated that the vehicle was taken to the dealer for an oil change. The contact was informed by the dealer that the lug nuts were swollen, making it difficult to remove wheels from the vehicle. The contact was informed that the lug nuts needed to be replaced. The manufacturer was not made aware of the failure. The contact stated that the manufacturer had disconnected the call after multiple attempts to contact the manufacturer. The failure mileage was approximately 26,470.

Filed Jun 20, 2024 · Wheels · PA

After getting a flat tire I could not get the lug nuts off by hand. They are aluminum and strip easily. Needed to call a tow truck with an air gun to get lug nuts off. Even with the air gun they strip. My mechanic says I now need 10 new lug nuts. That is after buying 8 about 2 years ago.

Filed Aug 17, 2023 · Electrical, Seat belts · GA

After purchasing suv the back seatbelt buckle popped while holding carseat. Second incident while driving car shut off and radio made a popping noise electrical issues stored happening Radio went out electrical functions won’t stay positioned back camera is blinking on an off upside down

Filed Jul 11, 2023 · Wheels · OH

On July 06, 2023, I took my wife's Ford Escape to Dick Masheter Ford for an oil change and tire rotation. It is the dealership that we bought the car new. The car is a 2015 and has only 44000 miles on it. The technician came over to the service representative so I knew there was a problem. They informed me that the wheel lug nuts had swollen and the parts department didn't have any lug nuts in stock. I would have to go somewhere else to get them replaced. I did some research on the internet and found out that my problem is not new to Ford. I have bought Ford cars for my wife and me for the last twenty years and I feel Ford should offer help on my wife's car. If not replace the lug nuts then assist in changing them out when I rotate the tires again.

Filed Oct 24, 2022 · Wheels · FL

I got a nail in a tire the other day and couldnt get the ford lug nut off, I was told by a mechanic that the lug nut had expanded and due to further inspection I now have to replace all of the lug nuts, there really should be a recall put in to place it is a huge expense to take your vehicle to a shop

Filed Sep 15, 2022 · Wheels · NC

Took vehicle in for scheduled oil change, tire rotation and inspection. Upon cashing out was told they could not rotate tires because of bad lug nuts. Would have to order new ones at a cost of $227. This to me seems to be a Ford Company problem. If I would have had a flat tire, I would have been stranded as tire could not have been changed. This is unacceptable and Ford needs to fix this and I should be compensated.

Filed Jul 29, 2022 · Wheels · 61,510 miles · KY

The contact owns a 2015 Ford Escape. The contact stated that while attempting to remove the rear passenger’s side wheel, the contact’s son-in-law discovered that the lug nuts were swollen and the supplied lug nut wrench could not be properly fit over the lug nuts. The vehicle was later taken to the local dealer who replaced the lug nuts. No further information was available. The cause of the failure was not determined. The manufacturer was notified of the failure but no assistance was offered. The failure mileage was 61,510.

Filed Dec 9, 2021 · Wheels · FL

On 11/21/21 I went to Sam's Club to have new tires installed. They were unable to remove lug nuts on both back tires, they said the nuts were swollen. They could not proceed with tire installation. On 11/23/21 I went to Goodyear for new tire installation. They also found the lug nuts to be swollen. They were able to get them removed and complete the tire installation, with 5 lug nuts needing to be replaced at a cost of $39.95. They suggested I purchase a full set of lug nuts and get them all replaced soon. There was no warning message alerting me to this issue so I had no idea until I tried to have the car serviced. Both Sam's and Goodyear said they see this problem often on Ford vehicles. Doing some research on the internet, I see that many people have this issue with Ford.

Filed Oct 27, 2021 · Wheels · MA

Had my tires rotated and the mechanic had a very hard time getting the lug nuts off. He said this the worst design that are on Ford’s. If you get a flat tire on the side of the road trying to change your tire it would be very dangerous. He said why Ford hasn’t had a callback is ridiculous.

Filed Sep 26, 2021 · Wheels · IL

Took car in for maintenance (my Ford dealer) and was told needed new lug nuts. Was informed that it is “a known issue” with the lug nuts. I don’t see a recall but see quite a few issues reported. If their as dangerous as implied by the dealer then why not on recall. Was quoted over $300 to replace them.