2019 Ford Escape: check engine light

Filed Nov 5, 2026 · Engine · WA

Was told by an automotive repair shop that my car's check engine light codes are P0302/P0316. Current intrusion into the cylinder directly through the head gasket. The technician looked into this issue and found that 2019 Ford Escapes assembled in [XXX] in 2019 have these issues. I was not aware of this manufacturing error, and no recall/repair notices were issued. I'm putting XXX as my date of incident, even though the manufacturing error was done upon creation. I'm also selecting WA where the incident occurred, but my vehicle was assembled in [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 5, 2026 · Engine · NJ

I am reporting a potential safety defect involving the 1.5L EcoBoost engine in my 2019 Ford Escape, which has approximately 39,000 miles. Beginning in August 2026, the vehicle developed repeated check-engine lights, misfires, and severe shaking while driving. Ignition coils and a spark plug were replaced, but the problems continued. The vehicle then began displaying overheating warnings and repeatedly losing coolant. On one occasion, the coolant reservoir was found completely empty. Coolant was added, but the overheating continued. On September 3, 2026, the thermostat assembly and temperature sensor were replaced. On September 5, after about 15 minutes of driving, the vehicle began smoking and overheating. After it cooled, the coolant reservoir was again empty. Coolant was added, but the vehicle continued to overheat. I scheduled a Ford dealer diagnostic appointment for September 23 because I believed something was seriously wrong, but the vehicle was not diagnosed because the check-engine light was not illuminated at that time. The engine later suffered a major failure. An independent repair shop performed compression testing and reported extremely low readings of approximately 20-40 PSI on the cylinders tested, indicating severe internal engine damage. Ford has previously documented coolant intrusion on certain 2017-2019 Escape 1.5L EcoBoost engines, with symptoms including coolant loss, smoke, rough running/misfires, and possible engine damage. Ford confirmed that Customer Satisfaction Program 19B37 was completed on my vehicle in 2020, but says my VIN was not included in 21N12. Coolant intrusion has not yet been conclusively diagnosed, but the failure pattern is concerning and occurred at only about 39,000 miles. I am asking the federal safety agency to review this complaint for a possible safety-related defect trend.

Filed Oct 3, 2026 · Engine · LA

The check engine light has repeatedly came on and been brought to the mechanics numerous times throughout the year. It was determined that the cause of issue is due to engine coolant leaking into the engine.

Filed Sep 21, 2026 · Engine · 43,800 miles · PA

The contact owns a 2019 Ford Escape. The contact stated that at cold starts, the vehicle vibrated significantly with heavy white smoke coming from the exhaust. The check engine light was intermittently illuminated, accompanied by a noticeable coolant odor. A diagnostic test by the dealer confirmed that there was coolant leaking between cylinders #1 and #2, leading to total engine failure. The vehicle remained with the dealer unrepaired. The dealer submitted a goodwill request to the manufacturer for the repair. The failure mileage was approximately 43,800.

Filed Sep 14, 2026 · Engine · 85,818 miles · NC

The contact owns a 2019 Ford Escape. The contact stated that while driving 20 MPH, the vehicle was shaking and vibrating abnormally. The check engine warning light remained illuminated with the message "Engine Overheating - Pull Over Immediately" displayed. The vehicle was taken to a local dealer, where it was diagnosed with engine failure due to coolant intrusion. The manufacturer was notified of the failure. The failure mileage was 85,818.

Filed Aug 24, 2026 · Engine · 64,000 miles · MI

The contact owns a 2019 Ford Escape. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The contact connected a portable diagnostic tester to the vehicle and retrieved DTC: P0301 displayed. In addition, the check engine warning light flashed on and off. The vehicle was taken to an independent mechanic. The contact was advised to take the vehicle to the dealer. The vehicle was taken to the dealer where it was diagnosed with coolant intrusion and engine failure. The contact was informed that the engine needed to be replaced. The vehicle was repaired. The contact referenced Customer Satisfaction Program: 21N12; however, the VIN was not associated. The manufacturer was made aware of the failure, and a case was filed. The contact was advised to proceed with the repair and wait for approval of the VIN to be added to the Customer Satisfaction Program: 21N12. The failure mileage was approximately 64,000.

Filed Aug 20, 2026 · Engine · OH

Vehicle was losing coolant, running rough and check engine light was on. We took it to a Ford dealer who told us: Stored Codes P1299 and P0302 for the cylinder 2 misfire due to the coolant intrusion in the cylinder. The fix is to replace the entire engine at a cost of $15,735.95!! This is a 2019 Ford Escape. We've owned it for six years. We had planned on keeping it another six years, at least. A car should not need an engine replacement within six years. We're retired, living on social security and a very small pension. We can't afford a $15,000 repair. On top of a diagnostic fee of $435 and close to $500 to rent a car (so far.) We contacted Ford and they said there was nothing they could do for us.

Filed Aug 4, 2026 · Engine · 95,000 miles · MN

The contact owns a 2019 Ford Escape. The contact received notification of the federal safety agency Campaign Number: 26V011000 (Equipment); however, the part to do the recall repair was not yet available. The contact stated that the check engine warning light was illuminated while driving. Upon inspection, the contact's husband became aware that the coolant level was abnormally low. Additionally, a diagnostic scan retrieved Diagnostic Trouble Code: P0302; indicating a misfire in cylinder #2. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 95,000.

Filed Aug 4, 2026 · Engine · MI

Bad engine reports on 2019 Escape. Engine light problems beginning at 56k. I understand Ford has had many complaints about this engine. New water pump at 56k, new purge valve at 58k.

Filed Jul 26, 2026 · Engine, Transmission · IA

Was driving and a loud pop happened when pulling onto the hwy and lost power. Immediately pulled into parking lot and tried to restart but would not start. My son came over that evening and towed back to my house and the discovered the oil pan was cracked along with block and piston shattered. There are parts inside the oil pan. This has not been inspected by a dealer or service center. No warning or check engine lights came on indicating a problem. My build date is June of 2019 and the tsb is for May of 2019, indicating that this engine still had a coolant problem as there was no coolant left and had all came out in the pan with the oil. I am asking for assistance in getting this covered . Please let me know what steps can be taken. Thanks

Filed Jul 8, 2026 · Engine · TX

The engine block and cylinder head assembly failed due to a manufacturing design flaw that causes engine coolant to intrude into the cylinder bores. This defect was officially reproduced, tested, and confirmed by factory-certified technicians at AutoNation Ford Katy in Katy, Texas. The vehicle is currently parked at my residence and is fully available for inspection upon request. Prior to the failure, the vehicle exhibited a glowing Check Engine Light on the dashboard, low coolant levels, and rough engine idling upon startup, which first appeared immediately prior to the formal dealership diagnosis at 81,085 miles. Coolant intrusion into the combustion chambers causes sudden engine misfires, severe overheating, and white smoke emission. This defect risks a sudden, unpredictable loss of motive power while driving at highway speeds, creating a severe, immediate collision hazard for myself and other motorists on the road.

Filed Jul 1, 2026 · Engine · MI

Took my car into the dealership with a check engine light at 50k miles. The dealership told me that because it’s a poorly designed engine in the car I would need a full engine block replacement and quoted me $12k. The root cause of this problem is the known coolant intrusion issue referenced in Ford’s customer satisfaction program 21N12. I called ford customer service and the agent told me “bad luck, ford is offering no assistance to you.” To answer the questions specifically: The engine failed. It can’t be safe to drive a car anywhere that has an engine which can fail so suddenly. The problem has been confirmed by the dealer. The manufacturer has confirmed the problem. The only warning was a check engine light about 50 miles before the engine failed.