2019 Ford Expedition: shudder or vibration when accelerating

Filed Jul 30, 2026 · Transmission · 97,000 miles · WA

The contact owns a 2019 Ford Expedition. The contact received notification of the federal safety agency Campaign Number: 26V402000 (Power Train); however, the part to do the recall repair was not yet available. The contact stated that while driving approximately 60-70 MPH, the vehicle shuddered with the message "See Manual" displayed, and the vehicle jerked. The contact stated that the failure had occurred during hard acceleration. The vehicle was taken to the dealer, where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The contact was informed that parts were unavailable for the recall repair, and the contact was provided an estimate for the repair. The vehicle was not repaired due to the cost. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure and informed the contact that parts would be available in 2027. The failure mileage was approximately 97,000.

Filed Dec 8, 2025 · Transmission · MD

2019 Ford Expedition Max with the 10R80 transmission experienced severe shifting issues shortly after PCM recall 24E13 was performed. The recall involves PCM/TCM updates and adaptive shift strategy reset. After the recall, the vehicle developed shuddering, harsh shifting, flaring between gears, and delayed engagement. Dealer diagnosis found internal transmission damage including CDF hub sleeve axial movement and No. 3 sun gear shell seal failure, along with diagnostic code P07E6. These failures are known on the 10R80, but the issue escalated immediately after the recall update. Transmission required a full overhaul. Concern that the recall calibration and adaptive strategy reset may accelerate internal wear or exacerbate pre-existing vulnerabilities in the 10R80 transmission.

Filed Feb 19, 2025 · Transmission · 62,000 miles · NC

The contact owns a 2019 Ford Expedition. The contact stated that while the vehicle was cold and driving at undisclosed speeds, the vehicle started shuddering abnormally between gears, and the RPM increased, causing the vehicle to lose power. The contact stated that after the hesitation, the vehicle returned to normal operation. No warning lights were illuminated. The vehicle was taken to a local dealer to be diagnosed. The contact was informed that the transmission was faulty and needed to be replaced. However, an unknown module was reprogrammed, and the main control body valve was repaired. The manufacturer was notified of the failure and contact was provided TSB: 24-2101. The approximate failure mileage was 62,000.

Filed Nov 14, 2024 · Brakes, Transmission · 120,000 miles · VA

The contact owns a 2019 Ford Expedition. The contact stated that while driving at various speeds and hitting a bump, the rear end of the vehicle shuddered violently. The contact also stated that upon starting the vehicle, the vehicle made an abnormally loud sound momentarily. Additionally, the contact stated that while depressing the accelerator pedal from a complete stop, the vehicle failed to respond. The contact stated that upon releasing and slightly depressing the accelerator pedal, the vehicle responded. Recently, the contact stated while driving at highway speeds, the front end of the vehicle would shake upon depression of the brake pedal without warning. The contact stated that the failure had been recurring while driving at various speeds, which required the contact to slightly depress the accelerator pedal several times until the vehicle progressively accelerated to the desired speed. There was no warning light illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was notified of the failure and a case was opened. Additionally, the manufacturer informed the contact that the VIN was not included in a recall and referred the contact to the federal safety agency Hotline for assistance. The failure mileage was approximately 120,000.

Filed Jul 31, 2024 · Transmission · 73,200 miles · NV

The contact owns a 2019 Ford Expedition. The contact stated while driving 60 MPH, the contact noticed a failure with the transmission. The contact stated that the vehicle shuddered and hesitated upon the depression of the accelerator pedal with the transmission warning light illuminated. The vehicle was able to restart however, the failure recurred. The dealer was contacted; however, the vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 73,200.

Filed Jul 26, 2024 · Transmission · 88,000 miles · VA

The contact owns a 2019 Ford Expedition. The contact stated that while driving at various speeds, the vehicle shuddered and hesitated upon depression of the accelerator pedal. There was no warning light illuminated. The vehicle was initially taken to an independent mechanic; however, the mechanic could not duplicate the failure. The vehicle was then taken to another independent mechanic where a software update was performed; however, the update worsened the failure. The dealer was notified of the failure and the contact was informed that the transmission needed to be replaced. The vehicle was repaired by the independent mechanic. The manufacturer was notified of the failure and the contact was provided a case number. The failure mileage was approximately 88,000.

Filed Jun 24, 2024 · Transmission · NC

The transmission seems to slip, shudder and sometimes lag or jerk ahead unexpectedly. At times when waiting to cross traffic, the lagging makes it so I almost stall for a second or two and fear getting hit by oncoming traffic. Each time I have asked the dealership to determine the cause, I am told they have to do a software update and reset the adaptive drive to the factory reset. I have had this serviced three times and the problem continues to reoccur a couple months after the reset and software update. Then I get to take it back and pay for the same service all over again. The incorrect timing of the transmission may now have led to a faulty catalytic converter which is now having to be replaced at only 88k miles.

Filed May 20, 2024 · Engine · 90,000 miles · TX

The contact owns a 2019 Ford Expedition. The contact stated that while driving at undisclosed speeds, the vehicle started shuddering and jerking while shifting gear. The contact stated that there was a loud knocking sound coming from the engine compartment. The check engine warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed that the cam phaser needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and the contact was referred to the federal safety agency Hotline. The failure mileage was approximately 90,000.

Filed Mar 21, 2024 · Engine · 28,000 miles · MI

The contact owns a 2019 Ford Expedition. The contact stated while driving and depressing the accelerator pedal, the vehicle failed to exceed 60 MPH. There was no warning light illuminated. The vehicle was taken to the dealer, where an unknown software update was performed. Additionally, the contact stated that while driving at various speeds, the vehicle stalled. The contact also stated that the vehicle overheated while driving and while idle. The contact stated that the engine had overheated to 230-240 degrees, and the engine was shuddering while driving. There was no warning light illuminated. The vehicle was taken to the dealer, where the water pump, the TCM, the battery and unknown parts were replaced; however, the failure persisted. The vehicle was taken to a second dealer, Suburban Ford of Ferndale (21600 Woodward Ave, Ferndale, MI 48220), where it was diagnosed that the cam phasers had failed and needed to be replaced. The vehicle was not repaired. The contact related the failure to Ford Campaign Number: [XXX]. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered. The manufacturer referred the contact to the federal safety agency Hotline for assistance. The failure mileage was approximately 28,000. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 7, 2023 · Engine · 67,469 miles · TX

The contact owns a 2019 Ford Expedition. The contact stated that while starting the vehicle, the engine was shuddering. No warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed that the cam phaser needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the federal safety agency Hotline. The contact related the failure to Customer Satisfaction Program: 21N03 (Cam Phaser Replacement); however, the VIN was not included. The failure mileage was 67,469.

Filed Mar 14, 2023 · Engine, Fuel system · MI

My 2019 Ford Expedition is experiencing engine shudder. This started about 3 weeks ago and is starting to happen more and more.

Filed May 23, 2022 · Engine · MN

My family received a notice of Customer Satisfaction Program 21N08 – PCM Reprogram Due to Engine Shudder – 2017-2020 Ford F-150, 2018-2020 Expedition, & 2018-2020 Lincoln Navigator. We immediate began trying to locate an authorized repair facility. It took several months to get an appointment. During this time, our vehicle shuddered, stopped, and even turned off completely while driving. The problem continued to increase in intensity. When we were able to get the vehicle into a Ford dealership, they suggested that we contact Ford for the repairs that we needed. A private repair facility told us that now, because the shudder issue was not resolved right away, they discovered VCT phasers, VCT solenoids, timing chains and tensioners - failed setting code P0021 and causing engine to run rough. There was a loud rattle on startup which is related. P0018 stored in history. We have received a $4,000 repair estimate. I contacted Ford Customer service. They suggested I bring it into Ford Dealership. I explained that it had taken months to get in the first time. Customer service refused to provide me with additional authorized Ford repair (non dealers) in my location. Customer service refused to provide me with information on the error codes above. Customer service refused to provide me with more information concerning the PCMC reprogram and the known problems related to failing to obtain the reprograming. Customer service was not able to help me at all. I believe that the “PCM reprogram due to engine sudder” should be investigated as a potential formal recall program. Ford should repair of known issues a priority for their customers, and should also repair issues caused by failing to allow their customers to receive a timely remedy of this problem. I would also like more information on known issues with the PCM reprogram and engine shudder. I would like to view the quarterly reports.