The contact owns a 2020 Ford Expedition. The contact received notification of the federal safety agency Campaign Number: 26V402000 (Power Train); however, the part to do the recall repair was not yet available. The contact stated that the vehicle shuddered extremely while driving. The manufacturer was notified of the failure. The dealer confirmed the failure and stated that the transmission needed to be replaced. The vehicle was not repaired.
Ford Expedition shudder problems
59 of the 9,411 owner complaints about the Ford Expedition describe shudder or vibration when accelerating, most of them for the 2019 model year.
- owner complaints
- 59
- worst model year
- 2019
- typical repair cost reported
- $3,200
- typical mileage
- 77,000
Is there a fix? There are 7 recalls for this area of the car. See below
By model year
Often reported together
Harsh shifting 11Loss of power 10Transmission failure 6Check engine light 6Stalling 5Jerking 5Hesitation 5Slipping 2
Trouble codes mentioned
P07E6 1P0021 1P0018 1P0016 1P0012 1P0011 1C0047 1
What owners say
The contact owns a 2019 Ford Expedition. The contact received notification of the federal safety agency Campaign Number: 26V402000 (Power Train); however, the part to do the recall repair was not yet available. The contact stated that while driving approximately 60-70 MPH, the vehicle shuddered with the message "See Manual" displayed, and the vehicle jerked. The contact stated that the failure had occurred during hard acceleration. The vehicle was taken to the dealer, where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The contact was informed that parts were unavailable for the recall repair, and the contact was provided an estimate for the repair. The vehicle was not repaired due to the cost. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure and informed the contact that parts would be available in 2027. The failure mileage was approximately 97,000.
We recently purchased a certified pre-owned 2020 Ford Expedition Max Limited with approximately 70,000 miles. Since purchasing the vehicle, it has experienced several issues, particularly with the transmission. Before the transmission was replaced, the dealer attempted to repair it twice but was unable to resolve the problem. After the replacement transmission was installed, the same symptoms returned within one to two weeks, including harsh shifting, shuddering, and harsh engagement when shifting into reverse and park. In addition, the front seat belts and the captain’s chair seat belts have locked up multiple times. I also received a recall notice for the replacement transmission that was installed about a month ago, with an estimated repair timeframe of the second quarter of 2027. There is currently no repair available for the seat belt issue either. There have been no warning lights or messages displayed for any of these problems. I am concerned that these ongoing issues put both my safety and my child’s safety and the public at risk while operating or riding in this vehicle.
I am filing this complaint because my vehicle is exhibiting the exact failure mode detailed in Ford Recall 26S48 (the federal safety agency Campaign 26V402000), but my VIN is currently excluded from the recall population." A loud, heavy metal-on-metal "CLUNK" or "THUNK" right under the center console or floorboards the exact second I change gears. It feels like the transmission is violently dropping or snapping into gear. I even feel a physical jar or shudder through the shift dial and I brake pedal.
The contact owns a 2020 Ford Expedition. The contact stated that while driving at an undisclosed speed, the vehicle unexpectedly stalled on several occasions, and the instrument panel turned blank, forcing the contact to coast to the side of the road to restart the engine. Additionally, when shifting from Park to Drive, the vehicle shuddered violently and unintendedly shifted into Park. The contact associated these failures with the federal safety agency Campaign Number: 26V402000 (Power Train). The contact also stated that the cup holder was collapsing inward, and the text or coating on every control button in the vehicle was peeling off. The vehicle was taken to the dealer, but no diagnostic trouble code was found. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failures. The failure mileage was approximately 31,000.
The contact owns a 2026 Ford Expedition MAX. The contact stated that while driving at 70 MPH or higher speeds, the steering wheel shuddered due to a front suspension issue. The contact completed some research online and learned that it was a known failure associated with 2025 - 2026 model years. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was 800.
Most mornings when I shift the vehicle from Park to Drive the transmission slams into gear and it feels like the vehicle just hit a wall. Also when shifting from 4th through 8th gear the transmission shudders through the shift sequence and sometimes it completely cuts out, total loss of power and have to coast to a stop on the side of the highway. This happens all the time.
2019 Ford Expedition Max with the 10R80 transmission experienced severe shifting issues shortly after PCM recall 24E13 was performed. The recall involves PCM/TCM updates and adaptive shift strategy reset. After the recall, the vehicle developed shuddering, harsh shifting, flaring between gears, and delayed engagement. Dealer diagnosis found internal transmission damage including CDF hub sleeve axial movement and No. 3 sun gear shell seal failure, along with diagnostic code P07E6. These failures are known on the 10R80, but the issue escalated immediately after the recall update. Transmission required a full overhaul. Concern that the recall calibration and adaptive strategy reset may accelerate internal wear or exacerbate pre-existing vulnerabilities in the 10R80 transmission.
2020 Ford Expedition FX4. Towing a four wheeler and motorcycle on the expressway. The suv was in tow / haul mode and on cruise. The car downshifted to go up a incline and made a booming noise and then composed its self. Shortly after, I tried to pass a car, and the trans downshifted, made a couple of loud clunks, shuddered, lost all power. After a couple terrifying seconds it composed itself, found gear and maintained speed, acceleration was not possible as the trans would go out of gear. Further down the road, it did the same thing, clunk, clunk out of gear, no power. There were NO warning lights. I took it out of tow mode and tried both sport and standard settings, both had similar issues. This was the scariest situation I have ever been in with a car mechanical issue. Note: We were ~120 miles into the 160mile trip. The OAT temperature was ~45 degrees. Trans temp showed 250 degrees when acting up, and dropped to 220 by the time the trip ended. Odometer shows ~77k. CPO, dealer maintained.
The contact owns a 2017 Ford Expedition. The contact stated that while shifted in reverse, the back-over prevention screen was black or distorted. The message "Rear Camera Image Display Not Available" was displayed. The contact stated that while driving at an undisclosed speed, the vehicle was shuddering abnormally. The contact received notification of the federal safety agency Campaign Number: 25V572000 (Back Over Prevention); however, the part to do the recall repair was not yet available. In addition, the local dealer was previously contacted, and the vehicle was diagnosed with an Oxygen sensor failure. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 95,000.
Related recalls
Power train: automatic transmission
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2018-2021 Navigator, Expedition, 2020-2021 Explorer, Lincoln Aviator, and 2021 F-150 vehicles. The transmission park pawl may engage while the vehicle is in motion, resulting in park system damage.
- Risk
- Park system damage may result in a vehicle rollaway, increasing the risk of a crash.
- Remedy
- Dealers will update the powertrain control module software, and inspect and replace any damaged transmission components as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed July 10, 2026. Additional letters will be sent once the remedy is available, anticipated in April 2027. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 26S48. Vehicle Identification Numbers (VINs) involved in this recall became searchable on on June 26, 2026.
Recall number 26V402000 · Recall details
Power train: axle assembly
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2023 F-150, Expedition, and Lincoln Navigator vehicles. The front axle pinion may not have been heat-treated, which can cause it to fracture.
- Risk
- A fractured pinion can result in a loss of 4-wheel drive and may cause the front wheels to lock up, increasng the risk of a crash.
- Remedy
- Dealers will replace the front axle pinion gear set. If there is a broken front axle pinion, the entire axle assembly will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed April 21, 2023. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 23S07.
Recall number 23V128000 · Recall details
Power train: automatic transmission: gear position indication (PRNDL)
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2020 Ranger and F-150 vehicles equipped with 10-speed automatic transmissions and certain 2020 Expedition vehicles equipped with a "police" package. The transmission shift cable lock clip may not be fully seated, allowing the transmission to actually be in a different gear than the gear shift position selected by the driver.
- Risk
- If the transmission selection does not match the indicated gear selection, and the parking brake is not applied, unintended vehicle movement can occur, increasing the risk of injury or crash.
- Remedy
- Ford will notify owners, and dealers will inspect and correct the shift cable locking clip installation, as necessary, free of charge. The recall began April 27, 2020. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 20S18.
Recall number 20V197000 · Recall details
Power train: automatic transmission: gear position indication (PRNDL)
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2018 F-650 and F-750 vehicles equipped with 6-speed automatic transmissions and 2018 Ford F-150 and Expedition vehicles equipped with 10-speed automatic transmissions (excluding Expedition vehicles with a Rotary Gear Shift Dial on the console). The gear shift cable clip may not be properly seated, allowing the transmission to be in a different gear than indicated by the gear shift lever position.
- Risk
- If the gear shift cable clip becomes unseated or dislodged, the gear shift lever position may indicate that the transmission is in 'Park' when it may be in a different gear. Additionally, despite selecting 'Park', if the parking brake is not applied before the vehicle is exited, the vehicle may roll. Either scenario increases the risk of a crash.
- Remedy
- Ford will notify owners, and dealers will inspect the shift cable locking clip and properly seat it, if necessary, free of charge. The recall began on April 13, 2018. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for the recall is 18S10.
Recall number 18V214000 · Recall details
Power train: automatic transmission
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2017-2018 Ford F-150 and 2018 Ford Expedition and Mustang and Lincoln Navigator vehicles equipped with 10-speed automatic transmissions. A roll pin may not have been installed in the transmission, potentially causing a loss of the "Park" function.
- Risk
- Despite the transmission shift lever being placed in 'Park' and the instrument panel display indicating 'Park,' the vehicle may roll away after it has been exited if the parking brake has not been applied, increasing the risk of injury or a crash.
- Remedy
- Ford will notify owners, and dealers will inspect the transmission to make sure it has the roll pin, installing one if it is missing, free of charge. The recall began on April 13, 2018. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 18S09.
Recall number 18V213000 · Recall details
Power train: automatic transmission
- What is wrong
- Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford F-150 trucks, 2012 Ford Expedition, Lincoln Navigator, and Ford Mustang vehicles. The affected vehicles are equipped with an automatic transmission that may unexpectedly downshift to first gear, regardless of vehicle speed.
- Risk
- An unexpected downshift into first gear can cause the vehicle to slow down suddenly without warning and the rear tires may slide or lock, increasing the risk of a crash.
- Remedy
- Ford will notify owners, and dealers will reprogram the powertrain control module with updated software, free of charge. The recall began on September 19, 2016. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 16S19.
Recall number 16V248000 · Recall details
Power train: automatic transmission: gear position indication (PRNDL)
- What is wrong
- Vehicle description: light duty pickup trucks and multi-purpose passenger vehicles. If the automatic transmission shift cable assembly was not fully attached to the steering column bracket, the shift cable assembly can come out of the bracket. The vehicle operator would then not be able to shift the transmission from one of the drive gear positions into the park position even though the gear shift selector would indicate "park."
- Risk
- The condition would not allow a disengagement of the transmission from the park position or affect proper neutral start switch operation. Unintended vehicle movement could occur if the parking brake was not set.
- Remedy
- Dealers will make the proper attachment of the transmission shift control cable to the steering column bracket and add a tie strap to that connection.
Recall number 97V171000 · Recall details
Questions about the Ford Expedition shudder
Which Ford Expedition years have shudder or vibration when accelerating problems?
The model years with the most reports are 2019 (13 complaints), 2020 (12 complaints) and 2018 (7 complaints).
How much does it cost to fix shudder or vibration when accelerating on the Ford Expedition?
Owners who mentioned a price put the repair at about $3,200 (median of 6 complaints that include a dollar amount). Costs vary with mileage, warranty and where the work is done.
VIN decoder
See the problems and recalls for an exact car
Buying a used Ford Expedition?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history