The contact owns a 2015 Ford Explorer. The contact stated that the driver's side and passenger’s side front door panels were cracked. There were no warning lights illuminated. The local dealer was contacted, and stated there was no recall or warranty coverage for the failure. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The approximate failure mileage was 25,000.
2015 Ford Explorer body complaints
Page 11 of 15: complaints 281 to 310 of 412, newest first, as owners wrote them.
The exterior right-side A-pillar panel departed the vehicle unexpectedly while driving at highway speeds (~70 mph). No early warning signs or indications were present. The incident occurred on the highway at night. When the panel departed, it made a loud noise like something hit the windshield. The driver and passengers were unaware that the panel was no longer attached to the vehicle until exiting the highway and inspecting the vehicle. The panel was not found on the highway after the incident and very well could have hit another vehicle, person, or animal and caused an accident. The vehicle has not been inspected by the manufacturer, police, or insurance representatives. The Ford Motor Company has an active recall for this issue and has indicated that they will not replace the panel until a remedy is identified later this year (2024). With the panel missing, there are broken pieces of plastic still loosely attached to the A-pillar and make a vibrating noise when driving at highway speeds.
The contact owns a 2015 Ford Explorer. The contact received notification the federal safety agency Campaign Number: 24V031000 (Structure), however, the remedy was not yet available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repairs. The contact stated while driving 50 MPH the right pillar trim detached from the vehicle. No warning lights illuminated. The vehicle was taken to the dealer and it was confirmed the vehicle was included in the recall and the vehicle could be repaired under an advanced recall if the contact paid for the repairs. The manufacturer was notified of the issue and informed the contact he had to wait to receive a recall letter in mid 2024 and it was possible to receive a refund for the repairs. VIN tool confirms remedy not yet available.
The contact owns a 2015 Ford Explorer. The contact received notification of the federal safety agency Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that following a recent heavy rainfall, water entered the vehicle on the passenger’s side. The contact called the manufacturer and was informed that the remedy was not yet available. The failure mileage was approximately 124,000. VIN tool confirms parts not available.
The contact owns a 2015 Ford Explorer. The contact stated that while vehicle was parked, the contact became aware that the retention clips were not flush with the rest of the vehicle. The vehicle was taken to the dealer where the vehicle was diagnosed and determined that the A-pillar and retention clips were not properly engaged. The vehicle was repaired; however, the failure recurred. The vehicle was taken back to the dealer and the A-pillar and retention clips were replaced again. The contact referenced the federal safety agency Campaign Number: 24V031000 (Structure) as a possible solution; however, the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was approximately 72,000.
Outer Windshield Panel on Drivers Side completely detached and blew off into oncoming and following traffic without warning. It did not make contact with any vehicle or pedestrian, however the risk was still there.
Passenger side front window trim (column). The rubber seal started flapping on the expressway (60-70mph), followed by the entire trim piece ripping off. Created a significant distraction for driver and passenger. Trim piece flew off vehicle onto a 6 lane highway creating a safety issues for other drivers. There was no previous history of damage/accident involving this trim piece.
I was driving on the highway on my way to work and the windshield trim panel on the passenger side flew off of my vehicle. This is definitely a safety hazard as this flying part could have hit another vehicle and/or caused an accident.
The contact owns a 2015 Ford Explorer. The contact stated while driving 70 MPH, the front windshield molding became fractured and started striking the front passenger’s side door glass. The contact was able to safely drive the vehicle to the shoulder of the road. The vehicle was taken to the dealer. The contact was informed that there was no recall. The dealer advised the contact to report the failure to the manufacturer. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to report the failure to the federal safety agency Hotline. The failure mileage was approximately 110,000.
While driving on the freeway, the windshield trim panel on the passenger side detached, lifted, and folded about 2/3 of the way up the panel. The detached portion then banged against the roof of the vehicle, door, and front passenger window until it snapped and flew off. It put us and other motorists in danger.
-Driver side front door/window trim flew right off while on freeway and almost hit another car. This is actually the 2nd time the trim came off after being repaired not even 5 months ago (I didn't file a complaint the first time). -It could hit another car or motorcycle while going high speeds and possibly cause a crash. -I haven't checked with my dealer but have read articles online how there already are complaints regarding this. -I took it to a local private car repair facility, and they claimed to have seen it happen quite frequently. -You can slowly see the trim start to delaminate over time. My passenger side trim is half-way off and probably a matter of time before the same happens to it.
The window trim came off while I was going 60mph. It was very loud and scary. I had no warning. I didn’t realise what it was until I stopped. I’m very lucky that it didn’t hit the car behind me at that speed. I see this part missing from a lot of Ford Explorers so it must be common. There needs to be a recall before someone gets hurt.
The contact owns a 2015 Ford Explorer. The contact stated while driving approximately 53 MPH, there was an abnormal booming sound detected. The contact noticed that the windshield panels had detached from the driver’s and passenger’s side. There were no warning lights illuminated. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted, and a complaint was filed, and the contact was referred to the federal safety agency Hotline for assistance. The failure mileage was approximately 61,711.
The contact owns a 2015 Ford Explorer. The contact stated that the front driver's side door and window trim panels were detaching and deteriorating. The vehicle was taken to the dealer, where it was determined that the failure was related to Customer Satisfaction Program: 17N01 (Crankshaft Position System Variation Not Learned), however, the campaign had expired. The vehicle was not repaired. The manufacturer was notified of the failure but declined to assist because the campaign had expired. The failure mileage was approximately 91,000.
The contact owns a 2015 Ford Explorer. The contact stated that after visually inspecting the rear hatch, he observed corrosion damage at the base of the hatch from outside of the vehicle. The vehicle was taken to the dealer, who confirmed the corrosion with no specific diagnosis but advised that the hatch needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but referred the contact to the federal safety agency Hotline for assistance. The failure mileage was 36,000.
Driver's side windshield A pillar molding.. Flew off on the interstate.
Driving down the highway and the passenger side windshield trim broke and detached from car, scraping down the side of my car and hitting the car behind us.
The contact owns a 2015 Ford Explorer. The contact stated that while driving at an undisclosed speed, the trim on the windshield detached. The vehicle was taken to an independent mechanic, who replaced the door gasket. The manufacturer was made aware of the failure and referred the contact to file a complaint with the federal safety agency Hotline. The failure mileage was approximately 120,000.
The contact owns a 2015 Ford Explorer. The contact stated that when he closed the front driver's side door, the outside door handle fractured and detached. The contact stated that the vehicle was taken to the dealer and the contact was informed that the fractured door handle needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 73,000.
Driver side Windshield trim flew off on interstate
I currently have a 2015 Ford Explorer. This is the 2nd time that I am having to replace the windshield trim on the passenger side due to it flying off while driving.
The contact owns a 2015 Ford Explorer. The contact stated while driving approximately 70 MPH, the contact heard an abnormal banging sound against the passenger’s side window. The contact thought that road debris had been kicked up and struck the vehicle. The contact stated that she heard an abnormal wind rushing noise coming from the top of the passenger’s side door. The contact stopped the vehicle and realized that a part of the door trim panel had detached from the vehicle and struck the vehicle. The contact had not taken the vehicle to a local dealer and the vehicle had not been diagnosed or repaired. The manufacturer had been informed of the failure. The contact researched online and related the failure to the federal safety agency Action Number: PE23001 (Structure). The failure mileage was approximately 55,000.
The passenger side window trim flew off on the expressway. Barely missing the vehicle behind. The drivers side trim looks as if it's becoming detached also.
The windshield trim piece on the passenger side flew off while driving and could have hit another vehicle /property or a person causing damage or injury. Online research indicates there is a known issue with these parts. However, I was unable to locate a recall.
The A-Pillar Windscreen TRIM on each side of the vehicle are a failed Ford design and require pending replacement to prevent them flying off whilst traveling and endangering other road users or pedestrians.
While driving around 45 mph I was startled by something black flapping against the passenger side of the windshield. I thought I must have hit a large bird and it was caught somehow. I immediately pulled off the road to see what happened. I found a large strip of rubber sealer had come loose from around my windshield and was causing the flapping, also the windshield trim was gone. I drove back the way I came and found the missing part in the road. Yes I feel this is a hazard to traffic. I was very startled with the commotion and if there was a car behind me they could have been startled by flying pieces of my car. I haven't had the repairs done yet.
A-Pillar molding suddenly detached and flew off while driving down interstate. The driver's side flew off in October of 2020. Caused me to swerve as I thought I hit something. Thankfully, no one was beside me. I didn't realize what it was until I was able to pull over at rest stop. Passenger side flew off while on highway in April of 2023. This time, the seal/gasket remained attached and was slapping the side of the vehicle until I could get somewhere to top and yank it off. The pillar molding caused several vehicles behind me to swerve, but no accidents were caused. Both times this happened, several of the plastic clips appear to have been broken. Both times this happened, there was no warning. No sounds or minor lifting to indicate that something might be loose. After the driver's side one happened, I took the vehicle in to the dealership and was told by Barton Ford that "this is a common problem with this style of Explorer." I could not afford the amount that I was quoted to replace. Also, after the first incident, I started noticing how many other Explorers are driving around with the same issue. This is ridiculous that Ford is allowing this issue to remain unresolved. I live in the country, where highway speeds are common on back roads and the sound alone that this makes is terrifying. I thought that I blew a tire and there was rubber on my windshield the first time. The second time, I had people slowing down and trying to get away from me probably in fear that more parts were going to suddenly start falling off. Also caused cosmetic damage to my passenger side door and windows due to the "flapping" of the rubber.
The contact owns a 2015 Ford Explorer. The contact stated while driving approximately 70 MPH, she heard an abnormal thumping sound coming from the passenger’s side front of the vehicle. The contact stated no warning light was illuminated. The contact stated that when she arrived at her destination, she observed that a part of the windshield trim was missing. The contact drove the vehicle to a dealer; however, the missing trim panel was not replaced. The contact ordered the part and installed the trim. The vehicle was repaired; however, the contact stated that later the driver's side trim panel also detached from the vehicle and was replaced. The manufacturer had not been informed of the failure. The contact researched online and related the failure to the federal safety agency Action Number: PE23001 (Structure). The failure mileage was approximately 90,000.
The contact owns a 2015 Ford Explorer. The contact stated while driving 65 MPH, the driver’s side A pillar windshield trim panel detached and flew off the vehicle. The contact was able to continue driving. The dealer was not notified of the failure. The vehicle was not diagnosed nor repaired. The contact related the failure to the federal safety agency Action Number: PE23001 (Structure). The manufacturer was not notified of the failure. The failure mileage was approximately 133,000.
Was driving on the freeway going about 60mph when passenger side windshield moulding flew off the vehicle and hit my windshield & mirror. I have no idea where the part landed. My concern is - the part should not just fly off even on an older vehicle. I have no idea if the part hit anyone else’s vehicle. I had no warning that this part could just fly off.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2015 Ford Explorer?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history