2017 Ford Explorer seat belts problems

Filed Sep 9, 2026 · Seat belts · MN

There is a driver's safety-restraint malfunction with a failure mode such that the tongue (male end of seat-belt) will not insert normally into the buckle (female end) unless the red release button is depressed. The driver buckle failure results in a failure in the vehicle's personal safety system. The component has not been inspected or confirmed by a dealer, as Ford Motor Company has indicated this will be an out-of-pocket cost replacement due to the extended warranty on this buckle no longer being applicable - Ford issued voluntary special field action 23L06 related to the driver's side buckle that expired March 31 2025.

Filed Sep 3, 2026 · Airbags, Seat belts · CO · crash · 1 injury

Head on collision occurred XXX. A man was traveling east on XXX and ran the light at the intersection of [XXX]. I was heading south on [XXX] and hit his white truck. My air bags did not deploy. Also, within the last year a seatbelt was not latching properly and I had to get it replaced. In addition to repairing the roof rack cover which flew off as I was driving one day. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 23, 2026 · Seat belts · TX

My back seatbelts are not working and my family feels unsafe without being able to put the seatbelts on.

Filed May 27, 2026 · Engine, Seat belts · CA

I’ve had three transmissions replaced from 2023 to 2026. Ford no longer makes 2017 Ford Explorer transmissions so I keep getting bad parts. In 2026 engine light came on , coolant leaking into cylinders, $11K to fix. This car has left me stranded on the side of the road , not to mention months at the dealership trying to find transmission parts. Ford Corporation refuses to buy back vehicle based on lemon law. Rear seatbelts defective.

Filed Dec 4, 2025 · Seat belts · MN

Rear passenger side seat belt strap is twisted and stuck in fully extended position.

Filed Jun 25, 2025 · Seat belts · 85,000 miles · IL

The contact owns a 2017 Ford Explorer. The contact stated that while attempting to use the 2nd row seat belts, after further inspection, the 2nd row driver’s side seat belt buckle remained latched and failed to release from the buckle and the 2nd row passenger side seat belt failed to latch securely as intended. The vehicle was taken to a local dealer; however, parts were not yet available to repair the vehicle, and the warranty was not valid. The manufacturer was made aware of the failure. The failure mileage was approximately 85,000.

Filed Apr 11, 2025 · Seat belts · IL

Passenger side/right side second row bucket seat = seat belt broke. Called numerous dealerships and were on a waiting list of over 350 that need a seatbelt. No seat belts available. Unable to fix problem. Safety issue due to no seat belt. No warning lamps or messages.

Filed Mar 9, 2025 · Electrical, Seat belts · OK

Passenger seatbelt frayed, inside electrical goes haywire when cold weather, transmission slipping was rebuilt under warranty lasted one week and is slipping again shifting hard, B panels falling off A panel was recalled but panel wasn’t?

Filed Feb 28, 2025 · Airbags, Seat belts · 104,000 miles · MT

The contact owns a 2017 Ford Explorer. The contact stated while driving at various speeds, the air bag warning light illuminated. The contact stated that the air bag warning light intermittently illuminated while driving at various speeds. The vehicle was taken to the dealer and was diagnosed with air bag light row #2 inflatable found on higher wire circuit installed, and the was fuse replaced. Additionally, row #2 buckle, rear center row passengers seat, rear driver seat would not buckle, and that the passenger seat buckle was internally fractured, and the buckle assembly needed to be replaced. The vehicle was not repaired. The dealer informed the contact that the parts were on backorder. The manufacturer was made aware of the failure. The failure mileage was approximately 104,000.

Filed Feb 8, 2025 · Seat belts · MN

In a 2017 Ford Explorer Platinum the passenger 2nd row seatbelt malfunctions and will not extend. It is available for inspection. The seatbelt first binded (or became stuck) March 2024 and taken into Ford dealership and they reported "Upon inspection of seat belt, found to be internally binding at the retractor. Requires replacement." They ordered replacement but said it was on backorder, it took months before replacement arrived. When replacement arrived it was taken in to Ford dealership to replace but Ford reported "Replaced RR seat belt retractor. After installation, found a faulty part was sent. Reinstalled old seat belt and ordered new belt." Returned to Ford dealership for the second replacement seatbelt and it was installed and at time was working. Now for the third time (During the next several months after the third seatbelt is installed) it has gotten stuck (binded) and unable to extend several times and unusable. Resulting in having to relocate the passenger to another seat. Safety concern: users may not have a working and reliable seatbelt. Passenger may not be restrained with seatbelt or it may force a child from sitting in the rear seat to relocate to a more dangerous front seat due to lack of working seatbelts. This seems to show that the seatbelt mechanism must be defective in that 3 seatbelts are having similar problem in a 6-12 month window. Have also seen similar reports of this issue on Reddit.