2019 Ford Explorer: complete transmission failure

Filed May 15, 2026 · Transmission · MT

I had my transmission replaced in California on Feb 2025. Had failure issues and took it to ford, they found an issue with the torque converter and replaced 7 months after the new transmission, it was cleaned out for debris and contamination. Early this May took it in again for the vehicle violently shaking, the ford Mechanic before inspecting immediately knew what transmission I had and knew what issue was, said all the 6F35 transmissions are failing. Took it to my local ford dealership who confirmed that the whole transmissions needs to be replaced again. Less than 20k miles on it. Of course this transmission had a law suit filed which was dismissed. Frustrating because it is clearly a known issue. I am currently #10 on the national waitlist for a new transmission. I am expected to be without a vehicle for months.

Filed Apr 13, 2026 · Transmission · MA

I brought my vehicle to Ford Motor Place in Webster Massachusetts to do two recalls, my car was driving normally before the recall service. Immediately after recall work, it does not run properly. The dealer claims transmission failure without prior symptoms. The vehicle only has 70,000 miles.

Filed Jan 16, 2025 · Transmission · 84,000 miles · MI

The contact owns a 2019 Ford Explorer. While the contact's husband was driving at various speeds, the transmission was slipping. The contact stated that the failure mostly occurred while driving and depressing the accelerator pedal with the transmission shifting between second and third gear. There was no warning light illuminated. The vehicle was taken to the dealer and was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced; however, the vehicle was not repaired due to the cost. The vehicle was then taken to Pioneer Transmission Services, where the transmission was replaced. The contact stated that the transmission warning light illuminated while driving at an undisclosed speed. The vehicle was taken back to Pioneer Transmission Services, where the torque converter was replaced. The vehicle was repaired. The manufacturer was notified of the failure and informed the contact that the VIN was not included in an unstated related recall. The failure mileage was approximately 84,000.

Filed Nov 22, 2024 · Transmission · TX

2019 Ford Explorer XLT with FWD Transaxle transmission and 46,107 miles on odometer, purchased in November 2018 and now 5 years old this month. Way too early for a transmission failure to occur. Normally drive the posted speed limit unless changes in the traffic patterns slower or a little faster.8 Heard a noise from left front wheel area when accelerating and slowing/re-accelerating in traffic. Extended service plan expired (5 year, 60,000 miles, Nov 2018-Nov 2023). Took car to local garage, did a test drive and checked by mechanic. It was determined that problem came from transmission. There have been NO warning lamps, messages, etc. prior to me noticing the problem and nothing since mechanic checked the vehicle. Sounded like the right front wheel area made a noise when turning around in a parking lot this morning. Mechanic estimated cost to repair with parts, labor, etc., will be $6,245.90 out of pocket.

Filed Oct 14, 2024 · Transmission · IL

For months, almost a year, my transmission could not properly accelorate. The car would not allow for the pick up in speed to happen. Each time I took it to the shop that cares for my car, Mike's More Miles, the problem would not duplicate. My special needs son, his service dog and I were all of the expressway traveling, the car slowed down on its own, I had not applied the brakes, the speed dropped from 65 to less than 35 in seconds. I pulled over and tried to regain speed after putting the car into park. No luck. the car would not go faster then 20-30 miles an hour, with me putting into neutral when coasting downhill, then back into drive manually to get it to the repair shop. This almost caused a terrible accident. This scared my son, who has brain disease. Our 85 lb. service dog was jolted from the back of the car slamming into the seat. I was also very scared and shaken. My son began to yell and scream what is happening, it was a scary and tense, literally jaw dropping experience. I drove to Enterprise Rental, called Austin the owner of the shop that has tried to duplicate the problem on a dozen tried and told him what occurred. I left my car at Enterprise, where Austin picked it up. The problem did duplicate. FINALLY a code came up to diagnose the problem. The transmission fluid was also black, with metal shavings in it as well. Please refer to all technical service bulletins that note this is a known problem by Ford. I have paid $7582.70 for a new transmission. The shop owner, Austin, told me the torque converter overheated, the transmission had failed. I also paid for the rental car an estimate of $490.00.

Filed Sep 13, 2024 · Transmission · OR

Vehicle lost acceleration while driving down highway and shuttered severally when depressing gas pedal. I had to cut across lanes of highway traffic with no power and nearly caused an accident. Engine revs up be vehicle wont accelerate, just shakes badly. I am waiting on a mechanic to verify the problem but appears to be a transmission failure. The vehicle has had hard shifting in recent months leading up to this failure. A 2019 model year with 105000 miles.

Filed Feb 21, 2024 · Transmission · MO

My wrench light came on in my 2019 Ford Explorer with 2.3L engine last week. It caused my vehicle to have lack of acceleration during launch and shudder while driving. When my son and I took off from a stop, it was very slow when crossing traffic. Made appointment with Ford dealership to have it looked at the next morning. After car was parked and restarted, wrench light went off. Kept appointment and told them a mechanic friend said it sounded like the torque converter (which my mother who has a 2019 Ford Edge just had replaced the week before!). Explained this to the dealership, they said it didn't sound like that was it. 4 wheel drive module was corrupt so they updated it and told me I may need a new transmission in the near future. Today, my light came on again while taking my son to school and caused lack of acceleration while pulling onto the highway and I took it to the dealership while it was lit up. Codes P0767 and P2704 showed and they told me it was I needed a new transmission due to my torque converter failing. I checked into it and Customer Satisfaction Program 20N07 does not include my car even though it is doing the exact same thing and was assembled in Chicago in January 2019 (timeframe of the program and location). I just don't understand how my car doesn't fall under that program when it is DOING THE EXACT SAME THING with only 67,200 miles on it. This is a serious safety concern. So thankful that there was not heavy traffic when I pulled onto the highway.

Filed Feb 1, 2024 · Transmission · NC

Needs a full transmission replacement and only have 80,000 miles on it. Bought new from dealership in 2019.