2019 Ford Explorer: fuel pump failure

Filed Jul 10, 2026 · Fuel system · OH

Fuel pump and module failure. Driving on the highway at 70 miles an hour and the fuel pump failed. Causing me to have zero acceleration. Thus losing speed rapidly in the center lane. No warning lights were present before or after. One previous symptom of a crank no start. Dealership was able to replicate the crank no start situation. Resulting in the problem being a fuel pump failure and module needing replaced, at 83,000 miles on the vehicle. Though I know normal wear and tear can and does happen, there was no warning. And losing engine power at high speeds on a highway is unsafe.

Filed Apr 9, 2026 · Engine, Fuel system · 50,000 miles · IL

The contact owns a 2019 Ford Explorer. The vehicle was taken to the local dealer to be repaired under the federal safety agency Campaign Number: 26V101000 (Suspension). While retrieving the vehicle, the vehicle failed to start. The contact heard the mechanic revving the engine of the vehicle. The dealer determined that the fuel pump and fuel pump module needed to be replaced, and that the failure was not related to the recall repair. The vehicle was not repaired. The manufacturer was contacted and determined that the failure was not related to the recall. The failure mileage was approximately 50,000.

Filed Jul 18, 2025 · Engine, Fuel system · 60,000 miles · FL

The contact owns a 2019 Ford Explorer. The contact stated that upon acceleration from a stop, the vehicle experienced a loss of automotive power. There were no warning lights illuminated. The vehicle was towed to a local dealer where it was diagnosed, and the contact was informed that the fuel pump and the fuel injectors were faulty and needed to be replaced. The vehicle was repaired; however, the failure persisted. The contact stated that on another occasion while driving 63 MPH, the vehicle lost automotive power. There were no warning lights illuminated. The vehicle was towed to a local dealer where it was diagnosed, and the contact was informed that the fuel pump and fuel injectors were faulty and needed to be replaced. The vehicle was repaired; however, the failure reoccurred while driving 72 MPH, and the vehicle lost automotive power. There was no warning light illuminated. The vehicle came to a complete stop and the contact called the Police for traffic control and the vehicle was towed to a local dealer to be diagnosed. The contact was informed that the fuel pump and the fuel injectors were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 60,000.

Filed Jul 14, 2025 · Fuel system · KS

Car would not start at certain times without warning. Sometimes putting us in an unsafe location. Finally vehicle was in a public parking and would not start and had to be towed to Ford dealer. The fuel pump and some other issues failed. Repair shop said it would happen with low gas, but we had over a half a tank. Total cost of bill without tow was $2132.02. Vehicle had 45,015 miles.

Filed Jul 11, 2025 · Fuel system · GA

On 3 separate occasions my car has stalled when driving. All three were after driving for several hours in hot weather. 2 of the times I had a quarter of a tank of gas and pressed on the gas to pass someone and my car stalled out immediately after. Both very dangerous scenarios. 3 time just this week. Driving for over 5 hours in hot weather conditions, but 3 quarters of a tank of gas and stuck in traffic and the car just completely stalled. Again a dangerous scenario on the highway. All three times after waiting for about 45 minutes the car will start again. Sluggish at first and then drives normal. It’s giving indications that it could be a defect in the low pressure fuel pump that has been a recall in other 2019 ford explorers, but my vin #is not listed as one of them.

Filed Aug 18, 2023 · Fuel system · FL

When the vehicle is in outside in the direct sunlight, the extreme heat causes the fuel pump driver module to fail. When this module fails, it cause the vehicles fuel pump to stop sending fuel to the motor which causes the vehicle to turn off or run extremely rough, while driving and or stationary. The moduel has been replaced by world ford Pensacola once, and twice by an ASE Certified Master Mechanic, on 3 separate occasions.

Filed Jul 10, 2022 · Fuel system · MO

At 53,000 miles I was driving down the highway and my vehicle sputtered and died leaving me stranded on the side of the road. The vehicle would not start. I took the vehicle to a local repair shop and had to replace the Fuel Pump for the vehicle. That was very low mileage to have an issue with a major part like a fuel pump.