2021 Ford Explorer: fuel pump failure

Filed Oct 23, 2026 · Fuel system · 78,209 miles · CA

The contact owns a 2021 Ford Explorer. The contact stated that while driving 30 MPH, the vehicle suddenly shut off. The vehicle was pulled over safely and turned off; however, the vehicle failed to restart. The vehicle was towed to an independent mechanic and was diagnosed with low-pressure fuel pump failure. The contact associated the failure with the federal safety agency Campaign Number: 25V455000 (Fuel System, Gasoline); however, the VIN was not included in the recall. The dealer was notified of the failure. The manufacturer was notified of the failure. The failure mileage was 78,209.

Filed Sep 21, 2026 · Fuel system, Transmission · KS

While driving with the cruise on at 74 mph the vehicle jerked as if the brakes had been tapped. I shut off the cruise and tried to accelerate but nothing happened. At this point I signaled to change lanes and pulled to the right shoulder. There were no dash lights or warning alarms prior to the engine stalling. Clearly an engine stalling at this rate of speed could have ended bad for all 5 passengers and surrounding vehicles. Vehicle is being towed to Augusta, KS Ford dealer this morning 9/21/26. Vehicle was scanned and is showing a hard code for low pressure to fuel pump. This vehicle is not currently included in the NHSTA Campaign 25V455000.

Filed Sep 15, 2026 · Transmission, Visibility · 64,000 miles · NY

The contact owns a 2021 Ford Explorer. The contact received notifications of the federal safety agency Campaign Numbers: 26V117000 (Visibility) and 26V402000 (Power Train); however, the parts to perform the recall repairs were unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repairs. While driving at various speeds, the transmission shifted into park, the vehicle entered LIMP mode, the engine revved abnormally, and there was a smoke odor inside the vehicle. The contact coasted to the side of the road, shifted into park, and waited before shifting back into drive. While refueling the vehicle with the engine turned off and the nozzle inside the fuel filler neck, the vehicle suddenly rolled forward, pulling the fuel pump away from the station. The contact stated that the vehicle continued to roll unless the parking brake was engaged. The dealer was contacted and confirmed that parts were unavailable for the recall repairs. The manufacturer was notified of the issues and stated that parts were expected in the second quarter of 2027. The failure mileage was approximately 64,000.

Filed Jul 18, 2026 · Fuel system · KY

I parked my car and when I returned to it the car would not start. Diagnosed as a faulty fuel pump. Had this problem occurred while I was driving it could have caused serious injury or death. There is an active recall on fuel pumps for the 2021 Ford Explorer that does not apply to my VIN number so Ford will do nothing to remedy the situation and parts are impossible to find as dealers scramble to fix the vehicles included in the recall.

Filed Jul 12, 2026 · Fuel system · WI

I was traveling on an 8 hour drive after just getting a new battery and fresh oil change, I also had a full diagnostic ran the week before travel and no issues were found in my vehicle. When we arrived at our destination we stopped 1 final time and attempted to start our vehicle to go to dinner and the car would not turn over. There were not any warning lamps or messages that appeared. We used roadside assistance to tow it to the [XXX] dealership and they ran another full diagnostic that showed "replace fuel pump and fuel pump driver". When I called my local dealer back home, Evansville Ford ([XXX]) they pulled the previous week diagnostic and confirmed nothing showed up regarding the fuel pump at that time. 1 week later is when we had it in [XXX], and the fuel pump failed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jun 22, 2026 · Fuel system · VA

While driving at highway speeds, the vehicle experienced a sudden and total loss of engine power and stalled in active traffic. I lost motive power and had to safely coast through traffic to the shoulder. The vehicle would not restart and had to be towed to a repair facility. The failure matches the exact symptoms of Ford Recall 25S75 / the federal safety agency Campaign 25V455000 for low-pressure fuel pump failure, but my VIN is currently excluded from the recall.