2023 Ford F-150 Hybrid problems

Filed Oct 5, 2026 · Brakes, Transmission · WY

I purchased a used 2023 Ford F-150 PowerBoost on April 3, 2026. Within days, the vehicle began making a hard clunk during initial acceleration and when stopping. It also hesitates before accelerating, especially while transitioning between electric and gasoline operation. At times, pressing the accelerator does not produce an immediate or predictable response. The problem is worse when accelerating uphill. This creates a collision risk when entering traffic, crossing intersections, merging, or driving uphill. The clunk can be heard and felt through the vehicle. There is also a loud, high-pitched whine that follows engine speed and certain gear transitions and can become extremely loud at highway speeds. On April 22, a Ford dealer confirmed the clunk during acceleration and stopping. The dealer found excessive movement in the rear leaf-spring and shackle bushings and replaced them, but the clunk and hesitation continued. On May 11, the dealer confirmed the high-pitched whine, traced it to the Hybrid Drive Unit, consulted Ford’s escalation team, and replaced the unit. The whining, clunking, shifting irregularities, and hesitation remained and have progressively worsened. Another Ford dealer later inspected the vehicle, but its road test was fewer than two miles, remained below approximately 30 mph, and did not include highway driving, uphill acceleration, merging, or entering traffic. The conditions causing the most serious symptoms were therefore not evaluated. Associated warning lights or messages are UNKNOWN. The vehicle is now parked because I no longer consider it safe to drive. It is available for inspection upon request.

Filed Sep 14, 2026 · Transmission · IN

The contact owns a 2023 Ford F-150. The contact received notification of the federal safety agency Campaign Number: 23V896000 (Power Train); however, the part to do the recall repair was not yet available. The dealer was contacted. The dealer confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.

Filed Aug 3, 2026 · Acceleration, Brakes · TX

I am reporting a safety-related transmission problem I experienced with my 2023 Ford F-150 equipped with the 10R80 automatic transmission. While driving normally, the transmission suddenly does not accelerate for up to 3 seconds while pressing the gas pedal, brakes either harshly or too soft at varying times, and very irregularly. This occurred while accelerating onto the highway, and almost every time I am braking at a stop sign or light, creating a potentially dangerous situation because the truck did not respond as expected when I needed predictable acceleration, propulsion, or deceleration. I believe this incident may be related to the known 10R80 CDF clutch-cylinder/sleeve problem. Ford technical information identifies axial movement of the CDF sleeve that can cause hydraulic-circuit leaks and harsh or delayed engagement and shifting. This condition can result in slipping, RPM flares, delayed engagement, unexpected gear changes, harsh downshifts, lurching, or loss of propulsion. This is a safety concern, not merely a transmission quality or reliability issue. Unexpected loss of propulsion or unpredictable shifting while merging, accelerating into traffic, crossing an intersection, turning, traveling at highway speeds, slowing down, and stopping, can create a collision hazard. Because I personally experienced this unexpected transmission event, I request that the federal safety agency investigate the 10R80 CDF clutch-cylinder/sleeve condition in Ford F-150s. Please review Ford warranty claims, dealer repair records, transmission replacements, consumer complaints, and field-failure data to determine whether this is a safety defect requiring a recall. I believe owners should not have to wait for a potentially dangerous transmission failure before this known condition is addressed.

Filed Aug 1, 2026 · Transmission · MO

I am reporting a safety-related transmission problem I experienced with my 2023 Ford F-150 equipped with the 10R80 automatic transmission. While driving normally, the transmission suddenly lost the selected gear, its slipped, shifted violently, RPMs flared, unexpectedly downshifted from 5th to 1st. So I took it in and they said it was my torque converter going out, and that it wasn’t something that they were aware of being a problem. This occurred when accelerating, merging onto a highway, turning, or just when driving straight. Creating a potentially dangerous situation because the truck did not respond as expected when I needed predictable acceleration or propulsion. I believe this incident may be related to the known 10R80 CDF clutch-cylinder/sleeve problem. Ford technical information identifies axial movement of the CDF sleeve that can cause hydraulic-circuit leaks and harsh or delayed engagement and shifting. This condition can result in slipping, RPM flares, delayed engagement, unexpected gear changes, harsh downshifts, lurching, or loss of propulsion. This can cause strain and damage to other parts on the transmission as well. This is a safety concern, not merely a transmission quality or reliability issue. Unexpected loss of propulsion or unpredictable shifting while merging, accelerating into traffic, crossing an intersection, turning, or traveling at highway speed can create a collision hazard. Because I personally experienced this unexpected transmission event, I request that the federal safety agency investigate the 10R80 CDF clutch-cylinder/sleeve condition in Ford F-150s. Please review Ford warranty claims, dealer repair records, transmission replacements, consumer complaints, and field-failure data to determine whether this is a safety defect requiring a recall. I believe owners should not have to wait for a potentially dangerous transmission failure before this known condition is addressed.

Filed Aug 1, 2026 · Transmission · TX

I am reporting a safety-related transmission problem I experienced with my 2023 Ford F-150 equipped with the 10R80 automatic transmission. While driving normally, the transmission suddenly fails to engage then randomly shifts violently. This occurs when merging onto a highway, crossing an intersection, traveling at highway speed, stop-and-go traffic,creating a potentially dangerous drive. This is common issue with this type of transmission, mostly related to the drum itself; slipping thus causing its erratic behavior.

Filed Jul 29, 2026 · Transmission · WA

Vehicle came in for service and the gear selector lever on the steering column was found to be loose. Upon further inspection it was found that the two phillips head screws that hold the gear selector lever to the column assembly had come loose and one had fallen out completely.

Filed Jun 23, 2026 · Brakes, Lights · TX

The driver's side rear light is full of moisture and some water. It is available for inspection. The Ford dealership in Beeville Texas Coastal Bend Ford inspected it already and informed me that it would cost $1,400 to replace and that it was only going to get worse. They also informed me that Ford allows a certain percentage of moisture and water to be in there safely. When you see the pictures this is definitely unacceptable and unsafe. This is causing the reverse lights to flicker intermittent. The moisture accumulation inside the lights can result in inoperative or flickering reverse lamp function. Inoperative reverse lamps may reduce the awareness of other motorists or road users of the driver's intention to operate the vehicle in reverse gear increasing the risk of injury or crash. I bought the vehicle from a Ford dealership in Austin Texas less than 10 days ago. I reported it to them and they stated it wouldn't be covered under warranty. The best assessment in my opinion of cause is going to be microcracks in the outer lens. Because my truck is a 2023 Ford F-150 King Ranch, and there is a known recall for the same issue for 2022-2023 Lariat and Platinum models, so this can't be a coincidence. Refer the federal safety agency recall number 23V‑418

Filed Jun 16, 2026 · Transmission · FL

transmission failure while driving resulting in vehicle shutting down on turnpike. ford was paid to fix trans. and failed, now the vehicle sits in ford autonation margate florida. I believe there is a history of transmission issues with the 10 speed transmission, but this was unsafe . I had to coast across 4 lanes to the shoulder.

Filed Jun 4, 2026 · Electrical · SD

tried to get ford to install Heated Steering Wheel Performance Upgrade 22G06 on this and they claim the case was closed and denied because of the credit on my window sticker they closed my case ID without even notifying me about it. (Ford CASE ID for heated steering module. XXX). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 14, 2026 · Fuel system · TX

I have a 2023 f150 powerboost. I slowed down to a yielding sign to turn right onto the state highway. The engine was in electric mode, I went to push the acceleration pedal and nothing happened. The truck would not accelerate for 4-5 seconds. I then put the accelerator pedal to the floor and it finally engaged and the truck flew. I’ve had it happen once before but for only a second so I thought nothing of it. It was a scary experience as I could have been hit if another drive wasn’t paying attention. I’m scared to drive it now, and have made an appointment with the local ford dealership to diagnose. No engines lights are on. Only happens when stopping briefly.