2018 Ford F-150 suspension problems

Filed Sep 22, 2026 · Suspension · NJ

Driver side front coil spring cracked/collapsed NOTE: THIS IS A COMMON PROBLEM WITH THE 2017-2018 FORD F-150

Filed Nov 11, 2025 · Suspension, Transmission · MT

At 66,000 miles I had to rebearing the Transfercase,and rear differential. at 88,000 miles I had to put a metal oil pan on it, because Ford used a two peice Plastic one.. they leak. Now I have a bad yoke off the transfer case,AND, the rear springer hangers are cracked on the welds. This is structural failure,..Ford is aware of the proplem ,because they offer a repair kit. I bought this truck new and it has never been wrecked.. Ford doesnot want to fix it..My complaint numberis 11698591. Thank you. [XXX] .. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Nov 10, 2025 · Suspension · 80,000 miles · MT

The contact owns a 2018 Ford F-150. The contact stated that the rear suspension spring was cracked. While looking underneath the vehicle, the contact noticed a hairline crack on the weld. There was a vibration in the vehicle while driving. There was no warning light illuminated. The local dealer was contacted, but no assistance was provided. The vehicle was not diagnosed or repaired. The manufacturer was contacted and confirmed that there was no warranty coverage on the vehicle, and no assistance was provided. The failure mileage was approximately 80,000.

Filed Nov 8, 2025 · Suspension · IA

Splash guard under the vehicle, sometimes also referred to as a diaper, fell off. I reported it to the dealer and was told I didn't need it anyhow. Well, if I didn't need it anyhow why did they put it on to begin with ? I also notice a lot of other Ford vehicles driving down the road with these guards (diapers) hanging down, so it isn't just a me problem it's a Ford problem. After inspecting the guard it is made of such cheap material I don't know how any engineering designer could of thought that these would hold up given the environment under a vehicle especially a truck. I would also think that this could easily become a road hazard.

Filed Jun 20, 2025 · Suspension · MI

Coil spring on the front drivers side suspension snapped in half while driving causing a momentary loss of control that was quickly regained. The spring was replaced at a local repair shop. There were no warning signs before failure occurred.

Filed Mar 31, 2025 · Engine, Suspension · CO

My cam phasers are always burning and consuming a lot of oil it also has a ticking sound coming from the engine which Ford says is normal but I don't think it's normal because it gets louder and it happens as I drive all the time. My transmission will automatically slam into a higher gear while trying to accelerate on the highway. Oil is constantly getting into the spark plug chamber even after replacement of seals.

Filed Mar 14, 2025 · Suspension · 112,900 miles · MA

The contact owns a 2018 Ford F-150. The contact stated that while starting the vehicle, there was an abnormal sound coming from the engine. The contact stated that while driving at various speeds, the vehicle jerked with an abnormal ticking sound coming from the front of the engine. No warning lights were illuminated. The vehicle was taken to a dealer, and it was diagnosed that the cam phasers had failed and needed to be replaced. The vehicle was not repaired. The contact related the failure to the federal safety agency Campaign Number: 21E027000 (Suspension), which was received in 2021. The vehicle was previously repaired. The manufacturer was notified of the failure and the contact was informed that the recall was closed since the vehicle was previously repaired. The contact was referred to the NHSTA Hotline for assistance. The approximate failure mileage was 112,900.

Filed Mar 2, 2025 · Engine, Suspension · NM

This truck was supposed to be recalled under the Transmission recall for 10r80 and I noticed while conducting a decode on the vin number that the type and kind of transmission was never listed so I’m wondering how many people have been going through the same issues as us and if this will get fixed because our vin is not recalled and it should be

Filed Sep 12, 2024 · Suspension, Transmission · 106,000 miles · LA

The contact owns a 2018 Ford F-150. The contact stated that while operating the vehicle, the transmission malfunctioned, causing the vehicle to suddenly lose motive power. Additionally, the RPMs increased but the vehicle did not properly accelerate with the "Service Wrench" warning light illuminated. The cause of the failure was not yet determined. The contact stated that while driving at an undisclosed speed, there was a grinding noise coming from the front of the vehicle. Upon inspection, the contact discovered that the front driver’s side wheel hub bearings were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The local dealer was not contacted. The failure mileage was 106,000.

Filed Jun 17, 2024 · Brakes, Steering · FL

I have been having nothing but problems with this truck since I purchased it and I'm looking to see if anyone can help me out with this truck. I have had it now almost two years and the truck was in the shop for 3 months of it getting worked. I have had nothing but problems with the braking system as well. The dealer wouldn't sell me the original pads for it, they sent someone to car quest to get a set of pads. Whenever i gave them the vin i would always end up with the wrong parts somehow. So i dont know if there is vin fraud or what but something wasn't adding up. The dealer i purchased it from is not much of help. The water pump has gone out, the cam phasers were replaced(and are rattling again.) The starter was replaced due to clunking when started.( still clunks) Oil pan gasket was replaced. The transmission had to be replaced. I am just trying to see what my options are with this truck. It's clearly a lemon and just wondering if there's anything anyone can do to help because the reliability of this 35,000 dollar truck is out the window.