2015 Ford F-250 SD: check engine light

Filed Jun 3, 2025 · Engine, Fuel system · 122,000 miles · TN

The contact owns a 2015 Ford F-250. The contact stated that while driving at various speeds, there was an abnormal ticking sound coming from the engine while depressing the accelerator pedal. The contact stated that after accelerating from a stop light, the vehicle started to sputter with the check engine warning illuminated. The contact pulled over and had the vehicle towed to the dealer. While at the dealer, a fault code for the fuel pump failure was retrieved. The contact was informed that shards of metal had entered the fuel system, and the contact was provided an estimate for the repair. The manufacturer was notified of the failure but offered no assistance. The contact was referred to the federal safety agency Hotline to report the failure. The vehicle was not yet repaired. The failure mileage was approximately 122,000.

Filed Aug 23, 2024 · Engine, Fuel system · 115,000 miles · TX

The contact owns a 2015 Ford F-250. The contact stated that while driving at 65 MPH, there was an abnormal sound coming from the engine compartment, with the check engine warning light illuminated. The contact stated that there was white smoke coming from the rear of the vehicle. The vehicle lost motive power and the contact pulled over to the side of the road and turned off the vehicle. The vehicle was unable to be restarted. The vehicle was towed to a dealer where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The vehicle was then taken to another dealer where it was diagnosed and determined that the fuel system and the engine was damaged. The contact was informed that the fuel system and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 115,000.

Filed Mar 25, 2024 · Engine · 40,000 miles · CA

The contact owns a 2015 Ford F-250. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated on the instrument panel. The vehicle was taken to the dealer, who diagnosed a failure with the rear NOx sensor. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N05. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the federal safety agency hotline for assistance. The failure mileage was 40,000.

Filed Feb 22, 2024 · Fuel system · 85,000 miles · OK

The contact owns a 2015 Ford F-250 The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed with a failed diesel particulate filter. The contact was informed that the diesel particulate filter needed to be replaced. The dealer advised the contact that there was a Customer Satisfaction Program for the repair, but the vehicle was not eligible. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to report the failure to the federal safety agency Hotline. The failure mileage was approximately 85,000.

Filed Aug 8, 2023 · Fuel system · 284,000 miles · SC

The contact owns a 2015 Ford F-250. The contact was exiting a highway ramp at approximately 60 MPH when the check engine and reduced engine power warning lights illuminated. The contact pulled over, stopped the vehicle, turned off, and restarted the vehicle to reset the warning lights. The contact stated that the warning lights again became illuminated, and the vehicle started to lose motive power. The contact was able to safely reach his destination and later the vehicle was taken to an independent mechanic where the vehicle was diagnosed, and it was determined that the fuel pressure sensor needed to be replaced. The vehicle was test-driven and several unknown warning lights were illuminated. The vehicle was driven back to the mechanic who drained a fuel line and discovered metal shavings in the line. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 284,000.

Filed Aug 7, 2023 · Fuel system · 111,000 miles · IA

The contact owns a 2015 Ford F-250. The contact stated that the check engine warning light was illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that the diesel particulate filter (DPF) had failed, and the failure was related to Ford Campaign Number: 20M06-2. The vehicle was then taken to the dealer, who informed the contact that the vehicle was not covered under the Campaign. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline for assistance. The failure mileage was approximately 111,000.

Filed Jul 18, 2023 · Engine · 69,361 miles · MN

The contact owns a 2015 Ford F-250. The contact stated while driving 60 MPH, the check engine warning light illuminated. The vehicle was taken to the dealer who stated that the exhaust gas temperature sensor needed to be replaced. The contact was informed that the vehicle was experiencing the failure listed in Technical Service Bulletin: 15M02. The contact was informed that the vehicle was out of warranty. The vehicle was repaired. On another occasion while driving 60 MPH, the diesel exhaust fluid low warning light illuminated. The contact was able to pull over and added more exhaust fluid, but the warning light illuminated again. The vehicle was taken to an independent mechanic and the contact was informed that the knock sensor needed to be replaced and the contact was referred to the local dealer. The vehicle was taken to the dealer and it was confirmed that the knock sensor needed to be replaced. The vehicle was repaired. The manufacturer was contacted and stated that the vehicle was not under warranty. The failure mileage was 69,361.

Filed Oct 18, 2021 · Fuel system · 82,111 miles · MA

The contact owns a 2015 Ford F-250. The contact stated while pulling a trailer and driving 65 MPH, the check engine warning light and powering down warning message were illuminated. The contact stated that he continued driving for a mile before the vehicle started to decelerate. The contact parked on the side of the road. The vehicle was not drivable. The contact towed the vehicle to an independent mechanic and was informed that shards of metal were found inside the fuel line and fuel filter. The vehicle was repaired. A dealer was not contacted. The manufacturer was not made aware of the failure. The failure mileage was 82,111.

Filed Jul 7, 2021 · Engine · 60,000 miles · TN

The contact owns a 2015 Ford F-250. The contact stated while driving at various speeds, the vehicle entered limp mode. The contact stated that the check engine warning light was illuminated. The vehicle was not diagnosed nor repaired. The manufacturer was informed of the failure and told the contact that the vehicle was not under recall. The failure mileage was approximately 60,000.

Filed Jun 30, 2020 · Engine · 105,000 miles · ND

At just over 100000 miles, check engine light code p20ba came on, reductant heater, turn out as it is an f250 its not covered, but f450 and f550 are. Also as air temperatures are in high 80f, the heater is not required. Now emissions are not meeting the specifications and truck completes more regens to stay clean, increasing chance of heating nearby items (straw, grass and household structure) potentially starting fires. The regens occur during highway travel and the heating affects surrounding area when parked

Filed Jun 9, 2020 · Engine, Fuel system · 26,737 miles · TX

I was heading from cibolo, tx to kingsville, tx. (distance 181 miles) upon arriving at destination I shut down my truck. After approximately one hour, I started my truck and the check engine light came on. I connected my obd reader and it identified the fault code p21b0 (I did not clear any codes). From my research it relates to the 'reductant level sensor 'c' circuit high'. After researching more information I started looking through the information center under the vehicle setting and noticed the def level was below half (I never got a pop up or notification from the information cluster). In the past the information cluster would display the level notification without an engine light coming on. This time it did not. I purchased some def and filled the tank. It only took two gallons of def. The engine light remained on the rest of the day driving around after filling the def tank and the def 'below half' notification also remained on. The next morning I started the truck and the engine light was off and the def 'below half' notification was gone.

Filed Mar 9, 2020 · Engine · 70,600 miles · CA

Since my last complaint this truck has had to have the def heater/sending unit replaced @ 70091 miles. Today the check engine light has come on again for the 4th time for a p207f code. Purchased truck october 2018 with 53,000 miles. December 10, 2018 ccv collar put in @ 57,104 miles for p207f code. December 21, 2018 nox sensors replaced @ 57414 miles for p207f code. August 30, 2019 egt sensors replaced @ 65687 miles for p242a & p2031 code. January 15, 2020 nox sensors replaced @ 69332 miles for p207f code. February 4, 2020 def heater/sending unit replaced @ 70091 miles - code ??. March 8, 2020 truck has popped p207f code again @ approx 70600 miles. At all times the truck was moving when the check engine light came on. At all times the truck was taken in for service within a few days of the check engine light coming on.