2022 Ford F-250 SD: check engine light

Filed Sep 4, 2026 · Fuel system · 32,000 miles · TN

The contact owns a 2022 Ford F-250 SD. The contact received notification of the federal safety agency Campaign Number: 25V455000 (Fuel System, Gasoline). The contact stated that while driving on several occasions at various speeds, the vehicle lost power and stalled. The vehicle was able to restart after each failure after two minutes. The contact stated that the failure persisted. The contact stated that during one failure while hauling a trailer, the vehicle immediately stalled. The contact stated that during the last failure, the check engine warning light illuminated. The vehicle was not diagnosed or repaired. The failure mileage was approximately 32,000.

Filed Jul 7, 2026 · Fuel system · 53,000 miles · NY

The contact owns a 2022 Ford F-250. The contact received a recall notification of the federal safety agency Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that while the contact's husband was driving at an undisclosed speed, the accelerator pedal was depressed, but the vehicle failed to accelerate as intended and lost motive power. The vehicle was driven to the shoulder of the road, and the engine seized. The check engine warning light was illuminated. The driver attempted to restart the vehicle, but the vehicle failed to restart. The vehicle was towed to the dealer, where it was diagnosed with a failed fuel pump. The contact was informed that the fuel pump needed to be replaced. The vehicle was repaired; however, the failure recurred while traveling out of the State on vacation, with a trailer hitched to the vehicle. Additionally, the contact stated that the outside temperature was extremely hot, and the tow truck operator took three hours to arrive. The manufacturer was not made aware of the failure. The failure mileage was approximately 53,000.

Filed Jun 9, 2026 · Electrical, Engine · WI

10 day roundtrip from [XXX] to [XXX]. 5 incidents of catastrophic engine failure on interstates. Truck started to jerk, sputter, lost power at an alarming rate. No engine light until failure ocurred. Very dangerous with heavy holiday traffic. Lives were in danger, us and other vehicles around us. No one expects travel to go from 70 mph,to 50, 30, 15 in such a short period of time. Pulled over to "investigate" code failures we deemed as o2 sensors. Afterwards the truck started back up, no engine lights and drove as normal. Started using premium gasoline, hoping it would help. Started driving in right lane as much as possible but had a failure ocurr right in front of on ramp as well at interstate speeds. Had another family following us so they also witnessed and pulled over all incidents. Brought into Ford 7/18/24 upon return home. Paid $125 inspection fee, concern not present, come back if happens again. Makes no sense that codes not present to pull. 12/13/2024 engine light on, catalytic converter replaced. 06/19/25 truck had catastrophic failure returning from work on hwy. XXX on [XXX], just two miles from leaving home another failure with no warning lights in heavy Friday traffic in construction zone. Couldn't clear the traffic lane completely. Very scary. Waited for clearing and limped it to a nearby off ramp. Same jerking, loss of power. Vehicle towed to shop for 2 weeks, testing, fuel pump replaced. Picked up 07/07/25. Next day received recall notice 25S75 in the mail 7/08/25. Everything made sense. 1/24/26 - Battery failed inspection @ 40% during oil change. Replaced battery ourselves from Costco. 04/23/26- Warning light, P0420 pulled, shop recommended engine tune -up. Paid $175 inspection fee + $671.20 tune up. 5/29/26 engine light on, P0420 pulled, recommend catalytic convertor replaced but not under factory warranty anymore so wants us to pay $4000 bill. Escalated up through Ford. As of 6/5/26 - Ford will pay half. I refuse. Should be covered by recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF I

Filed Mar 6, 2026 · Engine · 70,000 miles · NY

The contact owns a 2022 Ford F-250. The contact stated that while driving on several occasions at various speeds, the vehicle was driving sluggishly while accelerating, the RPM fell, and the vehicle lost motive power. The check engine warning light was illuminated. The vehicle was taken to a dealer and was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The spark plugs were replaced, and a tune-up was performed; however, the failure persisted. The vehicle was then taken to an independent mechanic to be diagnosed. The contact was informed that there was a misfire coming from the engine and that the ignition wires needed to be replaced. The vehicle was repaired, but the failure persisted. The manufacturer was notified of the failure. The failure mileage was approximately 70,000.

Filed Nov 8, 2025 · Transmission · TN

October 2024 (while out of state vacation): The transmission violently downshifted upon moderate acceleration such that truck lurched with a loud bang, went into limp safe mode in traffic, with no rear warning because brakes were not applied. I was able to shut the vehicle off and restart, and able to engage the transmission, though engagement remained harsh. No Check Engine Lights were illuminated. Upon return home, I got the truck to local dealer service center. They had the truck for a week and said they could not determine a cause or problem...no scanner codes recorded? Their tech could not duplicate. From October 2024 until June 2025, this same behavior occurred 2-4 times, all without CELs. June 2025: Truck taken to local dealership with symptom list, only now occurring more frequently. At my insistence, I asked the dealer to involve Ford Engineering, to diagnose, and to compel Ford to honor the active full warranty still in place. This unresolved issue began October 2024. The dealer had the truck for over a month, and said he could not proceed further in diagnosing unless Ford authorized warranty payment for labor and parts. No progress was made, and it was told to me I HAVE TO CONTACT FORD and push, because the dealer is an independent shop, not Ford proper. I took the truck away and drove, to allow possible worsening, or some other code to be recorded or CELs to show. October 2025: Truck violentlt downshifted without acceleration or deceleration from 35 mph to almost )mph, skidding and fishtailing, going into limp mode, and I was almost rear ended by following traffic...since brakes were not activated to cause this. Truck went immediately into limp mode, and would not now engage PARK. I turned it off, restarted, and transmission would hardly go into DRIVE. I limped home, and vowed I will not drive it again until repaired! No CELs illuminated. The truck was towed to the dealer at my cost, and has been there over 2.5 weeks as of 11/8/25. Ford denies help.

Filed Oct 18, 2025 · Engine · MD

The failed component is a lifter/camshaft. Luckily I was attentive to my vehicle and noticed a ticking noise within the engine and took it to a dealer for diagnosis. An engine failure while traveling at highway speeds could be a disastrous to occupants and others around them. This appears to be a common problem with the 7.3l engine. The check engine light illuminated after i noticed the ticking noise.

Filed Sep 10, 2025 · Fuel system · 21,646 miles · NM

The contact owns a 2022 Ford F-250. The contact received notification of the federal safety agency Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving approximately 55-60 MPH and hauling a Fifth Wheel Trailer, the low-pressure fuel pump suddenly failed and the vehicle lost power, causing the vehicle to stall. The contact activated the hazard lights and waited for a tow truck that was in the far-left lane on the freeway. The check engine warning light illuminated immediately when the vehicle lost power. The vehicle was towed to the dealer, who determined that the vehicle had experienced the failure listed in the federal safety agency Campaign Number: 25V455000 (Fuel System, Gasoline) but could not yet be repaired because parts to do the recall repair were not yet available. The dealer referred the contact to the federal safety agency Hotline to report the failure. The manufacturer was informed of the failure and opened a case. The failure mileage was 21,646.

Filed Jul 30, 2025 · Engine, Transmission · 30,000 miles · DE

The contact owns a 2022 Ford F-250. The contact stated that while driving 60 MPH, the vehicle skipped gears, decelerated unintendedly and lost motive power. The check engine warning light was illuminated. The contact stated that the failure had progressively increased. The vehicle was taken to the local dealer, where the failure could not be duplicated. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 30,000. The VIN was not available.

Filed Jul 7, 2025 · Engine · 62,454 miles · NY

The contact owns a 2022 Ford F-250. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the dealer, who performed a service update on the vehicle, which required a software update. The check engine warning light remained illuminated. The vehicle was returned to the dealer, who diagnosed that the catalytic converter had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and opened a case. The manufacturer offered to cover part of the cost of the repair. The manufacturer referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was approximately 62,454.

Filed Jun 23, 2025 · Engine · 80,000 miles · OK

The contact owns a 2022 Ford F-250. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who determined that there was a misfire in cylinder #2. The contact was informed that the vehicle needed to be taken to a Ford dealer for assistance. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 24B25. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the federal safety agency Hotline for assistance. The failure mileage was 80,000.

Filed Jun 2, 2025 · Engine · 76,000 miles · TX

The contact owns a 2022 Ford F-250. The contact stated that upon starting the vehicle, there was an abnormal tapping sound coming from the engine and the vehicle was idling rough. The contact stated that the check engine warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed, and the contact was advised that further diagnostic testing was required to determine the cause of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 76,000.

Filed Mar 21, 2025 · Fuel system · 82,000 miles · TX

The contact owns a 2022 Ford F-250. The contact received notification of the federal safety agency Campaign Number: 24V957000 (FUEL SYSTEM, DIESEL); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact's husband stated that while driving 70 MPH, the accelerator pedal was depressed, and the vehicle failed to respond. The check engine warning light was illuminated. The contact's husband stated that the check engine warning light was illuminated, and the vehicle lost motive power. The contact stated that after turning off and restarting the vehicle, the vehicle functioned as needed for several days. The vehicle was then taken to a dealer and the contact's husband was informed that there was no technician available to repair the vehicle. The vehicle was diagnosed with turbo failure. The vehicle was not repaired. The failure mileage was approximately 82,000. VIN tool confirms parts not available.