2022 Ford F-250 SD: sudden loss of power

Filed Oct 31, 2026 · Engine · TX

I am hearing knocking (metal on metal) noise at idle. I am concerned it is the cam and lifter oil starvation issue. Also, the idle has become a bit rough with intermittent misses causing vibration. I took to the dealer and they said this is "normal function". while the engine is running, there is no safety risk. but when/if the lifter/cam fails, the truck will lose power completely and, depending on where this occurs, could be quite dangerous.

Filed Sep 8, 2026 · Fuel system · UT

The contact owns a 2022 Ford F-250 SD. The contact stated that while driving at an undisclosed speed on the highway, the vehicle suddenly lost power, came to a full stop, and was unable to be restarted. The contact received notification of the federal safety agency Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to perform the recall repair was not yet available. The local dealer was contacted but was unable to recreate the failure. The contact stated that while attempting to restart the vehicle, there was an abnormal exhaust odor. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue.

Filed Sep 4, 2026 · Fuel system · 32,000 miles · TN

The contact owns a 2022 Ford F-250 SD. The contact received notification of the federal safety agency Campaign Number: 25V455000 (Fuel System, Gasoline). The contact stated that while driving on several occasions at various speeds, the vehicle lost power and stalled. The vehicle was able to restart after each failure after two minutes. The contact stated that the failure persisted. The contact stated that during one failure while hauling a trailer, the vehicle immediately stalled. The contact stated that during the last failure, the check engine warning light illuminated. The vehicle was not diagnosed or repaired. The failure mileage was approximately 32,000.

Filed Jun 9, 2026 · Electrical, Engine · WI

10 day roundtrip from [XXX] to [XXX]. 5 incidents of catastrophic engine failure on interstates. Truck started to jerk, sputter, lost power at an alarming rate. No engine light until failure ocurred. Very dangerous with heavy holiday traffic. Lives were in danger, us and other vehicles around us. No one expects travel to go from 70 mph,to 50, 30, 15 in such a short period of time. Pulled over to "investigate" code failures we deemed as o2 sensors. Afterwards the truck started back up, no engine lights and drove as normal. Started using premium gasoline, hoping it would help. Started driving in right lane as much as possible but had a failure ocurr right in front of on ramp as well at interstate speeds. Had another family following us so they also witnessed and pulled over all incidents. Brought into Ford 7/18/24 upon return home. Paid $125 inspection fee, concern not present, come back if happens again. Makes no sense that codes not present to pull. 12/13/2024 engine light on, catalytic converter replaced. 06/19/25 truck had catastrophic failure returning from work on hwy. XXX on [XXX], just two miles from leaving home another failure with no warning lights in heavy Friday traffic in construction zone. Couldn't clear the traffic lane completely. Very scary. Waited for clearing and limped it to a nearby off ramp. Same jerking, loss of power. Vehicle towed to shop for 2 weeks, testing, fuel pump replaced. Picked up 07/07/25. Next day received recall notice 25S75 in the mail 7/08/25. Everything made sense. 1/24/26 - Battery failed inspection @ 40% during oil change. Replaced battery ourselves from Costco. 04/23/26- Warning light, P0420 pulled, shop recommended engine tune -up. Paid $175 inspection fee + $671.20 tune up. 5/29/26 engine light on, P0420 pulled, recommend catalytic convertor replaced but not under factory warranty anymore so wants us to pay $4000 bill. Escalated up through Ford. As of 6/5/26 - Ford will pay half. I refuse. Should be covered by recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF I

Filed May 15, 2026 · Engine · MS

Lifter failure causes cylinder to misfire resulting in loss of power while towing. Defect causes catastrophic failure to the engine.

Filed Dec 8, 2025 · Engine, Transmission · FL

Subject: Safety Recall 24V‑957 – Loss of Power Risk – Dealer Mishandling I am filing a complaint regarding Ford recall 24V‑957 (Ford reference 24S78) for my vehicle. The recall states the defect can cause: “Loss of driving power, increasing the risk of a crash” “Engine stall” “Loss of motive power while driving” My vehicle has shown symptoms consistent with these safety risks. When I brought the vehicle to the dealership: 1. They claimed fuel contamination but provided a fuel sample with a Dec 3 timestamp, even though they originally claimed the issue was discovered on Nov 26, raising chain-of-custody concerns. 2. They have refused to properly address the recall or escalate the matter. 3. They threatened to report my rental car as stolen, even though I have not refused to return it and the vehicle is still under an unresolved recall safety issue. 4. Ford Customer Care refuses to intervene and instructs me to deal only with the dealership, despite this being a manufacturer safety recall. This situation has left me without clear direction, without safe transportation, and with concerns about dealership misconduct and improper handling of a safety-critical recall. I am requesting the federal safety agency review this recall handling and ensure Ford properly manages recall repairs, towing, rental support, and dealer oversight.

Filed Sep 10, 2025 · Fuel system · 21,646 miles · NM

The contact owns a 2022 Ford F-250. The contact received notification of the federal safety agency Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving approximately 55-60 MPH and hauling a Fifth Wheel Trailer, the low-pressure fuel pump suddenly failed and the vehicle lost power, causing the vehicle to stall. The contact activated the hazard lights and waited for a tow truck that was in the far-left lane on the freeway. The check engine warning light illuminated immediately when the vehicle lost power. The vehicle was towed to the dealer, who determined that the vehicle had experienced the failure listed in the federal safety agency Campaign Number: 25V455000 (Fuel System, Gasoline) but could not yet be repaired because parts to do the recall repair were not yet available. The dealer referred the contact to the federal safety agency Hotline to report the failure. The manufacturer was informed of the failure and opened a case. The failure mileage was 21,646.

Filed Jan 8, 2025 · Engine, Fuel system · TX

Engine started to tick and loss of power, had it hauled to ford dealership in Tulia tx to later find out that it had faulty rocker arms which is a known problem after calling around asking other dealerships if they have seen other pickups come in with the same issue! After digging further into the motor they found that the fuel system was going bad and also would have to be replaced which is also a well known issue after ford recalled 300,000 of these pickups with the same issue

Filed Jun 19, 2024 · Driver assistance, Electrical · NC

Loss of power windows,loss of A/C and heat,loss of turn signals,loss of radio,and loss of head lights. As well as engine not shutting off after key is pulled out. The first initial problems arose a year ago, not long after purchasing a 2022 Ford f250 superduty. Only when it rained or during very cold days the power to the front dash would be out including power windows and locks,radio, and A/C and heat. Ford dealership was unable to diagnose the problem. A year down the road,directly following a hard rain, the engine would not shut off when turning the key and removing it. I had to pull the fuel pump relay fuse from under hood to get the truck to shut off. After removing the lid, which was way too easy to take off, I noticed that all th box fuses were submerged in water. Yes there are safety concerns,what if my child ir myself was to get trapped inside the truck if the power windows and locks are malfunctioning? And on a hot day when the heat and air conditioning are also not working? How long would the truck have to continue to run before it shut off? There are electrical fire risks directly correlated with water in the fuse box. There were no warning lamps. Ford posted a service bulletin on regards to this matter. The power distribution module and the fuse box lid are at fault. The truck has since been repaired and are making us pay for it because it is 5,000 miles out of warranty. WE ARE extremely dissatisfied Ford customers!

Filed Oct 2, 2023 · Fuel system · TX

Driving down a busy highway and my truck starts lurching and losing power and then just dies in the road. I had to wait a few minutes and the truck would start up. There were no warnings or lights initially. This happened three times. After the third time it would no longer start, and a solid check engine light appeared after the third time. The check engine light did not present itself the first two times. According to the dealer service department the fuel pump quit working. Based on the time of day, the traffic was horrific, and I was almost rear ended when the truck stopped in the middle of the road.

Filed Sep 1, 2022 · Transmission · WI

complete loss of power after take off.