2020 Ford F-250 SD: sudden loss of power

Filed Oct 30, 2026 · Engine · MI

I am filing this complaint regarding a catastrophic engine failure in my 2020 Ford F-250. The engine experienced low oil pressure due to a failure involving the camshaft (cam). The failure resulted in damage severe enough that the entire engine had to be replaced. Component or System Failure: The component that failed was the camshaft within the engine. The failure resulted in low oil pressure and subsequent internal engine damage, ultimately requiring complete engine replacement. The failed engine and/or components may be available for inspection upon request, subject to confirmation of their current location and availability. Safety Risk: This failure created a significant safety concern. A sudden loss of engine oil pressure can result in catastrophic engine failure, loss of engine power, and potentially an unexpected vehicle shutdown while driving. Losing engine power while traveling at highway speeds or in traffic could put the driver, passengers, and other motorists at serious risk of an accident. The possibility of sudden engine failure without adequate warning is particularly concerning in a heavy-duty pickup truck that may be used for towing or hauling. Dealer or Independent Service Confirmation: The engine failure was serious enough that the entire engine required replacement. The low oil pressure and resulting engine damage were identified as the cause of the failure. The repair and diagnosis were handled through a ford dealer. Specific diagnostic findings and documentation can be provided if requested. Inspection by Manufacturer or Other Parties: The vehicle was serviced due to the engine failure and underwent evaluation as part of the repair process. Whether the failed components were independently inspected by Ford Motor Company or other parties is UNKNOWN. Warning Lamps, Messages, or Symptoms Prior to Failure: The primary symptom associated with the failure was low oil pressure. No lights were on at the time of service.

Filed Aug 27, 2026 · Fuel system · NY

I was traveling down the highway at approximately 55mph when truck suddenly lost power. I was able to pull over and had the vehicle towed as truck would not start. It was later determined that the cp4 high pressure fuel pump grenaded causing complete fuel system replacement costing over $11,000 in repairs. Shards of aluminium was sent throughout the fuel system.

Filed Mar 31, 2026 · Engine, Fuel system · NM

Vehicle experienced loss of power while in travel down a mountain. After inspection by a mechanic, CP4 pump had a catastrophic failure sending metal shards throughout the fuel system. This was less than a month after Fords SAFETY RECALL 24S78 that failed to remedy the problem, but before recall Number26V158 was issued.

Filed Mar 28, 2026 · Fuel system · NH

02/04/2026 69k miles. I brought my vehicle in because I got a check engine light on the dash and had loss of power. Was informed that my fuel pump had failed and sent metal shards through the whole fuel system. The damage was covered by the recall, which also included reprogramming of the tcm and pcm. Was then told that the reflash of those systems was a failure, and that the Ford Motor Company was working on a remedy. My dealership has since completed a full fuel system replacement, and there still isn't a fix for the programming issue. This is a revenue generating vehicle, and the only one, for my small business. I lost many clients due to inability to perform the work I was contracted to do. My dealership did offer me a loaner vehicle, but it's not one that can perform the work that my truck was able to do, and was told not to use the vehicle for any commercial work or towing, as thats not allowed. Ive reached out to customer relations to get updates, and have had no help from them, save for telling me they're working on it, and will hope to have a remedy soon.

Filed Mar 2, 2026 · Driver assistance, Fuel system · 95,000 miles · SC

The contact owns a 2020 Ford F-250. The contact received notifications of the federal safety agency Campaign Numbers: 24V957000 (Fuel System, Diesel) and 25V686000 (Back Over Prevention); however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The contact stated that the check engine warning light was intermittently illuminated. The contact stated that while driving at various speeds, the vehicle unintendedly decelerated and lost power. The vehicle was coasted to the side of the road, turned off, restarted, and the vehicle regained power and drove as intended. The message "Power Reduced” was displayed. The failure occurred approximately every 5 miles driven. The vehicle was taken to the dealer and was diagnosed with low fuel pressure, and it was determined that the fuel pump had failed and needed to be replaced. The vehicle had not been repaired because parts were not available. The manufacturer was not made aware of the issue. The failure mileage was approximately 95,000.

Filed Feb 11, 2026 · Fuel system · 120,050 miles · FL

The contact owns a 2020 Ford F-250. The contact stated that while driving at an undisclosed speed, the check engine and loss of power warning lights were illuminated. In addition, the vehicle sputtered. The vehicle was driven to the shoulder of the road. The vehicle was then towed to an independent mechanic, where it was diagnosed with fuel systems failure. The contact was informed that the fuel system needed to be replaced. In addition, the contact was informed that a complete fuel system and maintenance needed to be performed to fix the vehicle. The vehicle was repaired. The contact received notification of the federal safety agency Campaign Number: 24V957000 (Fuel System, Diesel); however, the part was not yet available. The dealer was made aware of the failure. The contact was informed that the recall was not associated with the VIN. The manufacturer was not made aware of the failure. The failure mileage was approximately 120,050.

Filed Feb 11, 2026 · Fuel system · GA

the federal safety agency Complaint Text (Copy/Paste) Vehicle: 2020 Ford F-250 Super Duty 6.7L Power Stroke Recall: 24S78 – Powertrain Control Module (PCM) Software Update Complaint: Ford has issued Recall 24S78 for the high-pressure fuel pump defect on my 2020 F-250, but the company has not provided an actual remedy. The recall shows as open on my VIN, and Ford’s documentation says a PCM software update is the fix, but Ford released the software and then pulled it back within a week. My dealership confirmed Ford removed the remedy from their system, so they cannot perform the recall at all. This leaves my truck exposed to a known safety defect with no available repair. The high-pressure fuel pump failure this recall addresses can cause sudden loss of power, engine stall, or complete shutdown while driving. Until a working remedy is released, I’m driving a truck that Ford has admitted has a serious safety defect, but they have not provided any fix or timeline. I am requesting the federal safety agency investigate why the remedy was withdrawn, why no replacement remedy has been provided, and why Ford is leaving owners with a known safety risk for an extended period. This is an expensive vehicle, and the defect can cause catastrophic engine damage and create a hazardous situation on the road. Owners deserve an effective recall remedy that is actually available. Not exactly sure when the recall was first brought to light but I do know it has been months now.

Filed Feb 9, 2026 · Engine, Fuel system · FL

While driving cross country, my dash warning light came on and said " In 50 miles your vehicle will lose power and you won't be able to drive more than 5 mph. DEF problem". I spent $70,000 on this vehicle used with 50K miles on it. Recall from 2024, this is unacceptable. Now another recall for steering. The steering column disengagement. I am afraid to drive it. The dealer keeps telling me no fix yet. FORD has no email to complain. I am not sure what can be done. This is my first FORD, never again.

Filed Nov 20, 2025 · Fuel system · CA

I am filing a complaint regarding a safety defect on my 2020 Ford F-250 (VIN: [XXX] ), which is included in the federal safety agency Recall 24V‑957 (Ford Recall 24S78). I received Ford’s recall notice prior to the failure of the high-pressure fuel pump. When I contacted Ford at that time, I was informed that the recall remedy was not yet available. In March 2025, the high-pressure fuel pump failed suddenly while I was transporting livestock in a towed trailer with my three children in the truck. The vehicle experienced an abrupt loss of power in traffic and became unable to move. We had to remain stopped until a tow truck arrived, creating a significant safety hazard for my family and other drivers. The Ford dealer documented the failure as “high pressure pump froze up and cracked high pressure pump,” which caused metal contamination throughout the fuel system and required complete replacement of the pump, injectors, rails, lines, and a fuel tank flush. The total repair cost was $16,574.44, which I paid out of pocket. Ford has stated they cannot process reimbursement until the recall remedy becomes available, despite federal regulations allowing reimbursement for repairs completed after notification of a safety defect. I am requesting the federal safety agency’s assistance in ensuring Ford complies with the recall reimbursement requirements and continues to monitor this defect due to the sudden and dangerous nature of these failures. Thank you for your attention. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 28, 2025 · Fuel system · UT

We have had this truck a total of two months. The dealer told us that there were not recalls on it, come to find out there are two. The recalled part froze up and shattered that shot metal shavings all through the fuel system. This caused the truck to lose all power and shut down on a busy road which could have led to a major accident had it not been after rush hour. After towing the truck to a repair shop, we found out about the recalls. Come to find out, the warranty company nor Ford will pay to fix the vehicle due to nothing available. How are we the consumer liable for this when it is under recall and Ford has been working on a fix for a year? We have been told a fix would be around $10,000.

Filed Sep 24, 2025 · Transmission · OK

AT 107,000 I lost 10th gear on the highway while pulling a trailer and was almost involved in a collision. The collar of the f250 10 speed is just as bad as the 2018 10 speed on f150s and they are failing at 100k. Complete new transmission needed. This should be recalled and i should be refunded. This is insanely dangerous to lose power while driving

Filed Jul 26, 2025 · Engine, Fuel system · AZ

My truck lost power on the Highway. Had to coast down the off-ramp and ended up blocking a turning lane when the engine failed to start back up. Called a someone to tow me back to my house and parked it where it’s been there for months since Ford has not yet issued a solution to the recall.