2022 Ford F-250 SD: engine failure

Filed Nov 4, 2026 · Engine · ND

My pickup has 97,000 miles and has a catastrophic engine failure. Cylinder 6 has failed which is from a lifter due to the insignificant oil pressure at idle. Ford new about this and after the fact tried to "fix" with a software update to increase the idle.

Filed Oct 26, 2026 · Fuel system, Transmission · LA

My vehicle has been at Ford of Harvey since 8/31/26. Dealer replaced ignition coil 8/18/26. Light and rough idle returned and the dealer determined a new engine would be needed. Dealer says Ford warranty only wants to replace cam shaft. Metal in oil was found and dealer has fought corporate warranty for over a month, ripping apart my engine. The fear is engine could seize at highway speeds as a result of internal damage.caused by circulating debris. Truck still sits at dealer.

Filed Jul 7, 2026 · Fuel system · 53,000 miles · NY

The contact owns a 2022 Ford F-250. The contact received a recall notification of the federal safety agency Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that while the contact's husband was driving at an undisclosed speed, the accelerator pedal was depressed, but the vehicle failed to accelerate as intended and lost motive power. The vehicle was driven to the shoulder of the road, and the engine seized. The check engine warning light was illuminated. The driver attempted to restart the vehicle, but the vehicle failed to restart. The vehicle was towed to the dealer, where it was diagnosed with a failed fuel pump. The contact was informed that the fuel pump needed to be replaced. The vehicle was repaired; however, the failure recurred while traveling out of the State on vacation, with a trailer hitched to the vehicle. Additionally, the contact stated that the outside temperature was extremely hot, and the tow truck operator took three hours to arrive. The manufacturer was not made aware of the failure. The failure mileage was approximately 53,000.

Filed Jun 9, 2026 · Electrical, Engine · WI

10 day roundtrip from [XXX] to [XXX]. 5 incidents of catastrophic engine failure on interstates. Truck started to jerk, sputter, lost power at an alarming rate. No engine light until failure ocurred. Very dangerous with heavy holiday traffic. Lives were in danger, us and other vehicles around us. No one expects travel to go from 70 mph,to 50, 30, 15 in such a short period of time. Pulled over to "investigate" code failures we deemed as o2 sensors. Afterwards the truck started back up, no engine lights and drove as normal. Started using premium gasoline, hoping it would help. Started driving in right lane as much as possible but had a failure ocurr right in front of on ramp as well at interstate speeds. Had another family following us so they also witnessed and pulled over all incidents. Brought into Ford 7/18/24 upon return home. Paid $125 inspection fee, concern not present, come back if happens again. Makes no sense that codes not present to pull. 12/13/2024 engine light on, catalytic converter replaced. 06/19/25 truck had catastrophic failure returning from work on hwy. XXX on [XXX], just two miles from leaving home another failure with no warning lights in heavy Friday traffic in construction zone. Couldn't clear the traffic lane completely. Very scary. Waited for clearing and limped it to a nearby off ramp. Same jerking, loss of power. Vehicle towed to shop for 2 weeks, testing, fuel pump replaced. Picked up 07/07/25. Next day received recall notice 25S75 in the mail 7/08/25. Everything made sense. 1/24/26 - Battery failed inspection @ 40% during oil change. Replaced battery ourselves from Costco. 04/23/26- Warning light, P0420 pulled, shop recommended engine tune -up. Paid $175 inspection fee + $671.20 tune up. 5/29/26 engine light on, P0420 pulled, recommend catalytic convertor replaced but not under factory warranty anymore so wants us to pay $4000 bill. Escalated up through Ford. As of 6/5/26 - Ford will pay half. I refuse. Should be covered by recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF I

Filed Mar 6, 2026 · Engine · 70,000 miles · NY

The contact owns a 2022 Ford F-250. The contact stated that while driving on several occasions at various speeds, the vehicle was driving sluggishly while accelerating, the RPM fell, and the vehicle lost motive power. The check engine warning light was illuminated. The vehicle was taken to a dealer and was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The spark plugs were replaced, and a tune-up was performed; however, the failure persisted. The vehicle was then taken to an independent mechanic to be diagnosed. The contact was informed that there was a misfire coming from the engine and that the ignition wires needed to be replaced. The vehicle was repaired, but the failure persisted. The manufacturer was notified of the failure. The failure mileage was approximately 70,000.

Filed Oct 18, 2025 · Engine · MD

The failed component is a lifter/camshaft. Luckily I was attentive to my vehicle and noticed a ticking noise within the engine and took it to a dealer for diagnosis. An engine failure while traveling at highway speeds could be a disastrous to occupants and others around them. This appears to be a common problem with the 7.3l engine. The check engine light illuminated after i noticed the ticking noise.