2016 Ford F-250 SD: loss of power steering

Filed Nov 23, 2024 · Suspension · TX

The truck began to suddenly shake fiercely while driving in the highway. The steering became difficult to control for about 2 or more minutes. We looked this up and it is termed the Death Wobble. Our F250 truck is a 2016. This is dangerous and needs to be Recalled for this year of F250 - 2016

Filed Feb 6, 2024 · Brakes, Driver assistance · OH

Vehicle has 44,000 miles, has never been wrecked in any way. Recently the advance trac system began displaying a fault at random. The light would come and go. At the time the fault light was active the turn signals did not operate normally. A message noted to service advance trac system. ( which is related to the abs) I noticed, once, the abs activate momentarily for no apparent reason. I narrowed the fault down to the steering wheel angle sensor. I had a Ford service center confirm the issue was the steering angle sensor. The sensor was on a backorder. I called around and other dealers confirmed. A week later while entering a cloverleaf and slowing down the system faulted, illuminated the error, and the abs activated. The brake system applied brakes unevenly pulling the vehicle to the left then right and aggressively slowing down without driver brake input. I had to fight to control the vehicle to prevent losing control or get rear ended. The roads were clean, dry, and it was daylight. Upon that i could see the complete loss of steering wheel angle sensor input. The dash can show this readout. Without the steering wheel angle input the system, which is to prevent accidents, nearly caused one. I tried turning off the advance trac via the traction control button, this was ineffective. I had to remove the abs pump fuse to get home safely. This system should not in any way be able to cause this severe loss of vehicle control simply due to the loss of one sensor. This is absolute unsafe software protocall. Attatched are images of the sensor reading then no place holder for it when it does not read.

Filed Oct 4, 2023 · Airbags, Electrical · 120,000 miles · TX

The contact owns a 2016 Ford F-250. The contact received notification of the federal safety agency Campaign Number: 22V337000 (Air Bags); however, the part to do the recall repair was not yet available. The contact stated while driving and making a turn into the driveway, the steering wheel lost power steering functionality inadvertently and made a clicking sound. The airbag warning light was illuminated. The contact stated that the failure persisted. The vehicle was taken to the local dealer and to a secondary dealer, Bill Utter Ford (4901 S Interstate 35 E, Denton, TX 76210), where it was diagnosed that the failure was related to the recall. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and informed the contact that the parts were not yet available. The failure mileage was approximately 120,000. Parts distribution disconnect.

Filed Oct 3, 2023 · Engine, Fuel system · AR

I was attempting to access the interstate when my truck began to immediately shut down at 70 miles per hour. I received a warning as the engine shut down stating that my engine power was reduced. At the exact moment the message displayed, the truck immediately died at 70 mph leaving me to be forced to wrestle the steering wheel to maneuver the truck to the side of the interstate as I had no power steering due to the failure. I have been informed that my truck is a victim of a catastrophic engine failure as a result of a failed CP4 OEM Bosch high-pressure fuel pump. The failure has resulted in the complete contamination of the fuel system requiring a complete overhaul with parts cost at $6,600.00 and approximately $4,000.00 in labor for a total of more than $10,600.00. on a low mileage diesel.

Filed Sep 24, 2023 · Steering, Suspension · OK

DEATH WOBBLE! Driving at any speeds from 30 MPH to highway speeds of 65-70 MPH, the front end (front suspension) of the truck will Wobble Uncontrollably in a Vehement and Violent Manner, making driving unsafe with loss of steering after hitting a small bump or dip in the road/highway. The condition is worse when pulling a 30 foot gooseneck trailer. I have replaced the front shocks, steering damper, and rear shocks and to no avail, the Death Wobble still occurs! This is Major Safety Concern and Life Threatening to myself and anyone on the road during the Death Wobble, and seeing the reaction of other drivers in the opposite direction should be cause for concern! My truck is at a dealer now for inspection of the front end suspension system (drag link, track bar, tie rod ends, ball joints, bushings, tires, and alignment), to include the engine mounts, which were worn and deteriorating (I noticed this when I was replacing my steering damper) probably from the Death Wobble. The tires were balanced and rotated on September 9th by Discount Tire and the technicians there didn't see any problems with the tires or the wheels. I get my tires balanced and rotated about every 7,500 miles and I keep an accurate vehicle history of my truck.

Filed Aug 18, 2020 · Steering · 104,000 miles · AL

Upon hitting a bump in the road at highway speeds the truck started shaking in the front end. In another instance I was accelerating to highway speeds and the truck started violently shaking at about 65mph, steering was difficult I had to slow down and stop on the shoulder for it to stop. I was able to start driving again after slowly accelerating along the shoulder then merging back into traffic. I noticed that it appears whenever I even hit a minor road defect I feel a slight vibration.